WenmarOpen by Wenmar Pro

Service bulletins for the 2001 Volkswagen Passat

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

219 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Only bulletins with component: Engine are shown. Show all

Bulletins, newest first
V011615 20148152018-01-08. Service bulletin. ENGINE. Update to include additional model year applicability.
TT 21-13-012017-12-14. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER. Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. This document informs the procedure of checks for damage.
V171302 20178132017-12-14. Service bulletin. ENGINE AND ENGINE COOLING. Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrication and cooling of internal engine components, all internal combustion engines consume a certain amount of engine oil. Oil consumption varies from engine to engine and may change significantly over the life of the engine. Typically, engines with specified break-in periods consume more oil during the break-in period, and the oil consumption will stabilize after the break-in period. This document informs of oil consumption tests to check a vehicles performance.
TT 24-08-012017-12-05. Service bulletin. ENGINE. Tech Tips (Models with 1.8T Engine - Pressure Loss issues): Fault code P1297 may be set and fuel mixtures may go lean if the vehicle is driven under load or revved up and then returned to idle. This document informs of what to do should these systems occur.
V011408 20148152017-12-05. Service bulletin. ENGINE. Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of deposits on intake valves, intake manifold, fuel injectors and combustion chambers. -Engine runs rough after cold start. -Excessive engine cranking time. -Stumbles while driving. -Rough engine idle. -Loss of engine performance. -Poor fuel economy. This document informs of the procedure for the vehicle if it is diagnoised with poor quality gas
V871506 20199472017-11-08. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER; ENGINE AND ENGINE COOLING. Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. This document contains information on how to diagnose, and service this issue.
V871508 20055662017-11-08. Service bulletin. EQUIPMENT; ENGINE AND ENGINE COOLING. Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. This document contains information on how to diagnose, and service this issue.
V171404 20128552017-10-21. Service bulletin. ENGINE. Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality Standard
TB-01-12-042012-04-14. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. VOLKSWAGEN: GASOLINE ENGINES HAVE ROUGH IDLE, HAVE SIGNIFICANT LOSS OF POWER OR STALLING WITH REDUCED PERFORMANCE. *PE
SAC-28F3/P1-REV2011-03-23. Service bulletin. ELECTRICAL SYSTEM:IGNITION; ENGINE AND ENGINE COOLING:ENGINE; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL. VOLKSWAGEN: GASOLINE ENGINE VEHICLES INSPECT, AND IF NECESSARY, REPLACE IGNITION COILS. VEHICLES AFFECTED BY THIS ACTION MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. MODELS PASSAT AND WAGON; GOLF; GTI; JETTA AND WAGON; NEW BEETLE AND CONVERTIBLE; PHAETON; EOS; RABBIT, ETC. *PE
SA-28F32010-07-26. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE; ELECTRICAL SYSTEM:IGNITION. VOLKSWAGEN: (REVISED) VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PERFORMANCE. IN SOME CASES, A MALFUNCTIONING IGNITION COIL MAY CAUSE A VEHICLE TO EXCEED FEDERAL AND/OR CALIFORNIA EMISSIONS STANDARDS. 2001-2007 PASSA/PASSAT WAGON. *PE UPDATED 8/9/10. *PE UPDATED 11/8/10. *PE UPDATED 12/8/10. *PE UPDATED 2/28/11. *PE UPDATED 3/21/11. *PE
SB-28F32010-07-26. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE; ELECTRICAL SYSTEM:IGNITION. VOLKSWAGEN: VEHICLES MAY HAVE IGNITION COILS THAT COULD MALFUNCTION UNDER CERTAIN CONDITIONS. IF THIS HAPPENS, THE MALFUNCTION INDICATOR LAMP (MIL) WILL ILLUMINATED TO LET YOU KNOW THAT THE VEHICLE MAY EXPERIENCE SOME DETERIORATION IN PERFORMANCE. IN SOME CASES, A MALFUNCTIONING IGNITION COIL MAY CAUSE A VEHICLE TO EXCEED FEDERAL AND/OR CALIFORNIA EMISSIONS STANDARDS. NO MODELS LISTED. *PE
TB-07-09-062009-09-25. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. VOLKSWAGEN: ENGINE OIL PRESSURE TOO LOW, LIGHT IS ON, ENGINE FLUSH. THE LOW ENGINE OIL PRESSURE CONDITION MAY BE CAUSED BY A RESTRICTION OF THE OIL PUMP SUCTION LINE STRAINER. *PE
20158312008-12-30. Service bulletin. STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. VOLKSWAGEN: EXHAUST HEAT SHIELD, REPLACEMENT GUIDELINES. HEAT SHIELDS ARE TO BE INSPECTED AFTER COMPLETION O ANY TYPE OF REPAIR TO THE UNDERBODY (EXHAUST SYSTEM TRANSMISSION, ETC.), AND IF DAMAGED, REPLACED. *PE
20132332007-04-26. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. ENGINE OIL PRESSURE TOO LOW, LIGHT IS ON, ENGINE FLUSH. *KB
0107022007-04-03. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS. DTC'S P1297 (17705) OR P1557 (17965) STORED IN DTC MEMORY. THIS MAY BE CAUSED BY INTAKE HOSES LEAKING (DURING BOOST CONDITIONS) DUE TO INCORRECT TORQUE ON CLAMPS OR IMPROPER PLACEMENT, WORN OR TORN INTAKE HOSES. *KB
05132005-08-23. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR. UPDATE PROGRAMMING FOR CATALYTIC CONVERTER SYSTEM. *SC
0042005-01-27. Service bulletin. ENGINE AND ENGINE COOLING. ENGINE COOLANT TEMPERATURE (ECT) SENSOR. *TC
04032004-12-01. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. VALVE COVER, DIAGNOSING OIL LEAKAGE FROM GASKETS. *TT
04022004-11-02. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. LOW ENGINE OIL PRESSURE LIGHT IS ON. *TT
04012004-11-02. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. ENGINE OIL SPECIFICATIONS, OIL CAPACITY, OIL FILTER. *TT
04212004-11-02. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. OIL SLUDGE - WARRANTY EXTENSION FOR 1998-2004 MODEL YEAR VOLKSWAGEN PASSAT WITH 1.8L TURBO ENGINE US AND CANADIAN DEALERS. SERVICE CIRCULAR. *TT
04212004-11-02. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. WARRANTY EXTENSION COVERING CERTAIN OIL SLUDGE RELATED REPAIRS. *TT
04032004-08-31. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. ENGINE, FLUCTUATING IDLE OR IDLE SPEED TOO LOW. *MJ
04022004-07-21. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. ENGINE, FLUCTUATING IDLE OR IDLE SPEED TOO LOW. *MJ

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.