Service bulletins for the 2022 Volvo S90
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
386 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
By topic
| 37618.3.4 | 2026-06-08. Service bulletin. UNKNOWN OR OTHER. This is a TJ - Text - plus 2 instruction documents (TJI's) - + 2 PDFS + how to find structure week + flow chart, 6 in all. If the Check Engine Light is on in the DIM and one or more of the DTCs listed below are set, please follow the advice under "Service". |
|---|---|
| 36496.10.0 | 2026-06-08. Service bulletin. POWER TRAIN. This is a Technical Journal: Intermittent knocking noise during acceleration. If the sound corresponds to attached sound file, change front drive shafts to the below part numbers. |
| 36376.6.0 | 2026-06-08. Service bulletin. UNKNOWN OR OTHER. This is a Technical Journal: Text only no attachments - Before replacing a cell module, make sure the latest BECM software is downloaded. This is important for utilizing the VIDA method described here and receiving the correct cell balancing diagnostics after the replacement. |
| 34521.11.1 | 2026-06-08. Service bulletin. EXTERIOR LIGHTING. This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp |
| 37814.1.0 | 2026-05-14. Service bulletin. UNKNOWN OR OTHER. This is a TJ - Text Plus 1 .mp4 file - When using the CSD for seat adjustments mode for example lumbar support and seat Cushing, the visualization does not match the selected part for adjustment. Do not fault trace for this symptom. Advice the customer to use the physical seat mode switch knob. A new improved software is planned to be released during quarter 3 2026. |
| 37813.2.0 | 2026-05-14. Service bulletin. UNKNOWN OR OTHER. This is a TJ - Text plus 1 mp4 file - If, an iCup model year 2026 vehicle equipped with Sound System defined by VDN K501 or K502, experiencing the symptom where the audible turn-indicator sound is out of sync and may occasionally skip a “beep” (see TJ_37813_1.mp4), follow the guidance provided in the Service. |
| 35526.1.8 | 2026-05-14. Service bulletin. ENGINE. This is a Technical Journal: Text plus 2 PDFs and 1 .PNG Oil Consumption test. Perform the test. Follow service procedure Description and Service sections updated to clarify that vehicle reports are not required. |
| 37618.3.3 | 2026-05-14. Service bulletin. UNKNOWN OR OTHER. This is a TJ - Text - plus 2 instruction documents - + 2 PDFS + how to find structure week + flow chart, 6 in all. If the Check Engine Light is on in the DIM and one or more of the DTCs listed below are set, please follow the advice under "Service". 3 steps provided in TJ |
| 36923.9.1 | 2026-05-14. Service bulletin. ENGINE. This is a Technical Journal: Text document plus 1 PDF attachment Coolant Pump Dry Coolant Mix Residue. If the coolant pump has an active leak, a photo must be taken prior to replacement (see example as in attached picture TJ_36923_3). The photo showing the active water pump leak on the vehicle must be saved for the TMA photo return process and provided when requested. Sealing improvements have been made to PNs 32382367, 32441161 and 32382368, but the part numbers are unchanged. To assist with identification of improved parts, a marking has been added to the parts: an "X," as shown in the attached document TJ_36923_1.pdf. If you receive a replacement pump that does not have the "X" marking, please return it and order a replacement |
| 37514.6.0 | 2026-05-14. Service bulletin. UNKNOWN OR OTHER. This is a TJ. Text only no attachments - If a customer complains it is not possible to download third-party apps (only ICUP MY2026 cars affected) follow advice under "Service". Workaround is to perform a "IHU factory reset". analysis will now continue to find the root cause and provide a better improvement. |
| 37809.1.1 | 2026-05-14. Service bulletin. UNKNOWN OR OTHER. This is a TJ text only - The purpose of this TJ is to be a master reference list to easily identify any components that are on prior approval. This TJ will be regularily updated as items are added or removed from prior approval. Current items under prior approval are listed in the "Service" section |
| 37801.1.0 | 2026-05-14. Service bulletin. UNKNOWN OR OTHER. This is a TJ - Text - plus 1 jpg attachment - If customer complains that the rear sun curtain button is missing in CSD, see red marking in attachment TJ_37801_1.jpg, then follow advice in Service. Only valid for S90/S90L with VDN PL03. This issue is planned to be corrected during year 2026 quarter 3 in a software update. |
| 37618.3.3 | 2026-05-14. Service bulletin. UNKNOWN OR OTHER. This is a TJ - Text - plus 2 instruction documents - + 2 PDFS + how to find structure week + flow chart, 6 in all. If the Check Engine Light is on in the DIM and one or more of the DTCs listed below are set, please follow the advice under "Service". 3 steps provided in TJ |
