Transport Canada recall 2016505
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2016505 |
| Reported | 2016-10-13 |
| Component | Fuel System |
| Notification type | Safety Mfr |
| Units potentially affected | 16663 |
What is wrong
On certain vehicles, the wires going to the in-tank fuel pump may not have been crimped correctly. An incorrect crimp could increase the resistance of the circuit which could cause the contact pin to heat and melt the surrounding plastic. This could potentially cause the fuel pump to stop working causing the vehicle to stall without warning, increasing the risk of a crash causing injury and/or damage to property. Also, in a very rare case, a fuel leak combined with an external ignition source, could increase the risk of fire causing injury and/or damage to property. Correction: Dealers will replace the fuel delivery module.
| 2010 BMW 5 SERIES | |
|---|---|
| 2011 BMW 5 SERIES | |
| 2012 BMW 6 SERIES | |
| 2007 BMW X5 | |
| 2008 BMW X5 | |
| 2009 BMW X5 | |
| 2010 BMW X5 | |
| 2011 BMW X5 | |
| 2008 BMW X6 | |
| 2009 BMW X6 | |
| 2010 BMW X6 | |
| 2011 BMW X6 |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| B160623 | 2024-01-03. Service bulletin. Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE |
|---|---|
| SIB160222 | 2022-08-22. Service bulletin. The fuel gauge may indicate the incorrect fuel level (full and reserve). |
| B650621 | 2021-08-23. Service bulletin. SURFACE RUST ON NEW AIR BAG INFLATORS: The technician finds that the new air bag inflator (aka: gas generator) may have surface rust on the metalhousing . |
| B011321 | 2021-07-19. Service bulletin. CLASS ACTION SETTLEMENT: N54/N54T/N55 ELECTRIC ENGINE COOLANT PUMP . With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered a nationwide settlement with the plaintiffs in the following class action: Oliver, et al v. BMW NA, et al |
| B011321 | 2021-07-06. Service bulletin. CLASS ACTION SETTLEMENT: N54/N54T/N55 ELECTRIC ENGINE COOLANT PUMP . With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered a nationwide settlement with the plaintiffs in the following class action: Oliver, et al v. BMW NA, et al |
| B130720 | 2021-02-01. Service bulletin. INCORRECT TORQUE SPECIFICATION FOR THE HIGH-PRESSURE PUMP IN ISTA: The current version of ISTA states the incorrect tightening torque for the High-Pressure pump M6 mounting bolts to the cylinder head cover. The correct tightening torque is only 12 Nm for the M6 bolts. |
| B010219 | 2019-05-20. Service bulletin. E71 (X6 WITH N63 ENGINE) FUEL INJECTORS: LIMITED WARRANTY EXTENSION TO 10 YEARS/120000 MILES. The vehicles engine is experiencing either a long crank/starting duration engine misfires/rough running with black smoke emitting from the exhaust tailpipes and the spark plugs maybe wet fouled with fuel. |
| B110815 | 2018-12-10. Service bulletin. This Service Information bulletin and attachment supersedes SI B11 08 15 dated November 2015. SUBJECT N63 and S63 Engine: Valve Seal Replacement. Refer to the following applicable SIBs before replacing the valve seals. SI B11 07 11 - Turbocharger Failure: Oil Supply and Return Line Blockage and Proper Repairs SI B11 07 12 - N63 Engine: Oil Consumption and/or Rough Running Complaints SI B11 01 13 - N63 Engine: Engine Oil Consumption, Engine Oil Top-ups and Refill Capacity SI B11 03 13 - Engine Oil Consumption (all models) If the valve seals are leaking, one of the following will help determine if the seals should be replaced. Smoke from the tailpipe when starting or aggressively accelerating and decelerating the engine Excessive engine oil consumption Spark plugs fouled with engine oil |
| B010511 | 2018-12-10. Service bulletin. "SI B01 05 11 March 2016 Warranties This Service Information bulletin supersedes SI B01 012 11 dated December 2012. Please read this Service Information bulletin in its entirety: the part information and content format has been completely updated. designates changes to this revision SUBJECT N52K Tank Leak Diagnostic Module (DMTL) Pump: Limited Warranty Extension to 10 Years/120,000 Miles. INFORMATION For the above-referenced vehicles, BMW of North America, LLC (""BMW NA"") is extending the limited warranty for the tank leak diagnostic module (DMTL) pump to: 10 years/120,000 miles as determined by the vehicle's original in-service date Item #3: This ""componentspecific"" limited warranty extension applies to defects in materials and workmanship and is subject to the applicable vehicle and coverage eligibility requirements, exclusions and limitations that apply to the BMW New Vehicle Limited Warranty for Passenger Cars and Light Trucks. Note: For items #1, #2 and #7, please refer to the ""Parts Information"" section. This bulletin is notice of a ""limited warranty extension."" This is NOT a notice of a Recall or Service Action. There is no immediate repair required unless the BMW vehicle is currently experiencing this problem. Even though this is NOT a Recall, BMW NA has sent VIN-specific customer notification letters (examples attached)." |
| B131410 | 2018-12-10. Service bulletin. "PERFORM THE PROCEDURE OUTLINED IN THIS SERVICE INFORMATION ON ALL AFFECTED VEHICLES THE NEXT TIME THEY ARE IN THE SHOP FOR MAINTENANCE OR REPAIRS. This Service Information bulletin supersedes SI B13 14 10 dated July 2013. SUBJECT Voluntary Emissions Recall Campaign 10E-A02: N54 Inspection and Replacement of Injectors. The piezo injectors may cause misfire faults with erratic engine operation. AFFECTED VEHICLES This Emissions Recall involves E60, E61, E71, E82, E88, E90, E92, and E93 vehicles with N54 engines which were produced from 04/02/2007 through 11/30/2008. In order to determine whether a specific vehicle has had this Emissions Recall Campaign completed or is affected by this Recall Campaign, it will be necessary to utilize the ""Service Menu"" of DCSnet (Dealer Communication System) or the Key Reader. Based on the response of the system, either proceed with the corrective action or take no further action. Copy of the customer letter is attached." |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.