Transport Canada recall 2020040
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2020040 |
| Manufacturer's number | 4320A |
| Reported | 2020-02-06 |
| Component | Lights And Instruments |
| Notification type | Safety Mfr |
| Units potentially affected | 6983 |
What is wrong
Issue:
On certain vehicles equipped with LED daytime running lights (DRLs), the wrong material was used for the gasket that seals the wiring connector. As a result, the gasket material could cause corrosion of the circuit board. This could cause one or both of the DRLs to flicker and/or fail.
Safety Risk:
Daytime running lights that do not work could make the vehicle less visible to others and increase the risk of a crash.
Corrective Actions:
Mazda Canada will notify owners by mail and instruct you to take your vehicle to a dealer for an inspection. Dealers will replace the sealing gasket and add an anti-corrosion material inside the headlights, as necessary. Dealers may also replace the headlight units if they have failed due to this problem.
| 2016 MAZDA CX-5 |
|---|
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| SA-010-23 | 2023-03-03. Service bulletin. Some customers may experience one or more electrical malfunctions after a vehicle body repair. The newly painted fender stay (2) may be causing a poor front harness (1) ground connection. |
|---|---|
| 0901416 | 2022-06-06. Service bulletin. White Milky stains on inner surface of headlight lens |
| 0900316 | 2022-06-06. Service bulletin. Condensation/Fog in front and rear combination lights |
| 0800116 | 2022-06-06. Service bulletin. Passenger fAirbag deactivation (PAD) indicator light illumination |
| SA-036-21 | 2021-06-03. Service bulletin. Some vehicles may have one of the following DTCs stored in memory along with a system status notice on the Multi-information display OR display a system status notice with no DTC: C1001:92 - Forward sensing camera (FSC) poor field of view [Gen 6 vehicles], B14F0:92 - General temporary failure in forward sensing camera (FSC) [Gen 7 vehicles build on or before March 2, 2019], No DTC - Gen 7 vehicles built after March 2, 2019, DTC C1001:92 or B14F0:92 set as a past record for low visibility of the Forward Sensing Camera (FSC). It does not mean there is an actual FSC defect. In some cases the customer may have a concern with the Lane Departure Warning System (LDWS) and/or High Beam Control system (HBC). In other cases this DTC might be found without a related customer concern. |
| 09-014-16-3132a | 2021-01-28. Service bulletin. Some vehicles equipped with LED or Discharge type headlights may exhibit white milky stains on the inner sur-face of the headlight lens. Some customers may complain of the poor appearance. This concern is caused by gas that emits from a gasket in the lamp unit. The gas adheres to the inner surface of the headlight lens and reacts with the anti-clouding coating and moisture in the air to create white milky stains. The gasket material has been improved to eliminate this concern. |
| 09-010-19-3624 | 2019-08-15. Service bulletin. Some customers may experience one or more electrical malfunctions after a vehicle body repair. The newly painted fender stay (2) may be causing a poor front harness (1) ground connection.The front fender stay (2) newly painted surface at ground point (3), where attachment bolt (4) is seated, may create a poor front harness ground connection. Customers concern can be resolved by sanding off paint at ground point (3) where attachment bolt (4) is seated. After installing the bolt (4), apply touch-up paint to the exposed base material area of the front fender stay. |
| 09-003-19-3555a | 2019-03-20. Service bulletin. Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear (taillamp/taillight) combination lights. The recent new models have been fitted with a clear lens which can cause the symptom to be more noticeable, however, it does not affect the performance of the light. This condensation/fog is a natural phenomenon that occurs when there is a fairly large temperature difference between the inside and the outside of the light housing. It is normal for very small water drops to appear in certain locations on the light units where the air is stagnant (condensation), making the lens look whitish (fog). This happens mostly in the corners and narrow spaces, and will typically clear during warmer ambient temperatures, or when the lights have been on for some time. |
| 09-003-19-3555 | 2019-02-19. Service bulletin. Some customers may complain of condensation/fog inside the front (headlamp/headlight) or rear (taillamp/taillight) combination lights. The recent new models have been fitted with a clear lens which can cause the symptom to be more noticeable, however, it does not affect the performance of the light. This condensation/fog is a natural phenomenon that occurs when there is a fairly large temperature difference between the inside and the outside of the light housing. It is normal for very small water drops to appear in certain locations on the light units where the air is stagnant (condensation), making the lens look whitish (fog). This happens mostly in the corners and narrow spaces, and will typically clear during warmer ambient temperatures, or when the lights have been on for some time. |
| SA-023-18 | 2018-07-02. Service bulletin. Some vehicles may have DTC C1001:92 stored in memory. DTC C1001:92 sets as a past record for low visibility of the Forward Sensing Camera (FSC). It does not mean there is an actual FSC defect. In some cases the customer may have a concern with the Lane Departure Warning System (LDWS) and/or High Beam Control system (HBC). In other cases this DTC might be found without a related customer concern.NOTE: Instrument Cluster Multi-Information Display Warning Messages vary depending on vehicle year/model. See the Owner's Manual for details. |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.