| 34521.10.0 | 2026-04-07. Service bulletin. EXTERIOR LIGHTING. This is a Technical Journal: Headlamp condensation inside lens - information/leak test. If the result is not ok (air leak), it is ok to replace the headlamp |
| 37495.2.0 | 2026-04-07. Service bulletin. UNKNOWN OR OTHER. This is a Tech Journal - Text only no attachments - If a customer experiences a “Propulsion System Performance” message in the DIM with diagnostic trouble code IEM P060700, often in combination with IEM P061A00, please follow the instructions under "Service". |
| 37773.1.2 | 2026-04-07. Service bulletin. UNKNOWN OR OTHER. This is a TJ - Text only no attachments - If customer experiences an incorrect ambient temperature reading in DIM (Driver Information Module) or reduced A/C performance, follow the advice under Service. Please refer to the wiring diagram in VIDA to locate the relevant circuit for the ambient temperature sensor (component 7/481) at the passenger door mirror harness. |
| 37511.1.0 | 2026-04-07. Service bulletin. UNKNOWN OR OTHER. This is a TJ - 1 txt file plus 3 PDF's - If the customer complains about any of the below symptoms after updating vehicle to next software release (5.0.x or later,) either with VIDA or OTA, follow instruction under "Service". |
| 37438.4.0 | 2026-04-07. Service bulletin. UNKNOWN OR OTHER. This is a Technical Journal - text plus 1 jpg : iCUP IHU - If, during a Software Download (SWDL) at the workshop, connected to VIDA, the CSD (Center Stack Display) turns black and the IHU (Infotainment Head Unit) becomes stuck in programming mode or is unresponsive, follow the advice under "Service". Follow the recommended procedure depending on the MY (Model Year) of the vehicle |
| 34295.9.0 | 2026-04-07. Service bulletin. ELECTRICAL SYSTEM. This is a Technical Journal: Text plus 2 attachments 1 PDF and 1 PNG - High Voltage Battery repairs. Always repair the battery according to the methods in VIDA. This TJ is a guide to the kinds of repairs that can be done instead of a complete HV battery replacement. Parts, methods, and tools are now available to repair almost all faults within the High Voltage Battery. |
| 37236.5.1 | 2026-04-07. Service bulletin. FUEL/PROPULSION SYSTEM; UNKNOWN OR OTHER. This is a Technical Journal: Text only no attachments - CEL and DTC ECM P04F000. New ECM software has been released |
| 36376.5.1 | 2026-04-07. Service bulletin. UNKNOWN OR OTHER. This is a Technical Journal: Text only no attachments - Before replacing a cell module, make sure the latest BECM software is downloaded. This is important for utilizing the VIDA method described here and receiving the correct cell balancing diagnostics after the replacement. |
| 37480.2.0 | 2026-04-07. Service bulletin. UNKNOWN OR OTHER. This is a Tech Journal - Text plus 1 jpeg--- This Technical Journal is rewritten in its entirety. When the vehicle has 5.0.X software installed, it includes the new Volvo Car UX for both Centre Display and the Driver Display, see attachment TJ_37480_1.jpg. After installing the update, follow advice under "Service". |
| 36923 | 2026-03-02. Service bulletin. ENGINE. This is a Technical Journal: Text document plus 1 PDF attachment Coolant Pump Dry Coolant Mix Residue. If the coolant pump has an active leak, a photo must be taken prior to replacement (see example as in attached picture TJ_36923_3). The photo showing the active water pump leak on the vehicle must be saved for the TMA photo return process and provided when requested. Sealing improvements have been made to PNs 32382367, 32441161 and 32382368, but the part numbers are unchanged. To assist with identification of improved parts, a marking has been added to the parts: an "X," as shown in the attached document TJ_36923_1.pdf. If you receive a replacement pump that does not have the "X" marking, please return it and order a replacement |
| 37710 | 2026-03-02. Service bulletin. UNKNOWN OR OTHER. This is a TJ - text, plus 2 PDF's - If there is a "Check Engine Light" lit in the DIM with one or a combination of the DTC's listed below, please follow the advice for checks and inspection procedures under "service". |
| 37664 | 2026-03-02. Service bulletin. UNKNOWN OR OTHER. This is a TJ Text only no attachments - If the Check Engine Light is on in the DIM and the DTCs listed below are set with no other symptoms, Do not replace any parts. Please follow the advice under "Service". This TJ is a complement to the fault tracing in VIDA. Inform the customer that driving for too long with low loads creates a risk that this DTC will be set, and they should accelerate more aggressively periodically. |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.