Transport Canada recall 2016309
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2016309 |
| Manufacturer's number | C0260 (50CA070) |
| Reported | 2016-06-16 |
| Component | Engine |
| Notification type | Superseded |
| Units potentially affected | 49845 |
What is wrong
This recall was replaced by Transport Canada Recall No. 2021-653.
On certain vehicles equipped with a 3.3L V6 engine, engine oil can leak onto the alternator, which could affect charging system function and potentially cause the engine to stall and not restart. This would result in a loss of motive power as well as affect power braking and power steering system function, which would unexpectedly increase steering and brake pedal effort, potentially increasing stopping distances and the risk of a crash causing injury and/or damage to property. Correction: Dealers will replace the front valve cover gasket and repair/replace the alternator, as necessary, under a special service campaign.
| 2007 HYUNDAI SANTA FE | |
|---|---|
| 2008 HYUNDAI SANTA FE | |
| 2009 HYUNDAI SANTA FE |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| 26-EM-016H TSB | 2026-10-14. Service bulletin. Some vehicles equipped with internal combustion engines may exhibit higher-than-expected engine oil consumption. This bulletin outlines the combustion chamber cleaning procedure for vehicles diagnosed with this condition. All internal combustion engines consume some engine oil during normal operation, depending on driving conditions and mileage, and this procedure should only be performed when deemed necessary based on inspection and diagnosis of the vehicle as outlined in TSB 26-EM-015H, Engine Oil Consumption – Inspection & Repair Guidelines, or the latest revision. |
|---|---|
| 26-EM-015H TSB | 2026-10-13. Service bulletin. Certain vehicles equipped with internal combustion engines may exhibit higher-than-expected engine oil consumption. This bulletin provides the inspection and repair procedures for vehicles exhibiting this condition. All internal combustion engines consume engine oil as part of normal engine operation. Oil consumption rates may vary based on mileage, operating conditions, driving habits, and maintenance history. Hyundai recommends following the prescribed maintenance schedule and periodically checking the engine oil level using the dipstick to maintain proper engine oil level. |
| 24-01-026H | 2024-04-16. Service bulletin. Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder bank’s valve cover onto the alternator. Oil could damage the alternator resulting in illumination of the charging system warning lamp and disablement of the charging system. If the vehicle is continually driven without recharging the battery, the engine will eventually shut off, increasing the risk of a crash. This bulletin outlines the procedures to inspect for T-joint leakage and install an oil protector to address this issue. |
| 23-01-076H-2 | 2023-12-22. Service bulletin. Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder bank’s valve cover onto the alternator. Oil could damage the alternator resulting in illumination of the charging system warning lamp and disablement of the charging system. If the vehicle is continually driven without recharging the battery, the engine will eventually shut off, increasing the risk of a crash. This bulletin outlines the procedures to inspect for T-joint leakage and install an oil protector to address this condition. |
| 23-01-076H-2 | 2023-12-22. Service bulletin. Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder bank’s valve cover onto the alternator. Oil could damage the alternator resulting in illumination of the charging system warning lamp and disablement of the charging system. If the vehicle is continually driven without recharging the battery, the engine will eventually shut off, increasing the risk of a crash. This bulletin outlines the procedures to inspect for T-joint leakage and install an oil protector to address this issue. |
| 23-EM-005H | 2023-12-15. Service bulletin. This bulletin provides important checkpoint guidelines when performing engine oil and filter change services. |
| 23-01-076H-1 | 2023-11-07. Service bulletin. Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder bank’s valve cover onto the alternator. Oil could damage the alternator resulting in illumination of the charging system warning lamp and disablement of the charging system. If the vehicle is continually driven without recharging the battery, the engine will eventually shut off, increasing the risk of a crash. This bulletin outlines the procedures to inspect for T-joint leakage and install an oil protector to address this issue. • 1. If the alternator voltage is less than 14.0V and there is evidence of oil leak at the T-joint, replace the alternator, valve cover gasket, and install the oil protector. • 2. If the alternator voltage is greater than 14.0V and there is evidence of oil leak at the T-joint, replace the valve cover gasket and install the oil protector. Do not replace the alternator. • 3. If the alternator voltage is greater than 14.0V and there is no evidence of oil leak at the T-joint, install the oil protector. Do not replace the valve cover gasket or the alternator. |
| 23-01-076H-1 | 2023-11-07. Service bulletin. Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder bank’s valve cover onto the alternator. Oil could damage the alternator resulting in illumination of the charging system warning lamp and disablement of the charging system. If the vehicle is continually driven without recharging the battery, the engine will eventually shut off, increasing the risk of a crash. This bulletin outlines the procedures to inspect for T-joint leakage and install an oil protector to address this issue. The service procedure contained in TSB 23-01-076H-1 (or latest version) is summarized below: 1. If the alternator voltage is less than 14.0V and there is evidence of oil leak at the T-joint, replace the alternator, valve cover gasket, and install the oil protector. 2. If the alternator voltage is greater than 14.0V and there is evidence of oil leak at the T-joint, replace the valve cover gasket and install the oil protector. Do not replace the alternator. 3. If the alternator voltage is greater than 14.0V and there is no evidence of oil leak at the T-joint, install the oil protector. Do not replace the valve cover gasket or the alternator. |
| 23-01-076H | 2023-10-02. Service bulletin. Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder bank’s valve cover onto the alternator. Oil could damage the alternator resulting in illumination of the charging system warning lamp and disablement of the charging system. If the vehicle is continually driven without recharging the battery, the engine will eventually shut off, increasing the risk of a crash. This bulletin outlines the procedures to inspect for T-joint leakage and install an oil protector to address this issue. The service procedure contained in TSB 23-01-076H (or latest version) is summarized below: 1. If the alternator voltage is less than 14.0V and there is evidence of oil leak at the T-joint, replace the alternator, valve cover gasket, and install the oil protector. 2. If the alternator voltage is greater than 14.0V and there is evidence of oil leak at the T-joint, replace the valve cover gasket and install the oil protector. Do not replace the alternator. 3. If the alternator voltage is greater than 14.0V and there is no evidence of oil leak at the T-joint, install the oil protector. Do not replace the valve cover gasket or the alternator. |
| 23-01-076H | 2023-10-02. Service bulletin. Some Santa Fe (CM) vehicles may have an engine that potentially leaks oil from the front cylinder bank’s valve cover onto the alternator. Oil could damage the alternator resulting in illumination of the charging system warning lamp and disablement of the charging system. If the vehicle is continually driven without recharging the battery, the engine will eventually shut off, increasing the risk of a crash. This bulletin outlines the procedures to inspect for T-joint leakage and install an oil protector to address this issue. |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.