WenmarOpen by Wenmar Pro

Service bulletins for the 2021 Freightliner 114SD

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

153 on file from NHTSA, as of 2026-10-19.

By type

By component

Bulletins, newest first
ICI20-022R2020-08-29. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. Revised letter is to announce a reimbursement available to dealers for travel to a customer's location to perform a recall or field service campaign. Potential travel reimbursement applies to DTNA truck dealers and Detroit Diesel distributors. Thomas Built Buses will be addressed separately.
ICI20-0242020-08-08. Service bulletin. ELECTRICAL SYSTEM; EXTERIOR LIGHTING; EQUIPMENT. Important Campaign Information letter announcing that SF605 for LED Step Lighting has been suspended. It has been determined that a change in the procedure is necessary. A second Important Campaign Information letter will be posted when the changes have been made and the campaign is reactivated.
ICI20-0222020-08-05. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. Important Campaign Information letter announcing Dealer Travel for Campaign Performance. This letter is to announce a reimbursement available to dealers for travel to a customerâ™s location to perform a recall or field service campaign.
WI20-0142020-08-05. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance. In the spirit of continuous improvement, DTNA reviewed sublet-related policies and procedures. The goal was to improve language clarity and optimize processes.
WI20-0122020-08-03. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. Warranty Information Letter informing that to ensure that DTNA policies and service network practices align, the Warranty Department will be revising the Warranty Manual.
20TS-052020-07-31. Service bulletin. ENGINE AND ENGINE COOLING. Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility. Note: This document supersedes 14 TS-25 and 15 TS-8. Detroit Diesel has determined that some, Diesel Particulate Filters (DPFs) are compatible in pairs and or can be mixed together within EPA10 and GHG14 Systems. For 1-BOX and Two-Box Configuration Aftertreatment Systems (ATS), this is only possible when the filters are used in accordance with Tables 1 and 2 shown below. All other DPFs, NOT mentioned below, are NOT compatible.
20OEM-052020-07-31. Service bulletin. ENGINE AND ENGINE COOLING. OEM and distributor announcement for DiagnosticLink 8.12 (Build 4527) was made available. All DTNA Service shops & OEM locations are required to maintain the latest version of software on each of their stations.
20CSA-102020-07-31. Service bulletin. ENGINE AND ENGINE COOLING. Customer Service Announcement informing that Service Pack (SP) 1 for DiagnosticLinkî 8.12 Standard and Professional is available to download from the Detroit Diesel server.
TS10330142020-07-31. Service bulletin. EQUIPMENT; EQUIPMENT ADAPTIVE/MOBILITY; FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP; ENGINE AND ENGINE COOLING. Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines. Occasionally we see trucks come in with fuel leaking from the high pressure fuel pump weep hole. This is NOT a defect in the pump and further diagnostics need to be performed to find the root cause.
SB31-0432020-07-31. Service bulletin. EQUIPMENT; SUSPENSION:REAR. Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change. With the start of production on March 2, 2020, the fasteners used to assemble the non-Airliner rear suspension (bogie) crossmember have changed. The rear suspension bogie crossmember gussets to the C-channel will be assembled with 5/8 - 18 fasteners. This change includes a revision to a higher friction nut that requires an increase in tightening torque. The new higher friction nut can be identified by its green color.
20CSA-092020-07-28. Service bulletin. ENGINE AND ENGINE COOLING. Customer Service Announcement for DiagnosticLink Software Update Reminder. Due to various software changes and fixes, vehicles will require DiagnosticLink 8.12 to perform functional programming. Failure to use this version may cause errors, incomplete programming, and poor vehicle performance. Because of this, all DiagnosticLink 8.09 installed versions will be disabled as of Thursday, July 23, 2020.
SB60-1712020-07-28. Service bulletin. STRUCTURE:BODY:DOOR. Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces. The following guidelines are for cleaning and disinfecting commonly touched surfaces on the inside and outside of a vehicle. For best results, follow cleaning and disinfecting procedures fully and consistently. Ensure there is adequate ventilation when using chemicals. NOTICE: Wipe down fragile components carefully to avoid damaging the vehicle.
