WenmarOpen by Wenmar Pro

Service bulletins for the 1994 Ford Aerostar

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

75 on file from NHTSA, as of 2026-10-19.

By type

By component

Bulletins, newest first
9626121997-06-17. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER. TRANSAXLE - TORQUE CONVERTER REPLACEMENT GUIDELINES AND TORQUE CONVERTER/TRANSAXLE COOLING SYSTEM CLEANING PROCEDURES - SERVICE TIP. *TW
962261997-06-17. Service bulletin. EQUIPMENT:APPLIANCE:AIR CONDITIONER. AIR CONDITIONING - COMPRESSOR FAILURE - INSUFFICIENT AMOUNT OF REFRIGERANT OIL. *TW
962251997-06-17. Service bulletin. FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM. MASS AIR FLOW SENSOR - REPLACEMENT AS AN ASSEMBLY - SERVICE TIP. *TW
962221997-06-17. Service bulletin. SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS. BRAKES - ELIMINATION OF SANDING ROTORS AND DRUMS - SERVICE TIP. *TW
962211997-06-17. Service bulletin. VISIBILITY:WINDSHIELD. WINDSHIELD AND INTERIOR GLASS - FOG/FILM. *TW
962491997-06-17. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION:TORQUE CONVERTER. TORQUE CONVERTER - LEAK TEST PROCEDURE - SERVICE TIP. *TW
962461997-06-17. Service bulletin. ELECTRICAL SYSTEM:WIRING. WIRING - ELECTRICAL DIODE IDENTIFICATION AND SERVICE REPLACEMENTS. *TW
BC08229610101997-04-24. Service bulletin. STRUCTURE:BODY:HATCHBACK/LIFTGATE:SUPPORT DEVICE/STRUT. CONCERNS W/ LIFTGATE OPENING EFFORTS &/OR THE LIFTGATE NOT STAYING OPEN, ESPECIALLY IN COLD AMBIENT TEMPS. *TT
BC06789610251997-04-24. Service bulletin. POWER TRAIN:MANUAL TRANSMISSION. INFORMATION ON AODE/4R7W TRANSMISSION MAIN CONTROL & CASE REPLACEMENT. *TT
952171996-04-25. Service bulletin. STRUCTURE:BODY. A WINDNOISE MAY BE HEARD AT THE A-PILLAR IN SOME VEHICLES. THIS MAY BE CAUSED BY INCOMPLETE SEALING AT THE A-PILLAR. INSTALL A FOAM SEALANT INTO THE LOWER SECTION OF THE A-PILLAR TO SEAL AN AIR LEAK IN THE A-PILLAR.
952121996-04-25. Service bulletin. SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP. THE USE OF PETROLEUM-BASED GREASE AS A LUBRICANT IN SERVICING DISC BRAKES IS NO LONGER ACCEPTABLE BECAUSE IT MAY BE INCOMPATIBLE WITH THE RUBBER MATERIAL USED IN THE DISC BRAKE SYSTEM. IF PETROLEUM-BASED GREASE IS USED TO LUBRICATE ANY PART OF THE DISC BRAKE SYSTEM, IT COULD CAUSE RUBBER PARTS TO SWELL IF LUBRICANT CONTACTS THE RUBBER MATERIAL.
BC13509509061996-04-25. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. HIGH ALTITUDE TRANSMISSION AVAILABLE. *TW
BC13839509061996-04-25. Service bulletin. STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS. VEHICLE MAY EXHIBIT A MOAN WHEN TURNING - TO CORRECT THIS CONDITION, REPLACE THE HIGH PRESSURE HOSE WITH A TUNED HOSE. *TW
95661995-11-01. Service bulletin. VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR. UNKNOWN
9510121995-11-01. Service bulletin. POWER TRAIN:AUTOMATIC TRANSMISSION. TRANSFER CASE MAY LEAK FLUID FROM THE CASE VENT TUBE. *TW
951021995-11-01. Service bulletin. ELECTRICAL SYSTEM:IGNITION. VEHICLES MAY HAVE A DISCONNECT OF THE IGNITION CONTROL MODULE (ICM) CONNECTOR OR MOISTURE BUILDUP WITHIN THE CONNECTOR. *TW
959101995-11-01. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. UNKNOWN
95921995-11-01. Service bulletin. VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR. UNKNOWN
957151995-11-01. Service bulletin. ELECTRICAL SYSTEM:IGNITION:MODULE. MIL LAMP MAY TURN ON OR FLASH INTERMITTENTLY MAY BE DUE TO THE POWERTRAIN CONTROL MODULE (PCM) INCORRECTLY CALCULATING THE VEHICLE ENGINE LOAD DURING LIGHT THROTTLE. *TW
95661995-11-01. Service bulletin. VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR. CHIRP OR SQUEAK NOISE FROM BLOWER MOTOR AT LOW SPEEDS. *TW
955111995-11-01. Service bulletin. VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:FAN/MOTOR. CHIRP OR SQUEAK FROM BLOWER MOTOR. *TW
953201995-03-31. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. KNOCKING NOISE FROM LOWER FRONT OF ENGINE COMPARTMENT. *TW
95241995-03-17. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY. NEW RADIATOR MANUFACTURING PROCESS/MODIFICATION. *TW
942561995-02-07. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. KNOCKING NOISE FROM LOWER END #1 MAIN BEARING DURING ACCELERATION. *TW
942491995-01-06. Service bulletin. VISIBILITY:POWER WINDOW DEVICES AND CONTROLS. FRONT DOOR GLASS TIPPING AND BINDING DURING DOWNWARD TRAVEL. *TW

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.