WenmarOpen by Wenmar Pro

Service bulletins for the 2017 Kia Optima

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

210 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Bulletins, newest first
TSBTRA047_R22018-03-13. Service bulletin. POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT. TSB - DRIVESHAFT SERVICEABILITY - This bulletin has been revised most recently to include additional information. This bulletin provides information regarding axle shaft serviceability for Kia vehicles equipped with a six-speed automatic transmission.
TSBENG175_R22018-03-13. Service bulletin. EQUIPMENT. TSB - SERVICE ACTION: E-CVVT COVER INSPECTION AND MOTOR PLUG REPLACEMENT (SA305) - This bulletin has been revised to include additional information. This bulletin provides information regarding the inspection and/or replacement of the E-CVVT cover or O-ring and replacement of the motor plug on some 2016-2017MY Optima (JF, JFa), 2016-2017MY Sorento (UMa), and 2017MY Sportage (QL) vehicles, equipped with 2.4L GDI or 2.0T-GDI, which may exhibit a malfunction indicator light (MIL) ON with DTC P001000 and/or oil leakage in the E-CVVT motor plug of applicable vehicles.
TSBELE1432018-03-13. Service bulletin. EXTERIOR LIGHTING:BRAKE LIGHTS; EXTERIOR LIGHTING. TSB - SERVICE ACTION: OUTSIDE REAR COMBINATION LAMP HARNESS REPLACEMENT (SA334) - This bulletin provides the procedure to replace the outside rear combination lamp harness on some 2016-2017MY Optima (JFa) vehicles, produced from September 25, 2016 through March 16, 2017, which may exhibit an intermittent inoperative brake light with the possibility of a ?Check brake light? warning on the instrument cluster display.
TSBTRA072A_R12018-02-12. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT; ELECTRICAL SYSTEM:IGNITION:SWITCH; ELECTRICAL SYSTEM; ENGINE. TSB - SERVICE ACTION: INHIBITOR SWITCH REPLACEMENT (SA317A) - This bulletin provides the procedure to replace the inhibitor switch on some 2017MY Optima (JFa), Sorento (UMa), Optima Hybrid (HEV), Optima Plug-in Hybrid (PHEV), Sportage (QL), Forte (YD), and Sedona (YP) vehicles, equipped with a front wheel drive 6-speed transmission, which may experience the concerns listed below. These concerns may be due to the inhibitor switch not allowing the correct gear position signal to be sent to various control units.
TSBTRA072A2018-01-16. Service bulletin. WHEELS; ELECTRICAL SYSTEM. TSB - SERVICE ACTION: INHIBITOR SWITCH REPLACEMENT (SA317A) - This bulletin provides the procedure to replace the inhibitor switch on some 2017MY Optima (JFa) and Sorento (UMa), produced from August 29, 2016 through June 15, 2017, and some 2017MY Optima Hybrid (HEV) and Optima Plug-in Hybrid (PHEV) vehicles, produced from June 27, 2016 through April 4, 2017, and equipped with a front wheel drive 6-speed transmission, which may experience the concerns listed below. These concerns may be due to the inhibitor switch not allowing the correct gear position signal to be sent to various control units.
TSBTRA072_CLOSED2018-01-16. Service bulletin. UNKNOWN OR OTHER. TSB - TRA072/SA317 CLOSED. REFER TO TSB TRA072A/SA317A
TSBENG1742017-11-14. Service bulletin. FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS. TSB - SERVICE ACTION: AIR INTAKE HOSE REPLACEMENT & ECU UPGRADE (SA303) - This bulletin provides the procedure to replace the air intake hose and/or improve the logic of the Electronic Control Unit (ECU) on some 2016-2017MY Optima (JFa), produced from September 4, 2015 through April 14, 2017, and some 2016-2017MY Sorento (UMa) vehicles, produced from November 19, 2014 through May 1, 2017, equipped with a 2.0T engine, which may exhibit an impaired air intake hose.
PS5242017-11-14. Service bulletin. ELECTRICAL SYSTEM:WIRING: REAR COMPARTMENT/TRUNK. PITSTOP - OPTIMA TRUNK TORSION BAR ADJUSTMENT - On some 2016-2018MY Optima (JFa) vehicles, there may be a concern with the trunk not opening as designed when using transmitter key fob or Smart Trunk feature. This may be caused by improper assembly of the trunk torsion bar (A) and trunk lid hinge. Follow the procedure in this publication to correct this concern.
PS5222017-11-14. Service bulletin. ELECTRICAL SYSTEM. PITSTOP - ECO-COASTING (ECOASTING) & ECO-DAS (DRIVING ASSISTANT SYSTEM) OVERVIEW ? CUSTOMER TIP - This Pitstop provides information regarding Eco-Coasting Guide (eCoasting) and Eco-Driving Assistant System (DAS) found on 2017-18MY Niro (DE HEV), Niro Plug-in (DE PHEV), Optima Hybrid (JF HEV), and Optima Plug-in (JF PHEV) vehicles.
