Transport Canada recall 2018132
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2018132 |
| Manufacturer's number | RC114 |
| Reported | 2018-03-15 |
| Component | Powertrain |
| Notification type | Safety Mfr |
| Units potentially affected | 112 |
What is wrong
On certain plug-in hybrid vehicles, the battery Voltage Protection Device (VPD) switch could inadvertently activate. If the VPD switch is activated, electricity to the vehicle's electric motor may be disconnected. If this occurs while the vehicle is driven under Electric Vehicle (EV) mode, the vehicle may experience a loss of motive power, which could increase the risk of a crash causing injury and/or property damage. Correction: Dealers will remove the current VPD switch and install two newly designed battery management systems containing new overvoltage protection devices. The corresponding wiring harness will also be installed. Note: This condition would result in the of the “Check Hybrid System" warning light illuminating.
| 2017 KIA OPTIMA | |
|---|---|
| 2018 KIA OPTIMA |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| TSB_TRA046_R5 | 2025-04-23. Service bulletin. TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, and the transmission oil cooler is transferred to the new transmission. |
|---|---|
| TSB_TRA046_R4 | 2024-06-04. Service bulletin. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced. |
| TSB_TRA072_R5 | 2023-12-05. Service bulletin. TECHNICAL SERVICE BULLETIN: SERVICE ACTION: INHIBITOR SWITCH REPLACEMENT (SA317B/C) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to replace the inhibitor switch on some 2017MY Optima (JFa), Sorento (UMa), Optima Hybrid (HEV), Optima Plug-in Hybrid (PHEV), Sportage (QL), Forte (YD), and Sedona (YP), and some 2016-2017MY Optima (JF) vehicles, equipped with a front wheel drive 6-speed transmission, which may experience the concerns listed below. These concerns may be due to the inhibitor switch not allowing the correct gear position signal to be sent to various control units. |
| TSB_TRA072_R4 | 2023-07-05. Service bulletin. TECHNICAL SERVICE BULLETIN: SERVICE ACTION: INHIBITOR SWITCH REPLACEMENT (SA317B/C) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to replace the inhibitor switch on some 2017MY Optima (JFa), Sorento (UMa), Optima Hybrid (HEV), Optima Plug-in Hybrid (PHEV), Sportage (QL), Forte (YD), and Sedona (YP), and some 2016-2017MY Optima (JF) vehicles, equipped with a front wheel drive 6-speed transmission, which may experience the concerns listed below. These concerns may be due to the inhibitor switch not allowing the correct gear position signal to be sent to various control units. |
| TSB_TRA072_R4 | 2023-07-05. Service bulletin. TECHNICAL SERVICE BULLETIN: SERVICE ACTION: INHIBITOR SWITCH REPLACEMENT (SA317B/C) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to replace the inhibitor switch on some 2017MY Optima (JFa), Sorento (UMa), Optima Hybrid (HEV), Optima Plug-in Hybrid (PHEV), Sportage (QL), Forte (YD), and Sedona (YP), and some 2016-2017MY Optima (JF) vehicles, equipped with a front wheel drive 6-speed transmission, which may experience the concerns listed below. These concerns may be due to the inhibitor switch not allowing the correct gear position signal to be sent to various control units. |
| TSB_TRA046_R3 | 2022-12-06. Service bulletin. TECHNICAL SERVICE BULLETIN: TRANSMISSION FLUID APPLICATION GUIDE - This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles in the chart starting on page 2. |
| TSB_TRA098 | 2021-09-03. Service bulletin. TECHNICAL SERVICE BULLETIN: 7-SPEED DUAL CLUTCH TRANSMISSION (DCT) ANTI-JUDDER LOGIC IMPROVEMENT - This bulletin provides the procedure to update the software logic of the Dual Clutch Transmission (DCT) system on some 2016-2020MY Optima (JFa) vehicles produced from August 28, 2015 through June 1, 2020, equipped with Gamma 1.6L T-GDI engine and 7-speed DCT, which might exhibit clutch judder when accelerating from a stop. |
| TSB_TRA083_R1 | 2021-09-03. Service bulletin. TECHNICAL SERVICE BULLETIN: 7-SPEED DCT JUDDER INSPECTION AND DUAL CLUTCH ASSEMBLY REPLACEMENT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to replace Dual Clutch Assembly and upgrade the TCU on some 2016-2020MY Kia vehicles listed in the table below, equipped with the 7 Speed Dual Clutch Transmission (DCT), which might exhibit clutch judder when accelerating from a stop. |
| TSB_TRA083 | 2021-01-06. Service bulletin. TECHNICAL SERVICE BULLETIN: 7-SPEED DCT JUDDER INSPECTION AND DUAL CLUTCH ASSEMBLY REPLACEMENT - This bulletin provides the procedure to replace Dual Clutch Assembly and upgrade the TCU on some 2016-2020MY Kia vehicles listed on the table below, equipped with the 7 Speed Dual Clutch Transmission (DCT), which might exhibit clutch judder when accelerating from a stop. If the vehicle body vibrates without the steering wheel shuddering when performing creep driving test (driving the vehicle up to 3mph), the vehicle is exhibiting clutch judder. The creep test can be conducted by driving at a speed slower than 5 mph after releasing the brake. |
| TSB_TRA046_R1 | 2020-05-05. Service bulletin. TECHNICAL SERVICE BULLETIN: - TRANSMISSION FLUID APPLICATION GUIDE - This bulletin has been revised to include additional information. This bulletin provides information relating to the correct transmission fluid type and fill quantity requirement for each Kia model. A flush is required ONLY when a transmission is replaced, refer to applicable vehicles on page 2. Refer to the shop manual on KGIS for the specific Kia model for the correct transmission fluid check/fill procedures. |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.