NHTSA recall 10V252000

A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.

What is wrong

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 ROUTAN VEHICLES MANUFACTURED FROM JUNE 2008 THROUGH JULY 2009. THESE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPER ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION. CONTACT WITH A 12V POWER FEED CIRCUIT WITHIN THE HARNESS MAY CAUSE A HIGH RESISTIVE SHORT CIRCUIT WITHIN THE LATCH MECHANISM LOCATED INSIDE OF THE SLIDING DOOR.

What can happen

THIS COULD RESULT IN AN OVERHEATED LATCH AND A FIRE WITHIN THE REAR SLIDING DOOR COULD OCCUR.

The remedy

VOLKSWAGEN WILL INSPECT THE SLIDING DOOR WIRE TRACK WIRE ASSEMBLY AND THE SLIDING DOOR POWER DRIVE UNIT WIRE ASSEMBLY FOR DAMAGE, REPAIR/REPLACE AS NECESSARY, TIE STRAP THE TWO HARNESSES TOGETHER AND ROUTE THE HARNESSES UNDER THE SLIDING DOOR WEATHER STRIP. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 15, 2010. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Notes

VOLKSWAGEN SAFETY RECALL NO. 97S8/T7.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO <A HREF=HTTP://WWW.SAFERCAR.GOV>HTTP://WWW.SAFERCAR.GOV</A> .

A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.

Bulletins for the same vehicles and component

A bulletin is the manufacturer's note to its dealers. It is not part of this recall.

Check one vehicle officially

• NHTSA recall lookup by VIN (United States)
• Transport Canada recall search (Canada)

• Check another vehicle for recalls
• Report an error on this page
• Report an error by email