PS5202017-11-14. Service bulletin. ELECTRICAL SYSTEM. PITSTOP - HYBRID POWER CONTROL UNIT 30A DC FUSE - The 2017MY~ Optima Hybrid (JF HEV), Optima Plug-in Hybrid (JF PHEV), and Niro (DE HEV) vehicles are equipped with a replaceable 30A fuse for the eCompressor. This fuse is easily accessible under a cover between the power cable connector and inverter cable, as shown below. However, the housing for the fuse is internally bolted to the HPCU assembly and is only available as part of the HPCU assembly. Forcibly removing the fuse housing assembly will result in damaging the internal HPCU terminals which will require replacement of the entire HPCU assembly and is not covered under Warranty.Follow the procedure in this ublication to inspect and/or replace the fuse, or refer to the ?Hybrid Control System ? Hybrid Control System ? DC Fuse ? Repair procedures? chapter in the applicable Shop Manual on KGIS.
TSBENG175R12017-10-15. Service bulletin. EQUIPMENT:MECHANICAL. TSB - SERVICE ACTION: E-CVVT COVER INSPECTION AND MOTOR PLUG REPLACEMENT (SA305) - REVISED - This bulletin provides information regarding the inspection and/or replacement of the E-CVVT cover or O-ring and replacement of the motor plug on some 2016-2017MY Optima (JF, JFa), 2016-2017MY Sorento (UMa), and 2017MY Sportage (QL) vehicles, equipped with 2.4L GDI or 2.0T-GDI, which may exhibit a malfunction indicator light (MIL) ON with DTC P001000 and/or oil leakage in the E-CVVT motor plug of applicable vehicles.
TSBENG1752017-10-15. Service bulletin. EQUIPMENT:MECHANICAL. TSB - SERVICE ACTION: E-CVVT COVER INSPECTION AND MOTOR PLUG REPLACEMENT (SA305) - This bulletin provides information regarding the inspection and/or replacement of the E-CVVT cover or O-ring and replacement of the motor plug on some 2016-2017MY Optima (JF, JFa), 2016-2017MY Sorento (UMa), and 2017MY Sportage (QL) vehicles, equipped with 2.4L GDI or 2.0T-GDI, which may exhibit a malfunction indicator light (MIL) ON with DTC P001000 and/or oil leakage in the E-CVVT motor plug of applicable vehicles.
TSBENG162R12017-10-15. Service bulletin. ELECTRICAL SYSTEM. TSB - DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC17) - Revised - This bulletin provides information related to extracting ?in use performance tracking? emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California.
TSBENG1622017-08-25. Service bulletin. ENGINE. TSB: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC17) - This bulletin provides information related to extracting ?in use performance tracking? emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting. To facilitate collection of this data at the dealer level, KDS screenshots will allow the capture of relevant parameters.
PS5082017-08-25. Service bulletin. ENGINE AND ENGINE COOLING; FUEL SYSTEM, GASOLINE. PITSTOP: ?FILL INVERTER COOLANT? MESSAGE AFTER REPAIR - Some technicians may report seeing the ?fill inverter coolant? message on the cluster after performing an HEV system service requiring the coolant to be drained. The logic for this message is such that it will be displayed when the RPM of the EWP climbs while line load goes down, indicating a possible cavitation. This is due to air in the system. Much like bleeding any fluid system utilizing a pump, the hybrid cooling system must be bled in a particular manner to avoid aeration.
PS497R22017-08-25. Service bulletin. VISIBILITY; EQUIPMENT ADAPTIVE/MOBILITY. PITSTOP - UVO ESERVICES MIRROR BUTTONS (CUSTOMER GUIDE) - This pitstop provides information regarding the functionality of the UVO eServices buttons located on the rear view mirror in some 2016-2017MY K900 (KH), 2017MY Optima Plug-in Hybrid (JF PHEV) and 2017MY Soul EV (PS EV) vehicles.
PS4962017-08-25. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION; EQUIPMENT ADAPTIVE/MOBILITY. PITSTOP: CUSTOMER TIP: ACCELERATOR PEDAL FUNCTION/DESCRIPTION - On all K900 (KH), Cadenza (VG, YG), and Optima (JF, JFa, JF-HEV, JF-PHEV) vehicles, the accelerator pedal features a small detent with a spring to provide increased resistance to help avoid unnecessary fuel consumption when applying full throttle. When the driver depresses the pedal beyond the resistance where the detent is felt (above 85% WOT), the pedal will easily reach WOT and kickdown shift will occur accordingly. For additional information, refer to the individual vehicle?s Owner?s Manual under section ?Driving Your Vehicle? ? Automatic Transmission (Drive).
PS4742017-08-25. Service bulletin. ELECTRICAL SYSTEM. PITSTOP: TPMS SENSOR POSITION - When diagnosing TPMS-related DTCs, make sure you are investigating the correct sensor. The TPMS positioning from the manufacturer may be different from the positioning shown on a KDS.
