WenmarOpen by Wenmar Pro

Service bulletins for the 1995 Ford Explorer

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

191 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

By topic

Bulletins, newest first
962211997-06-17. Service bulletin. VISIBILITY:WINDSHIELD. WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
9624171997-06-17. Service bulletin. POWER TRAIN:DRIVELINE. NOISE - PINGING OR CREAKING FROM DRIVELINE WHEN VEHICLE IS PUT INTO GEAR. *TW
962491997-06-17. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER. TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
962461997-06-17. Service bulletin. ELECTRICAL SYSTEM:WIRING. WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
BC52319611011997-06-17. Service bulletin. SUSPENSION:FRONT. VEHICLE LEAN. *TW
BC05339611081997-06-17. Service bulletin. SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE. INSTRUCTIONS FOR DIAGNOSING FAULTY ABS SENSORS. *TW
BC03429611271997-06-17. Service bulletin. ELECTRICAL SYSTEM:WIRING. WHEN A REAR HEGO (CMS) CONCERN IS NOTED, PLEASE CHECK THE REAR CMS HEGO FOR WIRE CHAFING/DAMAGE AND LOOSE HEGO WIRE. *TW
BC03249611011997-06-17. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. COLD ENGINE KNOCK/TICK NOISE. *TW
BC03179611011997-06-17. Service bulletin. SUSPENSION:FRONT. FRONT AXLE FLUID LEAK FROM VENT TUBE. *TW
BC52259610011997-04-24. Service bulletin. POWER TRAIN:DRIVELINE:DRIVESHAFT. VEHICLES MAY EXPERIENCE A VIBRATION DURING WIDE OPEN THROTTLE ACCELERATION OR WHILE CRUISING AT HIGHWAY SPEEDS. REVISED FRONT DRIVESHAFT. *TT
BC08819610041997-04-24. Service bulletin. SUSPENSION:REAR:SPRINGS:COIL SPRINGS. THUMP/CLUNK NOISE IN TURNS OR OVER BUMPS MAY BE CAUSED BY THE KEVLAR PATCH WEARING THROUGH ON THE TORSION BAR ADJUSTERS. *TT
BC07419610181997-04-24. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. FOR STALLING CONCERNS, REFLASH THE PCM W/ 96 CALIBRATION (R11 LEVEL). *TT
BC07409610181997-04-24. Service bulletin. ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH. VEHICLES EXPERIENCE CHAFFING ON THE 14401 WIRE HARNESS CAUSING THE ACCESSORY FUSES TO BECOME OPEN (PRIMARILY THE CIGAR FUSE. *TT
BC06789610251997-04-24. Service bulletin. POWER TRAIN:MANUAL TRANSMISSION. INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT. *TT
952121996-04-25. Service bulletin. SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP. THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. IF PETROLEUM-BASED GREASE IS USED TO LUBRICATE ANY PART OF THE DISC BRAKE SYSTEM, IT COULD CAUSE RUBBER PARTS TO SWELL IF LUBRICANT CONTACTS THE RUBBER MATERIAL.
9519121996-04-25. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. ON TRANSMISSIONS BUILT BEFORE 6/20/95 (FIG 1) AN EXTENDED SHIFT AND A HIGHER ENGINE RPM THAN EXPECTED AND/OR NO SHIFT CONDITION, POSSIBLY ALONG WITH A FLASHING 'O/D OFF' LAMP AND/OR THE DIAGNOSTIC TROUBLE CODES (DTCS) LISTED ABOVE, MAY OCCUR. THIS MAY BE CAUSED BY A DAMAGED INTERMEDIATE AND/OR OVERDRIVE SERVO SEAL.
951611996-04-25. Service bulletin. STRUCTURE:BODY. SHEET METAL-ROOF PANEL AND DRIP RAIL REPLACEMENT- SEAM SEALER APPLICATION PROCEDURE.*SD
BC43809509061996-04-25. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. AVAILABILITY OF HIGH ALTITUDE TRANSMISSION. *TW
SFA/94L051995-11-01. Service bulletin. STEERING: STEERING WHEEL/HANDLE BAR; EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM; STEERING:LINKAGES; POWER TRAIN:AUTOMATIC TRANSMISSION; ELECTRICAL SYSTEM:IGNITION:MODULE; VEHICLE SPEED CONTROL; UNKNOWN OR OTHER. UNKNOWN
9510111995-11-01. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE. MUFFLER OUTLET ASSEMBLY MAY HAVE THE SAME RESONANT FREQUENCY AS THE SPARK PLUG FIRING FREQUENCY, CAUSING VIBRATION IN THE SEAT AND/OR STEERING WHEEL. *TW
951091995-11-01. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE. EXHUAST LEAK OR TICKING NOISE WHILE ACCELERATING. *TW
957211995-11-01. Service bulletin. STEERING:LINKAGES; SEATS:FRONT ASSEMBLY:RECLINER. INSTRUCTIONS FOR COMPLETION OF RECALL 95S08. *TW
957201995-11-01. Service bulletin. ELECTRICAL SYSTEM:IGNITION:MODULE. SOME VEHICLES MAY HAVE A KNOCK NOISE FROM THE ENGINE ON HEAVY ACCELERATION. *TW
BC27149505031995-11-01. Service bulletin. STEERING:GEAR BOX (OTHER THAN RACK AND PINION). PRECAUTIONARY INSTRUCTIONS WHEN PERFORMING RECALL 95S08. *TW
BC27019505031995-11-01. Service bulletin. STEERING: STEERING WHEEL/HANDLE BAR. LIGHT CLICKING SENSATION OR LOOSENESS AS THE STEERING WHEEL IS TURNED. *TW

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.