Transport Canada recall 2019095
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2019095 |
| Manufacturer's number | R0152 (91C012) |
| Reported | 2019-02-27 |
| Component | Engine |
| Notification type | Safety Mfr |
| Units potentially affected | 31303 |
What is wrong
Issue:
The engine oil pan seal could leak on some vehicles with a 2.4 L engine. If the leak is not repaired, over time this could lead to engine damage or an engine failure. An engine failure would cause a sudden loss of motive power with an inability to restart.
Safety Risk:
A sudden loss of motive power could increase the risk of a crash. In some cases, an engine failure may also result in a fire.
Corrective Actions:
The company will notify owners by mail. Hyundai dealers will replace the vehicle’s engine oil pressure switch with a new one. Dealers will also inspect the engine’s oil pan, and if necessary, replace the oil pan.
Note: A driver may notice any of the following symptoms before an engine failure: an oil leak under the vehicle, a smell of hot or burning oil, a knocking sound from the engine, reduced power or hesitation, a check engine light, and/or an oil pressure warning light.
| 2011 HYUNDAI TUCSON | |
|---|---|
| 2012 HYUNDAI TUCSON | |
| 2013 HYUNDAI TUCSON |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| 26-EM-016H TSB | 2026-10-14. Service bulletin. Some vehicles equipped with internal combustion engines may exhibit higher-than-expected engine oil consumption. This bulletin outlines the combustion chamber cleaning procedure for vehicles diagnosed with this condition. All internal combustion engines consume some engine oil during normal operation, depending on driving conditions and mileage, and this procedure should only be performed when deemed necessary based on inspection and diagnosis of the vehicle as outlined in TSB 26-EM-015H, Engine Oil Consumption – Inspection & Repair Guidelines, or the latest revision. |
|---|---|
| 26-EM-015H TSB | 2026-10-13. Service bulletin. Certain vehicles equipped with internal combustion engines may exhibit higher-than-expected engine oil consumption. This bulletin provides the inspection and repair procedures for vehicles exhibiting this condition. All internal combustion engines consume engine oil as part of normal engine operation. Oil consumption rates may vary based on mileage, operating conditions, driving habits, and maintenance history. Hyundai recommends following the prescribed maintenance schedule and periodically checking the engine oil level using the dipstick to maintain proper engine oil level. |
| 26-01-033H TSB | 2026-03-31. Warranty extension. This TSB references the Op codes to use for claim submission and the Parts required based on the vehicle’s inspection results from TSB 22-01-023H-2 (DTC P1326 – Engine Bearing Inspection/Engine Replacement) or the latest version. |
| 26-01-033H DN | 2026-03-30. Warranty extension. This TSB references the Op codes to use for claim submission and the Parts required based on the vehicle’s inspection results from TSB 22-01-023H (DTC P1326 – Engine Bearing Inspection/Engine Replacement) or the latest version. |
| 24-01-068H | 2024-09-03. Service campaign. Hyundai is conducting a campaign to enhance the knock sensor software to detect abnormal engine bearing noise before potentially severe engine damage occurs. If abnormal engine bearing noise is detected, the Malfunction Indicator Lamp (MIL) will blink continuously, and the vehicle will be placed in Engine Protection Mode allowing the customer to drive to the nearest Hyundai dealer for diagnosis and repair. In addition, DTC P132600 will be recorded in the ECM. The vehicle can continue to be operated for a limited time in Engine Protection Mode, but it will accelerate slower and have a reduced maximum speed. Engine RPMs will be limited to approximately 1800-2000 RPM. |
| 23-EM-005H | 2023-12-15. Service bulletin. This bulletin provides important checkpoint guidelines when performing engine oil and filter change services. |
| 22-01-023H-2 | 2023-08-02. Service bulletin. A class action lawsuit against Hyundai Motor America (“HMA”) alleges that certain Hyundai vehicles (“Class Vehicles”) were manufactured, marketed, sold, and/or leased with an engine defect that can result in sudden engine seizure, stalling, engine failure, and in some circumstances, engine fire, and that some owners and lessees of Class Vehicles have been improperly denied repairs under warranty. Neither HMA nor Hyundai Motor Company have been found liable for any of the claims alleged in the lawsuit. The parties have instead reached a voluntary settlement (the “Settlement”) to avoid lengthy litigation and to provide owners of Class Vehicles certain benefits. |
| 22-01-023H-2 | 2022-12-07. Service bulletin. Certain vehicles listed below may experience the Check Engine warning lamp illuminated with DTC P1326 and/or an engine concern/noise related to connecting rod bearing wear or damage. Follow the procedure to inspect the vehicle and replace the engine and/or update the engine ECU software (if new ROM is available) based on the inspection results. |
| 22-EM-006H-2 | 2022-12-07. Service bulletin. The warranty coverage for engine repair or replacement regarding engine damage or malfunction from connecting rod bearing wear has been extended to 15 years or 150,000 miles from the date of original retail delivery or date of first use, whichever occurs first, and is valid for original and subsequent owners. Commercial entities and individuals engaged in the buying, selling, leasing, or renting of motor vehicles, as well as salvaged vehicles, are ineligible for the extended warranty. |
| 22-01-024H-2 | 2022-12-07. Service bulletin. OP CODE/PART NUMBER (REFERENCE GUIDE FOR SERVICE CAMPAIGN T6G) |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.