Transport Canada recall 2023147
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2023147 |
| Manufacturer's number | R0235 (30CC05) |
| Reported | 2023-03-17 |
| Component | Electrical |
| Notification type | Safety Mfr |
| Units potentially affected | 1897 |
What is wrong
Issue:
Certain vehicles may be equipped with a 4-pin accessory trailer wiring harness kit that could fail. Over time, this could result in a short circuit that can cause the control module to overheat.
Note: This recall only affects Hyundai Genuine 4-pin tow hitch wiring harness kits with the part number S2F67-AC401. These kits may have been ordered at the time of a vehicle purchase or purchased separately from a dealer as an aftermarket accessory.
Safety Risk:
A short circuit can create a fire risk, even while the vehicle is parked and turned off.
Corrective Actions:
Hyundai will notify owners by mail and instruct you to bring your vehicle to a dealership to inspect the vehicle for a trailer wiring harness kit. If necessary, the dealer will install a 15A fuse and a wire extension kit. Hyundai advises that if your vehicle has a tow hitch harness installed, you should park it outdoors, and away from other vehicles or structures until the recall repairs have been completed.
| 2022 HYUNDAI SANTA CRUZ | |
|---|---|
| 2023 HYUNDAI SANTA CRUZ | |
| 2019 HYUNDAI SANTA FE | |
| 2020 HYUNDAI SANTA FE | |
| 2021 HYUNDAI SANTA FE | |
| 2022 HYUNDAI SANTA FE | |
| 2023 HYUNDAI SANTA FE |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| 26-BE-001H-2 DCS | 2026-10-06. Warranty extension. Some vehicles may have an inoperable horn that may be caused by foreign substances causing internal parts to oxidize. Hyundai is extending the warranty coverage for the horn replacement under this condition to 10 years or 120,000 miles from the date of original retail delivery or date of first use (whichever occurs first) and is valid for original and subsequent owners. If a horn needs to be replaced, follow the instructions within this Technical Service Bulletin (TSB)26-BE-001H-2 to install the latest design. Please note that any vehicles under 10 years/120,000 miles are covered by this TSB, even if vehicle is with original warranty of 5 years/60,000 miles. |
|---|---|
| 26-BE-001H-2 TSB | 2026-10-06. Warranty extension. Some vehicles may have an inoperable horn that may be caused by foreign substances causing internal parts to oxidize. Hyundai is extending the warranty coverage for the horn replacement under this condition to 10 years or 120,000 miles from the date of original retail delivery or date of first use (whichever occurs first) and is valid for original and subsequent owners. If a horn needs to be replaced, follow the instructions within this TSB to install the latest design. Please note that any vehicles under 10 years / 120,000 miles are covered by this TSB, even if vehicle is within original warranty of 5 years / 60,000 miles. |
| 26-GI-002H TSB | 2026-06-06. Service bulletin. This bulletin provides information related to the navigation and head unit software changes introduced in the 2026 1st Navigation Map and Software Update. The changes may vary depending on vehicle type, model, and navigation system. Refer to the 2026 1st Navigation Map and Software Update Key Improvements and Additional Improvements tables in this TSB for a list of specific changes. The software can be downloaded via Navigation Updater (NAU) and updated by USB. |
| 9C2 060518 | 2026-06-06. Service campaign. Following completion of Service Campaign 9C2 (Theta II Emissions Improvement), certain vehicles may exhibit a brief hesitation or rough shifting condition during cold start operation. If present, this condition is expected to occur only within approximately the first 1-3 minutes after engine start, while the catalyst is reaching its normal operating temperature. |
| 9C2 DCS 260518 | 2026-06-06. Service campaign. Following completion of Service Campaign 9C2 (Theta II Emissions Improvement), certain vehicles may exhibit a brief hesitation or rough shifting condition during cold start operation. If present, this condition is expected to occur only within approximately the first 1-3 minutes after engine start, while the catalyst is reaching its normal operating temperature. |
| 26-01-013H-2 DN | 2026-06-06. Service campaign. Certain Santa Fe (TMA), Santa Fe Sport (AN), Sonata (LFA), and Tucson (TL) vehicles equipped with Theta II engines may exhibit elevated engine-out emissions. The California Air Resources Board has determined that these vehicles may be releasing air pollutants which exceed Federal and California standards. |
| 26-01-013H-2 TSB | 2026-06-06. Service campaign. Certain Santa Fe (TMA), Santa Fe Sport (AN), Sonata (LFA), and Tucson (TL) vehicles equipped with Theta II engines may exhibit elevated engine-out emissions. This bulletin provides instructions for updating the Engine Control Module (ECM) to address this condition. |
| Z01 Letter | 2026-06-06. Warranty extension. Certain 2012 – 2017 model year Accent, 2012 – 2017 model year Azera, 2013 – 2018 model year Santa Fe Sport, 2013 – 2019 model year Santa Fe, and 2012 – 2017 model year Veloster vehicles may exhibit an intermittent airbag warning light and diagnostic trouble codes (DTCs) may be set. At Hyundai, we are committed to providing vehicles of outstanding quality and value. In an effort to meet this commitment, the warranty coverage for the Occupant Classification System (OCS)/Occupant Detection System (ODS) under these conditions has been extended to 18 years/unlimited mileage from the date of original retail delivery or date of first use (whichever occurs first) and is valid for original and subsequent owners. |
| 26-EE-003H TSB | 2026-04-21. Service bulletin. Some vehicles may exhibit difficulty starting in cold weather. This bulletin provides the procedure to perform an inspection on the starter magnetic switch for potential freezing and, if necessary, replace the starter magnetic switch (solenoid) assembly. |
| 25-01-089H DCS | 2026-01-06. Other. Upon customer's request ONLY, the Technical Service Bulletin (TSB) 25-01-089H provides the service procedure for installation of a key cylinder reinforcement protector assembly and two anti-theft decals on the front windows. This repair procedure is being provided in addition to the previous Anti-Theft software provided under Service Campaign 993 (TSB 24-01-009H-1). |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.