WenmarOpen by Wenmar Pro

Service bulletins for the 2000 Ford Excursion

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

217 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Bulletins, newest first
143562001-08-07. Service bulletin. SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS. SOME SUPER DUTY F SERIES VEHICLES MAY EXHIBIT A BRAKE SQUEAL / SQUEAK FROM THE REAR BRAKES. *TT
143502001-08-07. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM. INFORMATION ON VEHICLES EXHIBITING A WATER PUMP SHAFT SEAL LEAK. *TT
142442001-08-07. Service bulletin. SUSPENSION. SOME 4X4 VEHICLES MAY EXHIBIT A POP / CLUNK NOISE DURING TURNS, TURNING ONTO UNEVEN SURFACES OR WHEN DRIVING OVER BUMPS. ENGINEERING HAS DETERMINED THAT THIS MAY BE CAUSED BY AN UNDER TORQUED UPPER FRONT SWAY BAR BOLT WHICH ATTACHES THE UPPER SWAY BAR ENDLINK THROUGH THE ENDLINK FRAME BRACKET TO THE FRAME. *TT
141842001-08-07. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. SOME VEHICLES EQUIPPED WITH 7.3L DIT ENGINE MAY EXHIBIT AN ENGINE THAT RUNS ROUGH, MISSES, BUCK / JERK, HESITATE / STUMBLE, SURGE, LACKS POWER, VARIOUS IDLE SYMPTOMS, MALFUNCTION INDICATOR LAMP ON. *TT
141602001-07-24. Service bulletin. UNKNOWN OR OTHER. A CONDITION MAY EXIST WHERE THE MALFUNCTION INDICATOR LAMP IS ON WITH DIAGNOSTIC TROUBLE CODE P0340 (CAMSHAFT POSITION (CMP) SENSOR A CIRCUIT) STORED, ACCOMPANIED WITH A DRIVEABILITY CONCERN. *TT
140322001-07-24. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER; FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM. SOME VEHICLES WITH 7.3L DIT ENGINES MAY EXHIBIT LOOSE TURBO BOLTS ON THE TURBO HOUSING. TYPICAL SYMPTOMS OF LOOSE BOLTS INCLUDE LACK OF POWER AND AN OIL LEAK. *TT
139932001-07-24. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT. SUBJECT REGARDING DIAGNOSTICS AND / OR MECHANICAL CONCERNS REGARDING THE NEW VENUTURE TRANSFER CASE. *TT
149072001-07-20. Service bulletin. UNKNOWN OR OTHER. CONCERNS WITH VEHICLES EXHIBITING THE OIL PRESSURE GAUGE REGISTERING LOW OR NO OIL PRESSURE USUALLY ON INITIAL START-UP AFTER SEVERAL HOURS OF COLD SOAK. *TT
01952001-07-19. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. A CONDITION MAY EXIST WITH LACK OF POWER UNDER A LOAD, AT CRUISE OR ON ACCELERATION MAY OCCUR ON SOME VEHICLES BUILT BEFORE 11/25/2000 EQUIPPED WITH THE 7.3L DIT ENGINE. THIS MAY BE CAUSED BY A COLLAPSED AIR FILTER ELEMENT OR DEFECTIVE AIR BOX / LID. *TT
147532001-06-01. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER. SOME VEHICLES EQUIPPED WITH A 7.3L DIT ENGINE MAY EXHIBIT LOOSE TURBO BOLTS ON THE TURBO HOUSING. *TT
147432001-06-01. Service bulletin. POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL. INFORMATION ON REAR AXLE PINION SEAL PART USAGE. *TT
01492001-05-30. Service bulletin. SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS. FRONT BRAKE PAD OR CALIPER RATTLE WHEN GOING OVER BUMPS. *TT
01472001-05-30. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. SUBJECT REGARDING ENGINE OIL RECOMMENDATIONS FOR USE IN 2001 VEHICLES - SAE 5W-20 MOTOR OIL. *TT
01442001-05-30. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. FUEL QUALITY AND MOISTURE IN CERTAIN DIESEL FUELS MAY CAUSE SOME VEHICLES TO EXHIBIT A NO START, GRADUAL LOSS OF POWER, OR A ROUGH IDLE CONDITION DUE TO FUEL GELLING DURING EXTREME COLD WEATHER OPERATION. *TT
148402001-05-23. Service bulletin. SUSPENSION:FRONT:WHEEL BEARING. A SLIGHT PURGE OF GREASE FROM THE FRONT HUB BEARING UNIT THAT MAY BE NOTED BETWEEN THE HUB UNIT AND THE INBOARD ROTOR FLANGE. *TT
01622001-05-22. Service bulletin. ELECTRICAL SYSTEM:IGNITION:ANTI-THEFT:CONTROL MODULE. VEHICLES EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) MAY NOT START OR CRANK. *TT
146582001-05-17. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. SOME VEHICLES EQUIPPED WITH 4R100 TRANSMISSION AND 7.3L ENGINE OR WITH 4R100 6.8L MAY EXHIBIT ENGINE STALL AFTER TRANSMISSION ENGAGEMENT INTO REVERSE AND A TIP IN BACKOUT OF THE THROTTLE. *TT
146522001-05-17. Service bulletin. STEERING:HYDRAULIC POWER ASSIST SYSTEM. SOME VEHICLES MAY EXHIBIT HIGHER THAN NORMAL STEERING EFFORTS WHEN THE VEHICLES IS AT A VERY LOW SPEED OR STOPPED WITH THE BRAKES APPLIED. *TT
01322001-05-16. Service bulletin. SUSPENSION. SOME VEHICLES MAY EXHIBIT STIFF STEERING, WANDERING, OR POOR RETURNABILITY AFTER TURNS. *TT
01252001-05-16. Service bulletin. SEAT BELTS:FRONT:WARNING LIGHT/DEVICES. SEAT BELT WARNING SYSTEM - BELT REMINDER FUNCTION, OPERATION AND SERVICE TIPS. *TT
143652001-04-18. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS. THIS BULLETIN ADDRESSES CONCERNS A NOISE AT INTIAL ENGINE STARTUP WHEN COLD FROM THE ACCESSORY DRIVE BELT. *JB
143562001-04-18. Service bulletin. SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS. CONCERNS WITH REAR BRAKE NOISE. *JB
143502001-04-18. Service bulletin. POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT:SEAL. VEHICLES MAY EXPERIENCE FRONT SHAFT SEAL LEAKAGE. *JB
143492001-04-18. Service bulletin. SUSPENSION:REAR. A CLUNK / POPPING NOISE FROM FRONT SWAY BAR AREA. *JB
143482001-04-18. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER. CONCERNS WITH A TURBO HOOT CONDITION. *JB

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.