NHTSA recall 15V800000
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | NHTSA (United States) |
|---|---|
| Campaign number | 15V800000 |
| Manufacturer's number | R63 |
| Manufacturer | Chrysler (FCA US LLC) |
| Reported | 2015-11-25 |
| Owners notified | 2016-05-09 |
| Component | SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM |
| Units potentially affected | 105425 |
| Report | Quarterly report 6, for 2017 quarter 3 |
|---|---|
| Filed with NHTSA | 2017-10-20 |
| Vehicles in the campaign | 105425 |
| Reported remedied | 66472 (63%) |
| Reported unreachable | 6699 |
| Reported removed | 4 |
These are the manufacturer's totals for the whole campaign at the end of 2017 quarter 3, as filed with NHTSA. They do not say whether one vehicle has been remedied: check the VIN with the official lookups. The reports are from data as of 2026-10-19.
What is wrong
Chrysler Group LLC (Chrysler) is recalling certain model year 2013-2014 Dodge Dart vehicles manufactured February 27, 2012 to January 23, 2014 and equipped with either a 2.0L or 2.4L engine. In affected vehicles, engine oil from the vacuum pump may seep into the brake booster, damaging a component within the brake booster.
What can happen
Internal damage to brake booster could result in a loss of brake assist, lengthening the distance needed to stop the vehicle and increasing the risk of a crash.
The remedy
Chrysler will notify owners, and dealers will inspect the brake booster grommet for the presence of oil. If no oil is found, the vacuum tube assembly will be replaced. If oil is found, the vacuum pump, vacuum tube assembly, brake booster and master cylinder will be replaced. The recall began on May 9, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R63.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
| 2012 DODGE DART | Built 2012-02-27 to 2014-01-23. |
|---|---|
| 2014 DODGE DART | Built 2012-02-27 to 2014-01-23. |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| 09-003-23 | 2023-02-13. Service bulletin. 2.4L Excessive Oil Consumption XB1 Warranty Extension The customer may describe one or more of the following: Oil pressure low indicator lamp illumination between oil changes. Excessive oil consumption. This bulletin involves performing an oil consumption verification test and possibly replacing the long block. |
|---|---|
| 18-023-16 | 2022-12-19. Service bulletin. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: 2015 UF Vehicles with (Sales Codes ED6, ED8) · P050D - Cold Start Rough Idle. · P0335 - Crankshaft Position Sensor Circuit. · P1607 - PCM Internal Shutdown Timer Rationality. · P0133 - O2 Sensor 1/1 Slow Response. · P0456 - EVAP System Small Leak. · P0480 - Cooling Fan 1 Control Circuit/Open. · U0402 - Implausible Data Received From TCM. · P2172 - High Airflow/Vacuum Leak Detected. · P1D73 - AGS Performance. · U0140 - Lost Communication With Body Control Module. · P0441 - Evap Purge System Performance. · P0116 - Engine Coolant Temperature Sensor 1 Performance. In addition to the DTCs above the following improvements have been made: · Engine Startup Flare and Idle Surge. · Improved vehicle acceleration. 2015 PF Vehicles with (Sales Codes ED6, ED8) · **P1066 - Cylinder 1 Oil Supply Solenoid Valve Switch Off Time Out Of Range. · P1068 - Cylinder 2 Oil Supply Solenoid Valve Switch Off Time Out Of Range. · P106A - Cylinder 3 Oil Supply Solenoid Valve Switch Off Time Out Of Range. · P106C - Cylinder 4 Oil Supply Solenoid Valve Switch Off Time Out Of Range.** · U0401 - Implausible Data Received From ECM/PCM - Signal Invalid. · P1185 - General Pressure Sensor Correlation. · P050D - Cold Start Rough Idle. · P0133 - O2 Sensor 1/1 Slow Response. · P0456 - Evap System Small Leak. · P219A - Bank 1 Air-Fuel Ratio Imbalance. · P2172 - High Airflow/Vacuum Leak Detected. · P1D73 - AGS Performance. · U0140 - Lost Communication With Body Control Module. |
