Transport Canada recall 2018025
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2018025 |
| Manufacturer's number | U02 |
| Reported | 2018-01-11 |
| Component | Fuel System |
| Notification type | Safety Mfr |
| Units potentially affected | 60 |
What is wrong
Certain vehicles equipped with a 6.2L supercharged engine may experience a fuel line separation resulting in a fuel leak, potentially causing the engine to stall. An engine stall could result in a loss of motive power which would increase the risk of a crash causing injury and/or damage to property. Additionally, leaking fuel in the presence of an ignition source could increase the risk of fire causing injury and/or damage to property. Correction: Dealers will inspect and replace the fuel line as necessary.
| 2018 JEEP GRAND CHEROKEE |
|---|
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| 105038 | 2025-05-20. Service bulletin. TUBE - FUEL INJECTOR SUPPLY & GASKET - NONE |
|---|---|
| 105039 | 2025-05-16. Service bulletin. TUBE - FUEL INJECTOR SUPPLY & GASKET - NONE |
| 102812 | 2025-03-05. Service bulletin. RAIL - FUEL |
| 9100494 | 2025-01-30. Service bulletin. FUEL PUMP/LEVEL UNIT MODULE For vehicles with Saddle Fuel Tanks, need to determine if there are any DTCs in wiTECH. Follow Service Diagnostics published prior to making any changes. Review any existing SOL or TSBs published for customer complaint issue. Only the Fuel Pump Module should be replaced if there are DTCs associated with the Fuel Level Sensor number 1. Only the Auxiliary Level Sender should be replaced if there are DTCs associated with the Fuel Level Sensor number 2. If there is a mixture of DTCs between the Fuel Pump Module and the Auxiliary Level Sensor, then investigate if there is a Jumper Harness or circuit issue between the Level Sender and the PCM. Verify fuel transfer between auxiliary tank and the primary tank by monitoring the auxiliary level sensor to verify it drops after driving. |
| S1925000008 | 2023-01-17. Service bulletin. Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Codes (DTCs) P208B ? Reductant Pump 1 Control Performance, and/or P20E8 ? Reductant Pressure Too Low, Set. |
| S1925000008 | 2022-10-17. Service bulletin. (Rev. B) Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Codes (DTCs) P20E8 ? Reductant Pressure Too Low and/or P208B ? Reductant Pump 1 Control Performance Set. |
| S1625000005 | 2022-10-17. Service bulletin. (Rev. A) Malfunction Indicator Light (MIL) Illuminated. Service Diesel Exhaust Fluid (DEF) System ? See Dealer Soon Message on Electronic Vehicle Information Center (EVIC) Along With Possible Diagnostic Trouble Code (DTC) P241D - SCR Inducement - Forced Engine Shutdown. |
| S1925000008RevA | 2022-09-26. Service bulletin. (Revision A) Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Codes (DTCs) P20E8 ? Reductant Pressure Too Low and/or P208B ? Reductant Pump 1 Control Performance Set. |
| 9003704 | 2022-09-26. Service bulletin. Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. The fluid in the 8 speeds can be detected with a black light and there are aftermarket spray on leak detection materials to help ensure that the leak is properly diagnosed and not from another location such as cooler lines, heater tubes, or case porosity. Please note that the transmission pan gasket is available for many of the 8 speed applications FCA offers. Please review the available quick connect and transfer tube parts, as replacement of the TMU may not be required. If a TOC line connection is found to be the source, the quick connect may need replacement. If the leak source is coming from the connection of the TMU to the transmission, the transfer tube may need replacement. When parts are returned to the QEC the retaining clips (snap ring) for the quick disconnect fittings are missing. (This leaves a question as to whether the clips were missing from the assembly plant, or the technician removed them in order to make line removal easier.) Please return the clips with the transmission heater and note if they were not there to begin with. For any questions regarding transmission heater, contact FCA Redacted Content. If no response in 15 minutes, proceed with repair. |
| S1925000008 | 2022-09-26. Service bulletin. Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Codes (DTCs) P208B ? Reductant Pump 1 Control Performance, and/or P20E8 ? Reductant Pressure Too Low, Set. |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.