SB54-3342020-07-28. Service bulletin. EXTERIOR LIGHTING; ELECTRICAL SYSTEM. Service Bulletin for Front Lighting Ground Splice Pack Failure. The left and right hood lighting of these vehicles have separate ground paths to the frame and use the same splice pack parts. The splice packs are part of the hood commodity and located near the headlight assemblies. These splice packs can fail, resulting in either the left or right lighting becoming intermittent or inoperative.
SF6052020-07-02. Service bulletin. ELECTRICAL SYSTEM; EXTERIOR LIGHTING. Field Service Campaign for LED Step Lighting. The frontwall harness that controls the LED step lighting is wired incorrectly. The frontwall harness will be repinned.
SB54-3282020-07-02. Service bulletin. POWER TRAIN. Freightliner Service Bulletin for Rerouting Wiring Harness to Reduce Chafing. Allison transmission wiring harness chafing causes disruption to gear engagement and fault code generation. To reduce chafing, the wiring is routed using stand off brackets and tie straps to minimize contact with the transmission parts. This bulletin applies to vehicles equipped with on-board diagnostics (OBDs) manufactured after 2016.
20CSA-082020-06-26. Service bulletin. ENGINE AND ENGINE COOLING. Customer Service Announcement for Release of DiagnosticLink 8.12. On Wednesday, June 10, 2020, DiagnosticLink 8.12 will be made available for download from the ordering system. Current subscribers of DiagnosticLink 8.xx can upgrade to DiagnosticLink 8.12 at no cost. All DTNA service shops are required to maintain the latest version of software on each of their stations.
20TS-03REV2020-06-26. Service bulletin. ENGINE AND ENGINE COOLING. Revised Technical Service Letter for DD Heavy Duty Platform Belt Tensioner Change. A newly designed, dual-arm friction shoe damping tensioner was implemented for the DD Heavy Duty Platform.
D20M32020-06-26. Service bulletin. ENGINE AND ENGINE COOLING. Detroit Field Service campaign for DETROIT Export DD15 and DD13 Valve Lash Adjustment, Throttle Connector O-ring, and TC Air Line Spacer Installation.
WI20-0092020-06-13. Service bulletin. ENGINE AND ENGINE COOLING. Warranty Information Letter for a Warranty Service Replacement Engine Program Clarification. Detroit established the Warranty Service Replacement Engine Program to support an unrepairable catastrophic engine failure due to manufacturing defect. To improve understanding and utilization of the program, DTNA is clarifying eligibility and engine returns.
20TS-032020-05-23. Service bulletin. EQUIPMENT ADAPTIVE/MOBILITY. Technical Service Letter for DD Heavy Duty Platform Belt Tensioner Change. A newly designed, dual-arm friction shoe damping tensioner was implemented for the DD Heavy Duty Platform.
WI20-0082020-04-28. Service bulletin. EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL. Warranty Information Letter for Warranty Training Online. DTNA is pleased to announce the release of new Warranty-related training videos. The videos provide Warranty content in short instructional videos that are available on demand through the AftermarkeTV Video Channel icon on the Aftermarket Resource Center (ARC) home page.
WP20-0072020-04-23. Service bulletin. EQUIPMENT. Warranty Policy Letter for Chassis Progressive Damage Policy Change. Effective for repair orders opened on or after April 27, 2020, if an Authorized Service Location installed a part which later has a warrantable failure, progressive damage and labor may be covered under the Aftermarket Parts Limited Parts Warranty (Parts Warranty).
WP20-0062020-04-23. Service bulletin. EQUIPMENT. Warranty Policy Letter for Handling for Authorized Service Location Part Transfers. To promote 24-hour throughput and maximum efficiency, DTNA is adjusting multiple handling policies: Launching a new handling allowance for parts ordered from another Authorized Service Location because the facing Part Distribution Center (PDC) is out of stock Retiring Detroit's Customer First Program
WP20-0052020-04-23. Service bulletin. EQUIPMENT. Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program. DTNA is pleased to announce that handling will increase to 33% for Misc. Replacement Part type claims filed under the Over the Counter (OTC) Aftermarket Parts Replacement Program.
WI20-0042020-04-23. Service bulletin. EQUIPMENT; ENGINE AND ENGINE COOLING. Warranty Information Letter for Warranty Long Block Program Change. The Detroit Reman Long Block Program has expanded. The expansion reduces complexity in ordering reman engines and promotes stocking reman engines to meet uptime commitments.

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.