Transport Canada recall 2018635
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2018635 |
| Manufacturer's number | 20BJ |
| Reported | 2018-11-19 |
| Component | Fuel System |
| Notification type | Safety Mfr |
| Units potentially affected | 113 |
What is wrong
Certain vehicles with a cracked (but not leaking) fuel pump flange were repaired with butyl tape only under a previous recall (please see Transport Canada Recall 2016-443 / Audi campaign 20W9). This is because replacement fuel pump flanges were not available at the time of repair (the butyl tape was used an interim repair). If the fuel pump flange is not replaced, a fuel leak could still occur. A fuel leak, in the presence of an ignition source, could lead to a fire causing injury and/or damage to property. Correction: Dealers will replace fuel pump flange and reapply the protective butyl tape.
| 2007 AUDI Q5 | |
|---|---|
| 2008 AUDI Q5 | |
| 2009 AUDI Q5 | |
| 2010 AUDI Q5 | |
| 2011 AUDI Q5 | |
| 2012 AUDI Q5 | |
| 2009 AUDI Q7 | |
| 2010 AUDI Q7 | |
| 2011 AUDI Q7 | |
| 2012 AUDI Q7 |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| TSB_2080186_1 | 2025-12-05. Service bulletin. This bulletin provides information when the MIL is on, DTC P310B00 in ECM; Vapor pocket formation in fuel system. |
|---|---|
| TSB_2042920_2 | 2025-07-08. Service bulletin. This bulletin provides information when there is corrosion on the exhaust tail pipes. |
| A0024902074853_1 | 2024-09-06. Service bulletin. This bulletin provides service information ror when the fuel tank cannot be fully filled. |
| A0024902074853_1 | 2024-09-06. Service bulletin. This bulletin provides service information ror when the fuel tank cannot be fully filled. |
| 0112562031368 | 2024-02-20. Service bulletin. Unnecessary High Pressure Fuel Pumps replacement due to Guided Fault Finding test plans not being performed or interrupted when the following DTC? s are present in the engine control module: |
| AWA1405 | 2024-01-22. Service bulletin. Due to new Minnesota state regulations regarding biofuels, biodiesel blends of B5 or less may not be available in the State of Minnesota. |
| Chart | 2023-10-10. Service bulletin. Audi Oil Capacity Chart |
| SM622013 | 2023-09-25. Service bulletin. Fuel Filter with Flange |
| A012341201475312 | 2023-03-06. Service bulletin. This bulletin contains instructions for when to add gasoline additives for cleaning the injectors. |
| 01146920366681 | 2023-01-03. Service bulletin. When diagnosing the condition listed above on a common rail diesel vehicle, if no root cause is found after all GFF diagnostic procedures have been performed, it may be necessary to check for metallic particles in the high pressure fuel pump using the procedure in the Service section of this bulletin. |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.