Transport Canada recall 2018135
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2018135 |
| Manufacturer's number | R0141 (81C016) |
| Reported | 2018-03-16 |
| Component | Powertrain |
| Notification type | Safety Mfr |
| Units potentially affected | 187 |
What is wrong
On certain plug-in hybrid vehicles, the battery Voltage Protection Device (VPD) switch could inadvertently activate. If the VPD switch is activated, electricity to the vehicle's electric motor may be disconnected. If this occurs while the vehicle is driven under Electric Vehicle (EV) mode, the vehicle may experience a loss of motive power, which could increase the risk of a crash causing injury and/or property damage. Correction: Dealers will remove the current VPD switch and install a newly designed battery management system module containing an overvoltage protection device. The corresponding wiring harness will also be installed. Note: This condition would result in the of the “Check Hybrid System" warning light illuminating.
| 2016 HYUNDAI SONATA | |
|---|---|
| 2017 HYUNDAI SONATA | |
| 2018 HYUNDAI SONATA |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| 24-AT-002H | 2024-04-16. Service bulletin. This TSB provides a procedure to diagnose and replace, if necessary, an automatic transmission with Incorrect Ratio DTC (transmission clutch slip in gear above limit) listed on Page 2. |
|---|---|
| 23-AT-003H-1 | 2023-09-06. Service bulletin. If you are servicing an 8-speed vehicle with a “Check Engine” light on and one or more of the DTC listed, follow the service procedure and replace the related solenoid and harness. |
| 23-01-014H-5 | 2023-09-06. Service bulletin. Hyundai has launched an anti-theft software upgrade and window decal campaign (Campaign 993), combined with an anti-theft steering wheel lock campaign (Campaign P32), in response to an increase in thefts of certain 2011-2022MY Hyundai vehicles not equipped with engine immobilizers targeted through social media. For certain vehicles that cannot be updated with the software (Campaign 993), Hyundai is offering customers steering wheel locks at the dealer (Campaign P32). This Dealer Best Practices Guide provides information to assist dealership personnel with customer questions relating to the immobilizer software upgrade, window decals and steering wheel lock ant-theft solutions available from HMA through Hyundai dealers. |
| 22-AT-007H | 2022-06-10. Service bulletin. Certain vehicles (listed below) equipped with 7-speed Double Clutch Transmissions (DCT) may exhibit abnormal vibration at low speeds. This bulletin outlines the procedures for diagnosing clutch judder, updating the Transmission Control Unit (TCU) with revised logic, and/or replacing the Double Clutch. |
| 22-AT-006H | 2022-06-10. Service bulletin. If you are servicing an applicable vehicle with a “Check Engine” light on and one or more of the DTC listed below, follow the repair procedure and replace the related input/output speed sensor and harness. |
| 22-AT-005H | 2022-05-10. Service bulletin. If you are servicing an applicable vehicle with a “Check Engine” light on and one or more of the DTC listed below, follow the repair procedure and replace the related solenoid and valve body harness. |
| 21-AT-014H | 2021-09-17. Service bulletin. Certain vehicles (listed below) equipped with 7-speed Double Clutch Transmissions (DCT) may exhibit abnormal vibration at low speeds. This bulletin outlines the procedures for diagnosing clutch judder, updating the Transmission Control Unit (TCU) with revised logic, and/or replacing the Double Clutch. |
| 21-EM-005H | 2021-04-07. Service bulletin. The Powertrain warranty coverage for certain engine repairs and/or replacement where the engine damage, defect, or failure is related to connecting rod bearing wear, has been extended to 15 years or 150,000 miles from the date of original retail delivery or date of first use, whichever occurs first, and is valid for original and subsequent owners. |
| 21-AT-001H | 2021-02-06. Service bulletin. This bulletin provides the procedure to update the TCU for a rough idle in Drive with Neutral Control enabled. The rough idle may occur only at a stop in Drive with the A/C off and the ATF temperature between 158~210°F (70~99°C). This update also reduces vibration when the brake is released during Neutral Control operation and the accelerator pedal is depressed. |
| 20-AT-005H-1 | 2020-11-06. Service bulletin. If you are servicing an applicable vehicle with a “Check Engine” light on and one or more of the DTC listed below, follow the repair procedure and replace the related solenoid and valve body harness. |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.