Service bulletins for the 2014 Ram 5500
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
355 on file from NHTSA, as of 2026-10-19.
By type
By component
By trouble code
| 18-002-14 REV. A | 2018-06-11. Service bulletin. ELECTRICAL SYSTEM; FUEL SYSTEM, GASOLINE. Flash: Diagnostic And System Improvements This bulletin involves selectively erasing and reprogramming the Engine Control Module (ECM/PCM) with new software. Several software improvements are available for vehicles equipped with a Cummins 6.7L turbo Diesel. Software To Prevent Or Reduce Unnecessary Malfunction Indicator Lamp (MIL) Illumination For The Following Diagnostic Trouble Codes (DTCs). These DTCs Are Currently Tripped As A One Trip Fault And Should Have Been A Two Trip Fault: ? P0201 - P0206 - FUEL INJECTOR X CIRCUIT/OPEN Fault Codes. ? U110E - LOST AMBIENT TEMPERATURE MESSAGE. ? P049D - EGR CONTROL POSITION EXCEEDED LEARNING LIMIT. Improvements To Prevent Or Reduce Unnecessary Malfunction Indicator Lamp (Mil) Illumination For: ? P0087 - FUEL RAIL PRESSURE TOO LOW. ? P0544 - EXHAUST GAS TEMPERATURE SENSOR CIRCUIT - SENSOR 1/1. ? P2281 - AIR LEAK BETWEEN MAF AND THROTTLE BODY. ? P0128 - THERMOSTAT RATIONALITY. In low ambient temperatures. ? U3017 - CONTROL MODULE TIMER/CLOCK PERFORMANCE. ? U1421 - IMPLAUSIBLE IGNITION KEY OFF TIME RECEIVED. ? P202E - (DIESEL EXHAUST FLUID) REDUCTANT INJECTOR PERFORMANCE. ? P20EE - SCR NOx CATALYST EFFICIENCY BELOW THRESHOLD - BANK 1. ? P2002 - DIESEL PARTICULATE FILTER EFFICIENCY BELOW THRESHOLD. ? P0604 - INTERNAL CONTROL MODULE RAM ERROR. This DTC may be caused by enabling the remote throttle feature via the EVIC, and it will be accompanied by a ?service electronic throttle control? message in the EVIC. Other Updates: ? Fuel Filter Minder Calibration Changes ? Cruise control system improvements. ? Improvements in exhaust brake switch operation. ? Charging system improvements for dual alternator applications. ? Various wiTECH data and system test additions and improvements. ? OBD Template changes for P2453. ? Dual Fuel Tank component update. ? Inducement Timer Reset (Feature enable in wiTech). ? PTO Denied Status Message Update. ? PTO Horn Request sen |
|---|---|
| BJA46597 | 2018-06-11. Service bulletin. EQUIPMENT ADAPTIVE/MOBILITY; EQUIPMENT; POWER TRAIN. Job aid - If you have a suspected TC shudder/vibration, check the Interactive Network for Service Bulletins for the vehicle you are working on. A test-drive snap shot may help you isolate the source of the issue. |
| 09-004-16 REV. A | 2018-06-04. Service bulletin. EQUIPMENT; ENGINE AND ENGINE COOLING. Cummins Service Engine Replacement This bulletin involves replacing the engine assembly. Remanufactured long block or short block was installed during a prior repair. A new replacement engine will be installed. |
| 9003740 | 2018-06-04. Service bulletin. ENGINE AND ENGINE COOLING. Oil Pan 2012-2017 Cummins engines with oil pan leaks, please inspect the shallow area of the oil pan for cracks. If cracks are found, please replace as necessary. Cracks are typically found above the cross member area. Please contact Chad Eichbrecht at cell (248) 309-2695 to arrange for part return or email chad.w.eichbrecht@fcagroup.com If you do not receive a response within 15 minutes, please proceed with normal repair. |
| 68184926A$ | 2018-05-21. Service bulletin. ELECTRICAL SYSTEM. Integrated Center Stack If vehicle is found within 50 mile radius of the Detroit Metro area please hold vehicle and contact:~ Contact one of the following:~ Daniel Acciacca CELL (586) 709-1537~ Michael Savich CELL (248) 214-7270~ Ayed Hadaad CELL (248) 941-8707~ Issue: On a 2015 & 2016MY LA (Challenger), LD(Charger) and LX (300), the Integrated Center Stack (ICS) may experience a lock-up/Inop condition (complete loss of functionality) during any vehicle diagnostic session (reading fault codes, clearing fault codes, reflashing of any module, etc.). If this occurs, do not replace the ICS. The module functionality can be restored if it is reset by disconnecting power to it (by removing fuse, battery disconnect or module connector disconnect).~ |
