Transport Canada recall 2014449
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | Transport Canada (Canada) |
|---|---|
| Campaign number | 2014449 |
| Manufacturer's number | P65 |
| Reported | 2014-10-09 |
| Component | Fuel System |
| Notification type | Safety Mfr |
| Units potentially affected | 59432 |
What is wrong
On certain vehicles equipped with 6.7L diesel engines, an electrical connection at the fuel heater could overheat, potentially rendering the heater inoperative and causing a fuel leak and fuel odour. Fuel leakage, in the presence of an ignition source, could result in a fire causing injury and/or damage to property. Correction: Dealers will inspect the fuel heater, and replace it if required, as well as replace the fuel heater wiring harness electrical connector.
| 2010 DODGE RAM | |
|---|---|
| 2011 DODGE RAM | |
| 2012 DODGE RAM | |
| 2013 DODGE RAM | |
| 2014 DODGE RAM | |
| 2010 RAM 2500 | |
| 2011 RAM 2500 | |
| 2012 RAM 2500 | |
| 2013 RAM 2500 | |
| 2014 RAM 2500 | |
| 2010 RAM 3500 | |
| 2011 RAM 3500 | |
| 2012 RAM 3500 | |
| 2013 RAM 3500 | |
| 2014 RAM 3500 | |
| 2010 RAM 4500 | |
| 2011 RAM 4500 | |
| 2012 RAM 4500 | |
| 2013 RAM 4500 | |
| 2014 RAM 4500 | |
| 2010 RAM 5500 | |
| 2011 RAM 5500 | |
| 2012 RAM 5500 | |
| 2013 RAM 5500 | |
| 2014 RAM 5500 |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| 1400114 | 2023-01-17. Service bulletin. Fuel Gelling in Cold Ambient Temperatures This bulletin involves reconfiguring the Body Control Module (BCM). Some customers may experience a Malfunction Indicator Lamp (MIL) due to fuel related Diagnostic Trouble Code (DTC) and/or may have a hard or no start condition due to fuel gelling in cold ambient temperatures (20°F or -7°C) or below. DTCs, such as P0087, P0191 or P026B (or other DTCs) may have been set.frame mounted fuel filter heater not to function. The condition is due to a configuration setting in the Body Control Module (BCM). |
|---|---|
| 2500115 | 2023-01-09. Service bulletin. Diesel Exhaust Fluid (DEF) Level Gauge Inaccurate Or Stuck This bulletin involves verifying the correct DEF level in the tank and if necessary, replacing the DEF pump module. A small number of customers may comment that their DEF level gauge is stuck for long periods of time or is erratic. The customer may also experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation a technician may find one or more of the following Diagnostic Trouble Codes (DTCs). ? P203B - Reductant Level Sensor Circuit Performance ? P203C - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit Low. ? P203D - (Diesel Exhaust Fluid) Reductant Level Sensor Circuit High. |
| 1805416 | 2022-12-19. Service bulletin. Flash: 6.7L Diagnostic And System Improvements This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) Illumination. Upon further investigation, a technician may find one or more of the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: · **P218F - Reductant No Flow Detected. · P242F - Diesel Particulate Filter Restriction - Ash Accumulation. · P2281 - Air Leak Between MAF And Throttle Body.** · P205E - (Diesel Exhaust Fluid) Reductant Tank Temperature Sensor Circuit Intermittent (setting when the block heater is plugged in). · U110E - Lost Ambient Temperature Message. · P20E8 - (Diesel Exhaust Fluid) Reductant Pressure Too Low. · P1477 - Intake Air Diverter Valve Position Sensor Circuit Shorted To Ground. · U3017 - Control Module Timer/Clock Performance. · P0087 - Fuel Rail Pressure Too Low. · P0544 - Exhaust Gas Temperature Sensor Circuit - Sensor 1/1. · P0128 - Thermostat Rationality. In cold ambient temperatures. · P214D - SCR NOx Catalyst Outlet Temperature Too High During Particulate Filter Regeneration. · P24A5 - Exhaust Gas Recirculation (EGR) Cooler Bypass Bank 1 Control Stuck. · P040B - Exhaust Gas Recirculation Temperature Sensor ?A? Circuit Performance. · U1421 - Implausible Ignition Key Off Time Received. · P0420 - Catalyst Efficiency Below Threshold. · P026B - Injection Timing Performance. · P04DB - Crankcase Ventilation System Disconnected. · P1C55 - NOx Sensor Intermittent - Bank 1 Sensor 1. · P202E - Diesel Exhaust Fluid (DEF) Reductant Injector Performance. · P20EE - SCR NOx Catalyst Efficiency Below Threshold - Bank 1. · P2002 - Diesel Particulate Filter Efficiency Below Threshold. · P0604 - Internal Control Module RAM. · P1451 - Diesel Particulate Filter System Performance. |
