NHTSA recall 02V150000
A recall listed here may apply to a vehicle of this year, make and model. Only the manufacturer can say whether it applies to one vehicle: check the VIN with the official lookups.
| Published by | NHTSA (United States) |
|---|---|
| Campaign number | 02V150000 |
| Manufacturer | BAYERISCHE MOTOREN WERKE |
| Reported | 2002-06-03 |
| Owners notified | 2002-06-28 |
| Component | FUEL SYSTEM, GASOLINE:DELIVERY |
| Units potentially affected | 8412 |
What is wrong
ON CERTAIN PASSENGER VEHICLES, THE ELECTRIC FUEL PUMP RUNS AT A ROTATIONAL SPEED THAT COULD RESULT IN REDUCED LUBRICATION OF ITS INTERNAL COMPONENTS. OVER AN EXTENDED PERIOD OF TIME, WEAR-INDUCED INTERNAL DAMAGE TO THE FUEL PUMP COULD RESULT IN INSUFFICIENT FUEL SUPPLY TO THE ENGINE WHEN THE FUEL TANK CONTAINS ONE-THIRD OR LESS OF ITS MAXIMUM FUEL CAPACITY.
What can happen
IF THIS WERE TO OCCUR, THE ENGINE COULD STALL AND NOT BE RESTARTED UNTIL MORE FUEL WAS ADDED TO THE FUEL TANK. THIS COULD OCCUR EVEN THOUGH THE FUEL GAUGE INDICATED THAT FUEL STILL REMAINED IN THE TANK.
The remedy
DEALERS WILL REPROGRAM THE FUEL PUMP CONTROL SYSTEM. OWNER NOTIFICATION BEGAN JUNE 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-800-332-4269.
Notes
CUSTOMERS CAN ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).
| 2002 BMW 745I | Built 2001-10-23 to 2002-05-03. |
|---|---|
| 2002 BMW 745LI | Built 2001-10-23 to 2002-05-03. |
A vehicle with no link is not in this site's catalog, which covers cars, multipurpose vehicles and trucks by model year. The campaign is from data as of 2026-10-19.
Bulletins for the same vehicles and component
| B160623 | 2024-01-03. Service bulletin. Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the DME: 032B43 - Low fuel pressure system, electric fuel pump: pressure value too low CDA594 - Message (- 0x33E) missing, receiver DME, transmitter TFE |
|---|---|
| SIB-16-02-09 | 2010-07-14. Service bulletin. BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS WELL. IN SOME CASES, EPC DOES NOT SHOW THAT THE REPAIR KIT IS AVAILABLE SEPARATELY IN THE ILLUSTRATION, BUT IT IS AVAILABLE IN THE PARTS DESCRIPTION. ALL MODELS. NO MODEL YEARS LISTED. *PE |
A bulletin is the manufacturer's note to its dealers. It is not part of this recall.