NHTSA recall 05V527000
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | NHTSA (United States) |
|---|---|
| Campaign number | 05V527000 |
| Manufacturer's number | 074 |
| Manufacturer | HYUNDAI CARIBBEAN-PUERTO RICO |
| Reported | 2005-11-17 |
| Owners notified | 2006-12-06 |
| Component | AIR BAGS:FRONTAL |
| Units potentially affected | 134 |
What is wrong
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN OCCUPANT CLASSIFICATION SYSTEM (OCS) THE RIGHT FRONT SEAT OF THE VEHICLE MAY MISCLASSIFY CERTAIN SMALL CHILDREN SEATED ON THE FRONT EDGE OF THE SEAT AS AN ADULT.
What can happen
THE POSSIBILITY OF MISCLASSIFICATION OF CERTAIN SMALL CHILDREN AS AN ADULT MAY ALLOW THE RIGHT FRONT AIRBAG TO DEPLOY IN A FRONTAL COLLISION CRASH OR THE SIDE IMPACT AIRBAG TO DEPLOY IN A SIDE COLLISION CRASH; SEVERE INJURY OR DEATH COULD OCCUR.
The remedy
DEALERS WILL ENSURE THAT THE VEHICLE'S OCS WILL PROPERLY CLASSIFY CERTAIN SMALL CHILDREN WHEN SEATED ON THE FRONT EDGE OF THE SEAT AND WILL DISABLE THE RIGHT FRONT AIRBAGS. DEALERS WILL REPROGRAM THE VEHICLE'S OCS ELECTRONIC CONTROL UNIT TO PROVIDE AN INCREASED MARGIN FOR RECOGNITION OF CERTAIN SMALL CHILDREN. THE RECALL BEGAN ON DECEMBER 6, 2005. OWNERS MAY CONTACT HYUNDAI OF PUERTO RICO AT 1-800-981-0188.
Notes
HYUNDAI OF PUERTO RICO RECALL NO. 074.CUSTOMERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV.
| 2005 HYUNDAI SANTA FE | Built 2004-08-10 to 2005-11-05. |
|---|
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| DTN DL | 2026-05-08. Other. The National Highway Traffic Safety Administration (NHTSA) has identified the presence of substandard and dangerous driver’s-side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN). These inflators were not supplied, approved, or authorized by the vehicle manufacturers and have primarily been found in vehicles that previously experienced a crash and underwent airbag replacement using non-genuine parts. These dangerous inflators have ruptured during deployment, posing a serious risk of injury or death due to metal fragments entering the vehicle cabin. To date, Hyundai is aware of three people who have died while driving a Hyundai vehicle with one of these substandard replacement airbag inflators that deployed in what likely would have been a survivable crash. NHTSA has issued a public advisory urging vehicle owners and service professionals to have vehicles inspected if there is reason to believe that a non-genuine replacement airbag may have been installed. Vehicles with salvage or rebuilt titles, prior airbag deployments, or unknown repair histories may present a higher risk. NHTSA strongly cautions against self-inspection by vehicle owners and recommends inspection by trained technicians. |
|---|---|
| DTN DCS | 2026-05-08. Other. The National Highway Traffic Safety Administration (NHTSA) has issued an urgent safety advisory regarding dangerous, counterfeit driver‑side airbag inflators manufactured by Jilin Province Detiannuo Automobile Safety System Co., Ltd. (DTN), that have been identified in U.S. vehicles following prior crashes, theft, or non‑certified airbag replacements. These inflators are not approved for use, may rupture during deployment, and have caused serious injuries and fatalities. Please see attached announcement, provided by NHTSA, for more details. |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.