TSBELE131R12017-08-15. Service bulletin. ELECTRICAL SYSTEM. TSB: SERVICE ACTION: VOLTAGE REGULATOR PERFORMANCE ENHANCEMENT (SA278) - This bulletin has been revised to include additional information. This bulletin provides the procedure to increase the torque on the voltage regulator screws on some 2017MY Sorento (UMa), produced from October 3, 2016 to January 24, 2017, and 2017MY Optima (JFa) vehicles, produced from October 3, 2016 to January 26, 2017, which may experience low battery voltage or a no-start condition.
PS353R12017-08-02. Service bulletin. EQUIPMENT; EQUIPMENT ADAPTIVE/MOBILITY. PITSTOP: NAVIGATION HEAD UNIT REPLACEMENT - This article provides information regarding navigation head unit replacement on 2015 - 2017MY Soul EV (PS EV), 2016 - 2017MY K900 (KH), and 2017MY Optima Plug-in Hybrid (PHEV). It is important to note that the head units in these vehicles contain a modem and should NOT be swapped between vehicles under any circumstances. Swapping a head unit from one vehicle to another may result in a non-operational UVO eServices on one of the vehicles. If a head unit needs to be replaced, the factory recommendation is to always order a replacement head unit to ensure proper eServices operations using the new installed/replaced head unit.
PS4982017-08-02. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER; VISIBILITY. PITSTOP: ANTI-CONDENSATION LOGIC ? NORMAL OPERATION, DISABLING, AND ENABLING - Some Kia vehicles starting with 2016MY and all Kia vehicles, after and including 2017MY, incorporate an anti-condensation logic to prevent the interior windows from becoming excessively fogged. The HVAC control head in these vehicles monitors ambient temperature to determine which settings will best prevent the windows from fogging. If the system detects lower ambient temperature (about 60°F or below), the anti-condensation logic may automatically set the air intake mode to FRESH, depending on the other HVAC settings. The anti-condensation logic is also designed to ensure that air intake mode is set to FRESH, as long as all conditions are met. If the user changes the air intake to RECIRCULATION, the anti-condensation logic will take control again after 5 minutes, and change the air intake mode back to FRESH. If this results in an undesired operation, the logic may be enabled or disabled by following the procedure below.
PS4942017-08-02. Service bulletin. ELECTRICAL SYSTEM:12V/24V/48V BATTERY. TSB: HIGH VOLTAGE (HV) BATTERY AND BATTERY MANAGEMENT SYSTEM (Bms) PART NUMBER CHANGE - This Pitstop provides information regarding a running change to the High Voltage (HV) Battery and Battery Management System (BMS) control unit assemblies on 2017MY Optima Hybrid (JF HEV only, does not apply to PHEV) vehicles.
PS4932017-08-02. Service bulletin. VISIBILITY; EQUIPMENT:APPLIANCE:AIR CONDITIONER. TSB: DEFOGGING LOGIC ? NORMAL OPERATION, DISABLING, AND ENABLING - Starting with 2010MY, all Kia vehicles, except Rio (JB), incorporate a defogging logic to prevent the interior windows from becoming excessively fogged. Depending on the specific model, the HVAC control head monitors ambient temperature and/or cabin humidity to determine which settings will best prevent the windows from fogging. If the system detects lower ambient temperature or higher cabin humidity, the defogging logic may automatically switch ON the A/C, and/or set the air intake mode to Fresh Air. If the user changes these settings, the defogging logic will take control again after 3 to 5 minutes, depending on the procedure in this publication.
PS4812017-08-02. Service bulletin. ENGINE; POWER TRAIN. PS481: DUAL CLUTCH TRANSMISSION (DCT) CHARACTERISTICS - All models with a 1.6L Turbo engine may come equipped with a 7-speed Dual Clutch Transmission (DCT), except the 2017MY~ Niro (DE) with a 1.6L Atkinson engine comes equipped with a 6-speed Dual Clutch Transmission (DCT). This automatic transmission is unlike the conventional automatic transmission found in the complete line up of Kia vehicles. The new DCT improves fuel efficiency and can also provide a sportier feel. Certain aspects of this technology may lead to customer concerns if they are unfamiliar with it. To help maximize owner satisfaction on this new technology, Kia would like all dealership sales and service personnel to be familiar with the characteristics of this new transmission.
PS497R12017-08-02. Service bulletin. VISIBILITY:REARVIEW MIRRORS/DEVICES; VISIBILITY. PIT STOP: UVO ESERVICES MIRROR BUTTONS (CUSTOMER GUIDE) - This pitstop provides information regarding the functionality of the UVO eServices buttons located on the rear view mirror in some 2016-2017MY K900 (KH), and 2017MY Optima Plug-in Hybrid (JF PHEV) and 2017MY Soul EV (PS EV) vehicles.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.