| 18-023-16 | 2022-09-19. Service bulletin. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: 2015 UF Vehicles with (Sales Codes ED6, ED8) · P050D - Cold Start Rough Idle. · P0335 - Crankshaft Position Sensor Circuit. · P1607 - PCM Internal Shutdown Timer Rationality. · P0133 - O2 Sensor 1/1 Slow Response. · P0456 - EVAP System Small Leak. · P0480 - Cooling Fan 1 Control Circuit/Open. · U0402 - Implausible Data Received From TCM. · P2172 - High Airflow/Vacuum Leak Detected. · P1D73 - AGS Performance. · U0140 - Lost Communication With Body Control Module. · P0441 - Evap Purge System Performance. · P0116 - Engine Coolant Temperature Sensor 1 Performance. In addition to the DTCs above the following improvements have been made: · Engine Startup Flare and Idle Surge. · Improved vehicle acceleration. 2015 PF Vehicles with (Sales Codes ED6, ED8) · **P1066 - Cylinder 1 Oil Supply Solenoid Valve Switch Off Time Out Of Range. · P1068 - Cylinder 2 Oil Supply Solenoid Valve Switch Off Time Out Of Range. · P106A - Cylinder 3 Oil Supply Solenoid Valve Switch Off Time Out Of Range. · P106C - Cylinder 4 Oil Supply Solenoid Valve Switch Off Time Out Of Range.** · U0401 - Implausible Data Received From ECM/PCM - Signal Invalid. · P1185 - General Pressure Sensor Correlation. · P050D - Cold Start Rough Idle. · P0133 - O2 Sensor 1/1 Slow Response. · P0456 - Evap System Small Leak. · P219A - Bank 1 Air-Fuel Ratio Imbalance. · P2172 - High Airflow/Vacuum Leak Detected. · P1D73 - AGS Performance. · U0140 - Lost Communication With Body Control Module. |
| 18-023-16 | 2022-09-15. Service bulletin. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: 2015 UF Vehicles with (Sales Codes ED6, ED8) · P050D - Cold Start Rough Idle. · P0335 - Crankshaft Position Sensor Circuit. · P1607 - PCM Internal Shutdown Timer Rationality. · P0133 - O2 Sensor 1/1 Slow Response. · P0456 - EVAP System Small Leak. · P0480 - Cooling Fan 1 Control Circuit/Open. · U0402 - Implausible Data Received From TCM. · P2172 - High Airflow/Vacuum Leak Detected. · P1D73 - AGS Performance. · U0140 - Lost Communication With Body Control Module. · P0441 - Evap Purge System Performance. · P0116 - Engine Coolant Temperature Sensor 1 Performance. In addition to the DTCs above the following improvements have been made: · Engine Startup Flare and Idle Surge. · Improved vehicle acceleration. 2015 PF Vehicles with (Sales Codes ED6, ED8) · **U0401 - Implausible Data Received From ECM/PCM - Signal Invalid. · P1185 - General Pressure Sensor Correlation.** · P050D - Cold Start Rough Idle. · P0133 - O2 Sensor 1/1 Slow Response. · P0456 - Evap System Small Leak. · P219A - Bank 1 Air-Fuel Ratio Imbalance. · P2172 - High Airflow/Vacuum Leak Detected. · P1D73 - AGS Performance. · U0140 - Lost Communication With Body Control Module. · P0116 - Engine Coolant Temperature Sensor 1 Performance. · P050B - Cold Start Ignition Timing Performance. · P061A - Level 2 Torque Performance. · P2172 - High Airflow/Vacuum Leak Detected (Instantaneous Accumulation). In addition to the DTCs above the following improvements have been made: |
| 18-023-16 | 2022-08-22. Service bulletin. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: 2015 UF Vehicles with (Sales Codes ED6, ED8) · P050D - Cold Start Rough Idle. · P0335 - Crankshaft Position Sensor Circuit. · P1607 - PCM Internal Shutdown Timer Rationality. · P0133 - O2 Sensor 1/1 Slow Response. · P0456 - EVAP System Small Leak. · P0480 - Cooling Fan 1 Control Circuit/Open. · U0402 - Implausible Data Received From TCM. · P2172 - High Airflow/Vacuum Leak Detected. · P1D73 - AGS Performance. · U0140 - Lost Communication With Body Control Module. · P0441 - Evap Purge System Performance. · P0116 - Engine Coolant Temperature Sensor 1 Performance. In addition to the DTCs above the following improvements have been made: · Engine Startup Flare and Idle Surge. · Improved vehicle acceleration. 