| 2500116 | 2022-11-21. Service bulletin. Diagnosing A Urea Module That Is Exposed To Diesel Fuel This bulletin involves discussing what will happen to the rubber material used in the urea pump when exposed to diesel fuel. This unit is sometimes referred to as the Selective Catalyst Reductant (SCR) module or the Adblue Delivery Module (ADM). Units exposed to hydrocarbons have a particular failure mode, the rubber heater unit is crinkled and in some cases the metal heater protrudes through the rubber membrane. The rubber material used in this unit is designed to withstand Diesel Exhaust Fluid (DEF) only. Exposure to fluids that contain hydrocarbons (i.e. diesel fuel) will damage the unit beyond repair. Units returned that exhibit this failure mode will have warranty claims that are rejected. Units that exhibit this failure mode should be considered customer abuse and should not be covered under warranty. Use the Hydroscopic test paper (P/N 223-44-863) available through MoparEssentialTools.com to confirm exposure. |
| S2214000003 | 2022-11-07. Service bulletin. Guidelines For The Use Of Alternative Diesel Fuels. |
| 18-038-16 | 2022-10-24. Service bulletin. P20EE SCR NOX Catalyst Efficiency Below Threshold Bank 1 This bulletin involves verifying the proper operation of the Diesel Exhaust Fluid (DEF) system and, if necessary, replacing the Selective Catalyst Reduction (SCR) Catalyst assembly. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find Diagnostic Trouble Code (DTC) P20EE SCR NOX Catalyst Efficiency Below Threshold Bank 1 set in the Powertrain Control Module (PCM) memory. |
| 9004267 | 2022-10-17. Service bulletin. FUEL, Tank Please be advised, do not replace fuel tanks with a fuel tank that has a different capacity than the vehicle was equipped with from the factory. Please do not attempt to upfit vehicles at the dealer with increased capacity tanks, they are not compatible. |
| 18-091-16 | 2022-09-26. Service bulletin. Flash: Powertrain Diagnostic And System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Codes (DTCs) have been set. Several software improvements are available for the following conditions. The Following DTC has been changed from a two trip fault to a one trip fault: · U1A24 - Lost Communication With Ammonia Sensor. Prevent or reduce MIL illumination when no defect is present for the following DTCs. These faults have been changed from a one trip fault to a two trip fault: · P0201 - P0206 - Fuel Injector X Circuit/Open. · P049D - EGR Control Position Exceeding Learning Limit. · P0711 - Transmission Temperature Sensor Performance. · P0712 - Transmission Temperature Sensor Low. · P0713 - Transmission Temperature Sensor High. · P0714 - Transmission Temperature Sensor Intermittent. · P0740 - TCC Out Of Range. · P0869 - Line Pressure High. · P0933 - Hydraulic Pressure Sensor Range/Performance. · P0934 - Line Pressure Sensor Circuit Low. · P0935 - Line Pressure Sensor Circuit High. · P1775 - Solenoid Switch Valve Latched In TCC Position. · P1776 - Solenoid Switch Valve Latched In LR Position. · U0100 - Lost Communication With ECM/PCM. · U0002 - CAN C Bus Off performance - Bus Off. · **P2281 - Air Leak Between MAF And Throttle Body. · P218F - Reductant No Flow Detected. · P242F - Diesel Particulate Filter Restriction - Ash Accumulation. · P20E8 - (Diesel Exhaust Fluid) Reductant Pressure Too Low. · P202E - Diesel Exhaust Fluid) Reductant Injector Performance. · P209F - Diesel Exhaust Fluid) Reductant Tank Heater Control Circuit Performance. · P218F - Reductant No Flow Detected.** · P205E - (Diesel Exhaust Fluid) Reductant Tank Temperatur |
