NHTSA recall 04V006000
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | NHTSA (United States) |
|---|---|
| Campaign number | 04V006000 |
| Manufacturer's number | B149 |
| Manufacturer | LAND ROVER |
| Reported | 2004-01-06 |
| Owners notified | 2004-06-02 |
| Component | ENGINE AND ENGINE COOLING |
| Units potentially affected | 5264 |
What is wrong
ON CERTAIN SPORT UTILITY VEHICLES, THE ACTIVE CORNERING ENHANCEMENT (ACE) PUMP BANJO BOLT LOOSES TORQUE AND ALLOWS FLUID TO LEAK PAST THE JOINT.
What can happen
THE FLUID FROM THE PUMP JOINT CAN IGNITE, RESULTING IN AN UNDER HOOD FIRE.
The remedy
DEALERS WILL INSPECT THE VEHICLES FOR LEAKAGE. IF NO LEAKAGE IS EVIDENT, THE BANJO BOLT WILL BE RE-TIGHTENED. IF LEAKAGE IS EVIDENT, THE BANJO BOLT AND DOWTY WASHERS WILL BE REPLACED. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MAY 2004. OWNERS SHOULD CONTACT LAND ROVER AT 1-800-637-6837.
Notes
LAND ROVER RECALL NO. B149.CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
| 2000 LAND ROVER DISCOVERY II | Built 1999-12-13 to 2003-06-17. Listed as a series or trim of this model. |
|---|---|
| 2001 LAND ROVER DISCOVERY II | Built 1999-12-13 to 2003-06-17. Listed as a series or trim of this model. |
| 2002 LAND ROVER DISCOVERY II | Built 1999-12-13 to 2003-06-17. Listed as a series or trim of this model. |
| 2003 LAND ROVER DISCOVERY II | Built 1999-12-13 to 2003-06-17. Listed as a series or trim of this model. |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| SSM56457 | 2017-06-02. Service bulletin. "ISSUE: REPORTS HAVE BEEN RECEIVED OF ENGINE DAMAGE OCCURRING, WHICH IS CAUSED BY THE USE OF NON-APPROVED ENGINE INDUCTION / FUEL INJECTION CLEANING EQUIPMENT OR MATERIALS. THIS INCLUDES, BUT IS NOT LIMITED TO, ""VACU-FLUSH"" TYPE EQUIPMENT. CAUSE: THE USE OF NON-APPROVED EQUIPMENT CAN CAUSE THE ENGINES TO HYDRO-LOCK, OR CAUSE OTHER ENGINE DAMAGE, AND SOMETIMES THE ONLY POSSIBLE REPAIR IS TO REPLACE THE ENGINE." |
|---|---|
| 031201 | 2003-08-21. Service bulletin. OIL PUMP FAILURES. *TT |
| OPS0201 | 2002-07-11. Service bulletin. SUBJECT REGARDING NEW STATE ULEV EMISSIONS REQUIREMENTS. *TT |
| SRE0006 | 2001-02-07. Service bulletin. SUBJECT REGARDING VEHICLE SAFETY RECALL CAMPAIGN D216. CONCERNS WITH THE LOADING CONDITIONS PRESENT ON THE LEFT SIDE ENGINE IDLER PULLEY CAN EXCEED THE MAXIMUM CALCULATED FIGURE OF THE ORIGINAL DESIGN SPECIFICATION. THE MATERIAL OF THE PULLEY CAN FRACTURE AND ULTIMATELY FAIL. *TT |
| 300200NAS | 2000-06-09. Service bulletin. VEHICLE MAY EXPERIENCE ROUGH RUNNING ENGINE SYMPTONS AND POSSIBLE MIL ILLUMINATION. *MJS |
| H202 | 2000-05-05. Service bulletin. SOME VEHICLES WITHIN VIN RANGE XA213405 TO YA250696 MAY EXPERIENCE OVERHEATING WHEN SITTING AT IDLE OR TRAVELING IN VERY SLOW TRAFFIC FOR AN EXTENDED PERIOD (45 MINUTES) EVEN IN MODERATE TEMPERATURES. *TT |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.