2015 PF Vehicles with (Sales Codes ED6, ED8) · U0401 - Implausible Data Received From ECM/PCM - Signal Invalid. · P1185 - General Pressure Sensor Correlation. · P050D - Cold Start Rough Idle. · P0133 - O2 Sensor 1/1 Slow Response. · P0456 - Evap System Small Leak. · P219A - Bank 1 Air-Fuel Ratio Imbalance. · P2172 - High Airflow/Vacuum Leak Detected. · P1D73 - AGS Performance. · U0140 - Lost Communication With Body Control Module. · P0116 - Engine Coolant Temperature Sensor 1 Performance. · P050B - Cold Start Ignition Timing Performance. · P061A - Level 2 Torque Performance. · P2172 - High Airflow/Vacuum Leak Detected (Instantaneous Accumulation). · Low Idle Speed After Cold Start between -10°C to 0°C (14°F to 32°F). · Cold Idle Surge With AC Engaged |
| 05-011-15 | 2022-07-25. Service bulletin. Front Brake Squeak/Squeal Noise This bulletin involves replacing the front brake rotors, front brake pads, and related hardware. The customer may describe a front brake squeak/squeal high frequency noise in the 6-7 kHz range while stopping, noise may be intermittent (not every stop). |
| 05-011-15 | 2018-12-17. Service bulletin. Front Brake Squeak/Squeal Noise This bulletin involves replacing the front brake rotors, front brake pads, and related hardware. The customer may describe a front brake squeak/squeal high frequency noise in the 6-7 kHz range while stopping, noise may be intermittent (not every stop). |
| 18-023-16 REV. D | 2018-06-11. Service bulletin. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: 2015 UF Vehicles with (Sales Codes ED6, ED8) P050D - Cold Start Rough Idle. P0335 - Crankshaft Position Sensor Circuit. P1607 - PCM Internal Shutdown Timer Rationality. P0133 - O2 Sensor 1/1 Slow Response. P0456 - EVAP System Small Leak. P0480 - Cooling Fan 1 Control Circuit/Open. U0402 - Implausible Data Received From TCM. P2172 - High Airflow/Vacuum Leak Detected. P1D73 - AGS Performance. U0140 - Lost Communication With Body Control Module. · P0441 - Evap Purge System Performance. · P0116 - Engine Coolant Temperature Sensor 1 Performance. In addition to the DTCs above the following improvements have been made: · Engine Startup Flare and Idle Surge. · Improved vehicle acceleration. 2015 PF Vehicles with (Sales Codes ED6, ED8) · **P1066 - Cylinder 1 Oil Supply Solenoid Valve Switch Off Time Out Of Range. · P1068 - Cylinder 2 Oil Supply Solenoid Valve Switch Off Time Out Of Range. · P106A - Cylinder 3 Oil Supply Solenoid Valve Switch Off Time Out Of Range. · P106C - Cylinder 4 Oil Supply Solenoid Valve Switch Off Time Out Of Range.** · U0401 - Implausible Data Received From ECM/PCM - Signal Invalid. · P1185 - General Pressure Sensor Correlation. · P050D - Cold Start Rough Idle. · P0133 - O2 Sensor 1/1 Slow Response. · P0456 - Evap System Small Leak. · P219A - Bank 1 Air-Fuel Ratio Imbalance. · P2172 - High Airflow/Vacuum Leak Detected. · P1D73 - AGS Performance. · U0140 - Lost Communication With Body Control Module. · P0116 - Engine Coolant Temperature Sensor 1 Performance. · P050B - Cold Start Ignition T |
| D-160-1 | 2017-11-03. Service bulletin. (X62) Hydraulic Clutch Master Cylinder / Reservoir Hose - 2013-2015 Dodge Dart and 2014-2015 Jeep Cherokee (Rev. A) To announce an extended warranty on the Hydraulic Clutch Master Cylinder/ Reservoir Hose on the following vehicles: ? 2013-2015 Dodge Dart (PF) ? 2014-2015 Jeep Cherokee (KL) |
| D-16-01 | 2016-07-14. Service bulletin. HYDRAULIC CLUTCH MASTER CYLINDER/RESERVOIR HOSE (X62)-2013-2015 DODGE DART AND 2014-2015 JEEP CHEROKEE. |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.