| 1803014REVB | 2022-09-26. Service bulletin. Flash: 6.7L Diagnostic and System Improvements This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Several software improvements are available for vehicles equipped with a Cummins 6.7L turbo Diesel.Prevent Or Reduce Malfunction Indicator Lamp (MIL) Illumination When No Defect is Present For The Following Diagnostic Trouble Codes (DTCs). These Faults Have Been Changed From P0201 - P0206 - Fuel Injector X Circuit/Open. P049D - EGR Control Position Exceeding Learning Limit. P0711 - Transmission Temperature Sensor Performance. P0712 - Transmission Temperature Sensor Low. P0713 - Transmission Temperature Sensor High. P0714 - Transmission Temperature Sensor Intermittent. P0740 - TCC Out Of Range. P0869 - Line Pressure High. P0933 - Hydraulic Pressure Sensor Range/Performance. P0934 - Line Pressure Sensor Circuit Low. P0935 - Line Pressure Sensor Circuit High. P1775 - Solenoid Switch Valve Latched In TCC Position. P1776 - Solenoid Switch Valve Latched In LR Position. U0100 - Lost Communication With ECM/PCM. U0002 - CAN C Bus Off performance - Bus Off. U110E - Lost Ambient Temperature Message.The Following DTC Has Been Changed From A Two Trip Fault To One Trip Fault: U1A24 - Lost Communication With Ammonia Sensor.Improvements To Prevent Or Reduce Malfunction Indicator Lamp (MIL) Illumination When No Defect Is Present For: U3017 - Control Module Timer/Clock Performance. P026B - Injection Timing Performance. P0128 - Thermostat Rationality. In cold ambient temperatures. P0087 - Fuel Rail Pressure Too Low. P2281 - Air Leak Between MAF and Throttle Body. U1421 - Implausible Ignition Key Off Time Received. P026A - Charge Air Cooler Efficiency Below Threshold. P04DB - Crankcase Ventilation System Disconnected. P0544 - Exhaust Gas Temperature Sensor Circuit - Bank 1 Sensor 1. P0562 - Battery Voltage Low. P0604 - Internal Control Module RAM Error. P1451 - Diesel Particulate Filter |
| 1805314REVB | 2022-09-26. Service bulletin. Flash: 6.7L Diagnostic And System Improvements Bulletin involves reprogramming the Powertrain Control Module (PCM) with new software. Several software improvements are available for vehicles equipped with a Cummins 6.7L turbo diesel. They are as follows:Prevent Or Reduce Malfunction Indicator Lamp (MIL) Illumination When No Defect is Present Following Diagnostic Trouble Codes (DTCs). These Faults Have Been Changed From P0201 - P0206 - Fuel Injector X Circuit Open Fault Codes. U110E - Lost Ambient Temperature Message. P049D - EGR Control Position Exceeding Learning Limit. P226C - Turgocharger Boost Control ?A? Slow Response.The Following DTC Has Been Changed From A Two Trip Fault To One Trip Fault: U1A24 - Lost Communication With Ammonia Sensor.Improvements To Prevent/ Reduce Malfunction Indicator Lamp (MIL) Illumination When No Defect Is Present For: U3017 - Control Module Timer/Clock Performance. P0087 - Fuel Rail Pressure Too Low. P2281 - Air Leak Between MAF And Throttle Body. P0544 - Exhaust Gas Temperature Sensor Circuit - Sensor 1/1. P0128 - Thermostat Rationality. In cold ambient temperatures. P214D - SCR NOx Catalyst Outlet Temperature Too High During Particulate Filter Regeneration. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P040B - Exhaust Gas Recirculation Temperature Sensor ?A? Circuit Performance. U1421 - Implausible Ignition Key Off Time Received. P0420 - Catalyst Efficiency Below Threshold. P026B - Injection Timing Performance. P04DB - Crankcase Ventilation System Disconnected. P1C55 - NOx Sensor Intermittent - Bank 1 Sensor 1. P202E - Diesel Exhaust Fluid (DEF) Reductant Injector Performance. P20EE - SCR NOx Catalyst Efficiency Below Threshold - Bank 1. P2002 - Diesel Particulate Filter Efficiency Below Threshold. P0604 - Internal Control Module RAM. P1451 - Diesel Particulate Filter System Performance.Other Updates Included: Urea system calibration changes. Fuel Filter Minder Calibrat |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.
Check one vehicle officially
Contains information licensed under the Open Government Licence – Canada.