Transport Canada recall 2016580
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2016580 |
| Manufacturer's number | PC494 |
| Reported | 2016-11-18 |
| Component | Fuel System |
| Notification type | Safety Mfr |
| Units potentially affected | 1896 |
What is wrong
On certain vehicles equipped with diesel engines, a temporary fuel tank breather tube cap may not have removed during assembly, and the tube may not have been correctly affixed to the bed rail. As a result, the fuel tank may not receive proper ventilation through the fuel tank breather tube and, in some instances, may deform. This condition could result in the fuel gauge, and the separate “distance to empty” meter, to both display inaccurately. If this occurs, the vehicle could possibly run out of fuel, which would cause the engine to stall without warning to the driver. Engine stalling could increase the risk of a crash causing injury and/or property damage. Correction: Dealers will inspect the fuel tank breather tube for proper routing and inspect for the absence of the temporary fuel tank breather tube cap to determine if a vehicle is affected. The temporary fuel tank breather tube cap will be removed and fuel tank, fuel sending unit, and/or fuel tank breather tube will be replaced as necessary.
| 2016 NISSAN TITAN XD | Listed as a series or trim of this model. |
|---|
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| NTB22-026 | 2022-06-08. Service bulletin. SERVICE INFORMATION FOR FUEL GAUGE INACCURATE WITH DTCS STORED IN ECM SERVICE INFORMATION If a fuel level sensor has been diagnosed as sending an incorrect level signal, and one or more of the following DTCs are stored in the ECM, do not replace the entire “Fuel Level Sensor Unit, Fuel Filter and Fuel Pump Assembly” (fuel pump assembly). The fuel level sensor can be replaced separately. • P0460 (FUEL LEV SEN SLOSH) • P0461 (FUEL LEVEL SENSOR) • P0462 (FUEL LEVL SEN/CIRC) • P0463 (FUEL LEVL SEN/CIRC) NOTE: Warranty claims referring to fuel level issues that result in the replacement of the entire fuel pump assembly will be charged back. |
|---|---|
| NTB17-082E | 2022-03-12. Service bulletin. DTC P0456 CAUSED BY EVAP LEAK AT VENT CONTROL VALVE O-RING This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin. |
| NTB13-097J | 2022-03-12. Service bulletin. EVAP LEAK DTC P0442, P0455, P0456 INFORMATION This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin. |
| NTB15-044B | 2021-05-24. Service bulletin. Fuel Filler Cap tether clip service information |
| NTB15044B | 2021-05-10. Service bulletin. SERVICE INFORMATION If the clip for the fuel filler cap tether becomes lost or is detached for any reason, it is no longer necessary to replace the fuel filler cap. The clip or "pin" is now available as a separate service part. NOTE - Do not replace the fuel filler cap if only the pin is needed. See this bulletin for further detail. |
| NTB20-070 | 2020-11-09. Service bulletin. 2016-2019 TITAN XD DIESEL; TURBOCHARGER SERVICE INFORMATION SERVICE INFORMATION The low pressure turbocharger and the high pressure turbocharger on the APPLIED VEHICLES, listed above, are now available as separate service parts. • If the low pressure turbocharger on an APPLIED VEHICLE is being replaced for any reason, refer to NTB20-071 for the removal procedure, installation procedure and parts information. • If the high pressure turbocharger on an APPLIED VEHICLE is being replaced for any reason, refer to NTB19-017 for the removal procedure, installation procedure and parts information. |
| NTB19-037a | 2020-08-09. Service bulletin. 2016-2019 TITAN; MIL ON WITH DTC P0448 AND WATER IN EVAP FILTER This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin. |
| PC731 2016-17 TI | 2020-05-06. Service bulletin. On-Board Diagnostic (OBD) Electronic Control Unit (ECU) Voluntary Emission Recall Campaign ***** Campaign Summary ***** Nissan is conducting a Voluntary Emissions Recall Campaign on 27,085 certain MY2016-17 Titan Diesel vehicles identified in Service Comm to inspect and, if necessary, reprogram the Electronic Control Unit (ECU) with countermeasure software. Nissan has determined that the subject vehicles were manufactured with an On-Board Diagnostic (OBD) calibration that may not allow the exhaust gas sensor monitors to run as intended. If an affected vehicle is not repaired, the exhaust gas sensor monitors may not run as frequently as required by regulation to determine if the sensor is performing as intended. This issue has no effect on vehicle safety, fuel economy, drivability, or performance. ***** What Dealers Should Do**** 1. Verify campaign applicability using Service Comm or DBS National Service History – Open Campaign I.D. PC731. 2. Dealers should use NTB20-030 to correct any vehicles subject to this campaign. 3. Once repaired, dealers should submit the claim, using the claims coding provided, and release the vehicle. |
| NTB19-026a | 2019-09-10. Service bulletin. 2016 – 2018 TITAN XD; STATIC DISCHARGE FROM FUEL LINE This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin. |
| NTB19-026 | 2019-08-19. Service bulletin. 2016 - 2018 TITAN XD; STATIC DISCHARGE FROM FUEL LINE IF YOU CONFIRM There is a static discharge from the fuel line causing a click or pop noise. NOTE: Concern is more likely to: - Be heard from under the center of vehicle. - Occur more often on dry days. - Occur at regular intervals about every 30 seconds to 1 minute. ACTION Install the tether assembly as described in the SERVICE PROCEDURE starting on the next page. |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.