| 68103198A$ | 2018-05-21. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. A/C Compressor This applies to 2015 and 2016 UF and PF. Before replacing the AC compressor for noise, leaks , or in-op:~ After these questions have been answered please call one of the individuals below.~ Stev at cell (248) 867-0061~ Mark Briolat at cell (248) 345-0127~ If no response in 15 minutes, please continue with repair.~ 1) Check all AC plumbing connection for leaks with UV light. Any leaks found?~ 2) Does compressor pulley and clutch hub turn freely, or are they seized?~ 3) What was the amount of the recovered refrigerant?~ After these questions have been answered please call one of the individuals below.~ Stev at cell (248) 867-0061~ Mark Briolat at cell (248) 345-0127~ If no response in 15 minutes, please continue with repair.~ If the compressor is replaced, then:~ 4) Drain oil from compressor. What was quantity of oil recovered? |
| 05091960A$ | 2018-05-21. Service bulletin. ELECTRICAL SYSTEM. Hands Free Module - CTM ? Peiker For RT, JK and MK bodies only; Before replacing the Hands Free Module (HFM), please contact Gaurav Saxena at cell (248) 260-0583~ IMPORTANT - do not reset the HFM, clear codes or perform a battery reset before calling. Engineering is currently root causing this issue and your assistance is greatly appreciated. Seeking vehicles with HFM in a locked state, inoperative, or offline. If unable to reach this person within 15 minutes, then proceed with the necessary repair. |
| 05066241A$ | 2018-05-21. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. Battery - Transmitter For vehicles within 12 Months in Service which have a "FOB Battery Low" message within Cluster or DTC B1A10 or B1A11 Active or Stored. Engineering is requesting complete FOB returned unopened (ie, battery not removed or FOB housing opened!). ~ All others, follow normal procedures.~ Please ensure Dealer Technicians are aware of this request to allow for gain in FOB Battery depletion understanding. |
| 14-001-14 REV. A | 2018-05-21. Service bulletin. FUEL SYSTEM, DIESEL. Fuel Gelling in Cold Ambient Temperatures This bulletin involves reconfiguring the Body Control Module (BCM). Some customers may experience a Malfunction Indicator Lamp (MIL) due to fuel related Diagnostic Trouble Code (DTC) and/or may have a hard or no start condition due to fuel gelling in cold ambient temperatures (20°F or -7°C) or below. DTC?s, such as P0087, P0191 or P026B (or other DTC?s) may have been set. Ram Trucks equipped with a 6.7L Cummins Turbo Diesel included on the RRT VIN list exhibiting the above concerns have a condition that will cause the frame mounted fuel filter heater not to function. The condition is due to a configuration setting in the Body Control Module (BCM). NOTE: The engine mounted fuel filter heater is operating properly. |
| 14-001-14 | 2018-05-21. Service bulletin. FUEL SYSTEM, DIESEL; ELECTRICAL SYSTEM. Fuel Gelling in Cold Ambient Temperatures This bulletin involves reconfiguring the Body Control Module (BCM). Some customers may experience a Malfunction Indicator Lamp (MIL) due to fuel related Diagnostic Trouble Code (DTC) and/or may have a hard or no start condition due to fuel gelling in cold ambient temperatures (20°F or -7°C) or below. DTC?s, such as P0087, P0191 or P026B (or other DTC?s) may have been set. Ram Trucks equipped with a 6.7L Cummins Turbo Diesel included on the RRT VIN list exhibiting the above concerns have a condition that will cause the frame mounted fuel filter heater not to function. The condition is due to a configuration setting in the Body Control Module (BCM). NOTE: The engine mounted fuel filter heater is operating properly. |
| 18-002-14 | 2018-05-21. Service bulletin. FUEL SYSTEM, DIESEL; ELECTRICAL SYSTEM. Flash: Diagnostic and System Improvements This bulletin involves selectively erasing and reprogramming the Engine Control Module (ECM/PCM) with new software. Several software improvements are available for vehicles equipped with a Cummins 6.7L turbo Diesel. Prevent Or Reduce Unnecessary Malfunction Indicator Lamp (MIL) Illumination For The Following Diagnostic Trouble Codes (DTC?s). These DTC?s Are Currently Tripped As A One Trip Fault And Should Have Been A Two Trip Fault: ? P049D - EGR CONTROL POSITION EXCEEDED LEARNING LIMIT Improvements To Prevent Or Reduce Unnecessary Malfunction Indicator Lamp (Mil) Illumination For: ? P202E - (DIESEL EXHAUST FLUID) REDUCTANT INJECTOR PERFORMANCE ? P20EE - SCR NOx CATALYST EFFICIENCY BELOW THRESHOLD - BANK 1 ? P2002 - DIESEL PARTICULATE FILTER EFFICIENCY BELOW THRESHOLD ? P0604 - INTERNAL CONTROL MODULE RAM ERROR. This DTC may be caused by enabling the remote throttle feature via the EVIC, and it will be accompanied by a ?service electronic throttle control? message in the EVIC. Other Updates: ? OBD Template changes for P2453 ? Fuel Filter Minder Calibration Changes ? Dual Fuel Tank component update ? Inducement Timer Reset (Feature enable in wiTech) ? PTO Denied Status Message Update ? PTO Horn Request sent to Body Control Unit (BCU) ? Wait To Start (WTS) bulb check timing improvements (1 second) ? Frozen CAC Diagnostic Improvement |
| 9002519 | 2018-02-21. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. 82212076, 82203694 - Fabric Cleaner This "fabric cleaner" is not intended for sale in California, the otc states (Connecticut, Delaware, Massachusetts, Maine, New Hampshire, New Jersey, New York, Pennsylvania, Virginia, and Washington dc), and some ladco states (Illinois, Michigan, and Ohio). Mopar offers an alternative product (82213192) which is a water based product approved for sale in the aforementioned states.~ ~ Please inform the customer & your prep dept that spraying excessive amounts of the fabric protector on load floors will result in the breaking down of the adhesive (glue) that is used to create the bond between the fabric (carpet) and the load floor. This will apply to any vehicles equipped with rear load floors such as WK, WD, PM, MK, KA, KK. The carpet will appear to be loose, wrinkly, or bunch up~ |
| RL108213A$ | 2017-11-03. Service bulletin. ENGINE AND ENGINE COOLING. NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~ |
| 9003355 | 2017-11-03. Service bulletin. ENGINE AND ENGINE COOLING. 3.2L - 3.6L Cylinder Head Assy Multiple cylinder head replacement. If a cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people. First: Joe Lovell - Cell (734) 309-6467 joe.lovell@fcagroup.com Second: Kevin Refalo - Cell (248) 260-0738 Kevin.refalo@facgroup.com If no response in 15 minutes, proceed with repair. |
| 68232786A$ | 2017-11-03. Service bulletin. ENGINE AND ENGINE COOLING. Housing: Oil Filter Adapter Cummins equipped trucks ONLY; If you are replacing the oil filter adapter as a result of thread damage to the oil filter connector (Spud), DO NOT replace the entire adapter assembly. The oil filter connector is available separately (Part Number 04429355).~ If ordering an adapter due to some other issue, you must also order an oil bypass valve Mopar Part # 04797726AB, as these are not reusable. Please refer to all applicable published service information for oil bypass valve installation |
| 08-054-16 | 2016-07-14. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. SUBJECT: RA3 RA4 Radio Enhancements OVERVIEW: This bulletin involves inspecting and updating the radio software, if required. SYMPTOM/CONDITION: **Improvements: · Ability to communicate with Siri via UConnect. · Ability to press Voice Recognition (VR) button for more than one second.** |
| 18-079-15 | 2016-06-22. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. SUMMARY TO BE PROVIDED ON A FUTURE DATE. |
| 18-042-15 | 2016-06-22. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. SUMMARY TO BE PROVIDED ON A FUTURE DATE. |
| 18-038-16 | 2016-06-22. Service bulletin. ENGINE. SUMMARY TO BE PROVIDED ON A FUTURE DATE. |
| 18-028-16 | 2016-06-22. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. SUMMARY TO BE PROVIDED ON A FUTURE DATE. |
| 21-015-14 | 2016-06-02. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE. SUMMARY TO BE PROVIDED ON A FUTURE DATE. |
| D-13-37 | 2016-06-02. Service bulletin. ENGINE. SUMMARY TO BE PROVIDED ON A FUTURE DATE. |
| 26-001-14 | 2016-05-13. Service bulletin. EQUIPMENT. SUMMARY TO BE PROVIDED ON A FUTURE DATE. |
| 25-006-13 | 2016-05-13. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. SUMMARY TO BE PROVIDED ON A FUTURE DATE. |
| 25-005-14 | 2016-05-13. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. SUMMARY TO BE PROVIDED ON A FUTURE DATE. |
The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.