WenmarOpen by Wenmar Pro

Service bulletins for the 2007 Ford E-450

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

23 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Bulletins, newest first
SSM 519092023-10-04. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30-Jun-2023, MERCON SP ATF will no longer be manufactured and will only be available until inventory depletes.
DOR-T7F8K-082020-08-24. Service bulletin. ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL; TRAILER HITCHES; ELECTRICAL SYSTEM:SOFTWARE. These SKUs are Trailer Brake Control Modules. The customer communication requested return of unsold inventory due to an internal software issue. The internal software issue leads to a false check trailer brake message and Trailer Brake Controller fault whenever the brake pedal is pressed. This will cause the part to be replaced, due to repetitive dashboard warning light, even though it sends signals to the trailer brakes properly.
TSB T2007-022017-03-27. Service bulletin. ELECTRICAL SYSTEM:IGNITION:MODULE. ON SOME VEHICLES, WHEN THE GATEWAY 401 MODULE TRANSITIONS FROM ITS POWER DOWN MODE (IGNITION OFF) TO ITS POWER UP MODE (IGNITION ON) THE MODULE MAY NOT WAKE UP. IF THIS ACTION OCCURS, THE MODULE'S LED DISPLAY PANELS WILL NOT PROVE-OUT AND THE BACKLIGHTS ON THE LED DISPLAY PANELS WILL NOT ILLUMINATE.
ASI-445342014-10-01. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. FORD: WHEN SHIFTING BETWEEN PARK, REVERSE AND/OR DURING 2-3 SHIFT, AN INTERMITTENT CLUNK OCCURS WITH A TORQSHIFT TRANSMISSION. MODEL 2003-2014 F-SUPER DUTY, E SERIES, EXCURSION, F-53 MOTORHOME CHASSIS, LOW CAB FORWARD. *PE
ASI-444042014-06-24. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:DIESEL; POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER. FORD: ON SOME TRUCKS, THERE IS A NO CRANK SITUATION AND IF VOLTAGE ON TRANSMISSION RANGE SENSOR AT PIN 21, IS LESS THAN 5 VOLTS, DISCONNECT THE ENGINE COOLING FAN CLUTCH, ELECTRONICALLY, AND RECHECK VOLTAGE. MODEL 2003-2007 F SUPER DUTY, 2004-2010 E SERIES, 2003-2005 EXCURSION.
TSB-10-23-52011-07-11. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. FORD: THERE MAY BE A LACK OF RPM, HESITATION, OR ROUGH RUNNING CONCERNS WHEN THE VEHICLE IS IN IDLE. THERE MAY BE TWO TROUBLE CODES STORED. THE PROBLEM MAY BE CAUSED BY AFTERMARKET GENERATORS INSTALLED OR MODIFICATIONS TO THE FRONT END DRIVE. E-350/450. *RM
AS-217692011-07-07. Service bulletin. ELECTRICAL SYSTEM:SOFTWARE; ENGINE AND ENGINE COOLING:ENGINE; SERVICE BRAKES, AIR:ANTILOCK; POWER TRAIN. FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM
TSB-10-12-62010-12-07. Service bulletin. FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:INJECTORS. FORD: RUNS ROUGH, LACKS POWER, HARD START, NO START. SOME VEHICLES AND TRUCKS EQUIPPED WITH 6.0L ENGINE MAY EXHIBIT A RUNS ROUGH, LACKS POWER, HARD TO START, NO START CONCERN WITH OR WITHOUT DIAGNOSTIC TROUBLE CODE (DTC) P0611 CODE OR VARIOUS INJECTOR CIRCUIT CODES. *PE
TSB-08-26-32009-06-01. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:DIESEL; FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM. FORD: SOME VEHICLES WITH DIESEL ENGINES MAY EXPERIENCE NO STARTS, HARD STARTS OR ROUGH RUNNING WHEN COLD AND MAY BE ACCOMPANIED WITH DIAGNOSTIC TROUBLE CODES (DTCS) P0611, P1378 AND/OR ALL 8 INJECTOR CIRCUIT CODES. *PE
TSB-08-16-132009-05-20. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER; ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER. FORD: SOME VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINE MAY EXHIBIT ANY ONE OR COMBINATION OF THE FOLLOWING CONCERNS-LACK OF POWER, WHITE/BLACK SMOKE OR A SURGE. *PE
TSB-08-20-12009-03-21. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE; ENGINE AND ENGINE COOLING:ENGINE:DIESEL; ENGINE AND ENGINE COOLING:ENGINE. FORD TRUCKS: MISFIRE, LACK OF POWER, BUCK/JERK, EXCESSIVE SMOKE, CRANK/NO START-DIAGNOSTICS FOR FUEL SYSTEM. THERE ARE SEVERAL POTENTIAL CAUSES FOR THESE SYMPTOMS. *PE
TSB-08-18-62009-02-25. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:DIESEL. FORD TRUCK: SOME TRUCKS EQUIPPED WITH A 6.0L DIESEL ENGINE MAY EXHIBIT A HARD START/LONG CRANK OR NO START CONDITION DUE TO LOW INJECTION CONTROL PRESSURE (ICP). *PE
08-2-112008-04-04. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER. 6.0L TURBOCHARGER CARBON DEPOSIT DIAGNOSTICS AND SERVICE TIPS. *NJ UPDATED 5/29/08. *NJ
072192008-02-07. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE). 6.0L--MIL ON--P0401, P0402, P0404, P1335--LACK OF POWER OR SURGE WITH SOME 2003-2007 F-SUPER DUTY, 2003-2005 EXCURSION AND 2004-2008 E-SERIES VEHICLES. *NJ
198452007-09-26. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM). CRANK/NO START/ NO PCM COMMUNICATION AND POSSIBLY P1336 AND OTHER CODES. *NJ
07032007-09-25. Service bulletin. EQUIPMENT:OTHER:LABELS. CERTAIN 2007 E-SERIES STRIP CHASSIS VEHICLE EMISSION CONTROL INFORMATION (VECI) LABEL REPLACEMENT. *NJ
0711102007-09-19. Service bulletin. SERVICE BRAKES, AIR. BRAKE BOOSTER SYSTEM MAY EXHIBIT A BRAKE PEDAL KICKBACK AND/OR GRABBING CONDITION WHEN APPLYING THE BRAKES. *NJ
197282007-07-23. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:DIESEL. LACK OF POWER DUE TO LOW FUEL PRESSURE - FUEL TANK LINER SEPERATION. *KB
195272007-07-23. Service bulletin. EXTERIOR LIGHTING:HEADLIGHTS. HEADLIGHT ADJUSTMENT NEEDED. *KB
196212007-06-12. Service bulletin. FUEL SYSTEM, GASOLINE. LACK OF POWER DUE TO LOW FUEL PRESSURE, FUEL TANK LINER SEPERATION. *KB
07542007-04-27. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. COLD START DRIVEABILITY - WHITE SMOKE, LACKS POWER, EXHAUST ODOR, SURGES, RUNS, ROUGH, OR NO START. *KB
07142007-03-23. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN. LACK OF COOLING FAN OPERATION. *KB
062292007-03-23. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. 6.0L - MIL ON WITH DTC P2138, P2139, AND P2140. *KB

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.