Transport Canada recall 2023421
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2023421 |
| Manufacturer's number | RC182 |
| Reported | 2023-08-01 |
| Component | Powertrain |
| Notification type | Safety Mfr |
| Units potentially affected | 10758 |
What is wrong
Issue:
On certain vehicles, the circuit board in the electric oil pump assembly for the transmission may be damaged. As a result, the circuit board could short circuit and overheat.
Safety Risk:
A short circuit could create the risk of a fire.
Corrective Actions:
Kia will notify owners by mail and advise you to take your vehicle to a dealership to inspect the transmission electric oil pump assembly, and replace it as necessary. Kia recommends parking your vehicle outside and away from other vehicles or buildings until the recall repairs are completed.
| 2023 KIA SELTOS | |
|---|---|
| 2024 KIA SELTOS | |
| 2023 KIA SOUL | |
| 2023 KIA SPORTAGE |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| TSB_TRA114 | 2025-06-11. Service bulletin. TECHNICAL SERVICE BULLETIN: AWD/4WD COUPLING ACTUATOR REPLACEMENT (CA2503) - This bulletin provides information related to the Technical Service Bulletin previously published under ELE374, titled ‘Service Action: AWD Coupling Actuator Logic Improvement (SA605)’. If the affected vehicles experience a loss of AWD capability (FWD continues to operate but there is no power sent to the rear wheels) accompanied by a warning message on the instrument cluster “Check AWD/4WD System” and the Malfunction Indicator Lamp (MIL) illuminated with DTCs P195800 and P196000 stored AFTER the AWD Coupling Actuator Logic Improvement has been installed per ELE374/SA605, follow the instructions outlined in this publication to replace the AWD Coupling Actuator on the applicable vehicle. |
|---|---|
| TSB_ELE374 | 2025-05-22. Service bulletin. TECHNICAL SERVICE BULLETIN: AWD COUPLING ACTUATOR LOGIC IMPROVEMENT (SA605) - This bulletin provides information to upgrade the 4-Wheel Drive (“4WD”) system software on certain 2024-2025MY Seltos (SP2) vehicles equipped with All-Wheel Drive (“AWD”) produced from February 14, 2023 through October 08, 2024. The affected vehicles may experience an interruption of supplementary power to the rear wheels, while normal motive power continues to be available to the front wheels, accompanied by the warning message “Check AWD/4WD System” on the instrument cluster and with the Malfunction Indicator Lamp (MIL) illuminated with DTCs P195800 and P196000 stored. |
| TSB_TRA046_R5 | 2025-04-23. Service bulletin. TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, and the transmission oil cooler is transferred to the new transmission. |
| SC297_OWNR_201 | 2025-04-10. Service campaign. VOLUNTARY SERVICE CAMPAIGN: OWNER RENOTIFICATION (SC297) - This document is the owner renotification advising that Kia conducting a Voluntary Service Campaign to inspect and, if necessary, replace the AWD Control Unit in certain 2021-2023 MY Seltos all-wheel drive (AWD) vehicles that were originally sold in or are currently registered in one of the 36 states or District of Columbia with significant snowfall. Kia dealers will also install a cover over the AWD Control Unit for improved protection against water intrusion. |
| TSB_TRA113 | 2024-10-01. Service bulletin. TECHNICAL SERVICE BULLETIN: PRECAUTIONS FOR TRANSMISSIONS WITH ISG/EOP - This bulletin provides information related to the replacement or servicing of transmission assemblies on all Kia vehicles equipped with Idle-Stop-Go (ISG) and High-Flow Electric Oil Pump (HF EOP). The HF EOP protective connector cover may NOT have been installed on a new or remanufactured transmission during assembly. The HF EOP connector may become contaminated with debris during shipping and/or with oil/coolant during installation. |
| TSB_TRA109 | 2024-07-18. Service bulletin. TECHNICAL SERVICE BULLETIN: IVT OIL PRESSURE SENSOR REPLACEMENT: This bulletin provides information to replace the Intelligent Variable Transmission (IVT) Oil Pressure Sensor (OPS) on some 2018-2024MY vehicles listed on page 3 equipped with IVT. The affected vehicles may exhibit a malfunction indicator lamp (MIL) illuminated on the instrument cluster with DTCs P084500, P084600, and/or P0867XX present with no drivability concerns due to a failed IVT oil pressure sensor. |
| TSB_TRA046_R4 | 2024-06-04. Service bulletin. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced. |
| TSB_TRA108_R1 | 2024-05-06. Service bulletin. TECHNICAL SERVICE BULLETIN: 4WD COUPLING ACTUATOR ASSEMBLY REPLACEMENT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to replace the AWD coupling actuator assembly on some 2021-2024MY Kia AWD models listed on page 4. The affected vehicles may exhibit an inoperative AWD system (also referred to as 4WD) capability concern which may be caused by abnormal wear of the motor brushes inside the actuator assembly. This condition will cause the warning lamps on the instrument cluster to illuminate with stored DTC(s) P195800 and/or P19600. |
| SC297_TSB | 2024-05-06. Service bulletin. TECHNICAL SERVICE BULLETIN: VOLUNTARY SERVICE CAMPAIGN: 4WD ECU INSPECTION/REPLACEMENT (SC297) - This bulletin provides information to inspect and, if necessary, replace/repair the 4WD Electronic Control Unit (ECU) and wire harness and also to install a protective cover over the 4WD ECU on certain 2021-2023MY Seltos (SP2) All-Wheel Drive (AWD) vehicles produced from November 20, 2019 through March 2, 2023 that were originally sold or are currently registered in one of 36 states and the District of Columbia with significant snowfall (AK, CO, CT, DC, DE, IA, ID, IL, IN, KS, KY, MA, MD, ME, MI, MN, MO, MT, ND, NE, NH, NJ, NM, NV, NY, OR, OH, PA, RI, SD, UT, VA, VT, WA, WI, WV, and WY). In the 36 states and District of Columbia with significant snowfall, snow may be tracked into the driver’s footwell area. Meltwater from this snow may enter the 4WD ECU located under the driver’s seat and, over time, damage the 4WD ECU circuit board components. This can lead to the illumination of the 4WD Warning Light and deactivation of the vehicle’s 4WD feature. If this occurs, the vehicle can continue to be driven in the front-wheel drive mode. This service campaign is to improve protection of the 4WD ECU against water intrusion. |
| SC297_OWNR | 2024-05-06. Service bulletin. VOLUNTARY SERVICE CAMPAIGN: OWNER NOTIFICATION (SC297) - This document is the owner notification advising that Kia is conducting a Voluntary Service Campaign to inspect and, if necessary, replace the AWD Control Unit in certain 2021-2023 MY Seltos all-wheel drive (AWD) vehicles that were originally sold in or are currently registered in one of the 36 states or District of Columbia with significant snowfall. Kia dealers will also install a cover over the AWD Control Unit for improved protection against water intrusion. |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.