WenmarOpen by Wenmar Pro

Service bulletins for the 1996 Chevrolet Cavalier

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

84 on file from NHTSA, as of 2026-10-19.

By type

By component

By trouble code

Bulletins, newest first
6771601997-08-21. Service bulletin. POWER TRAIN:CLUTCH ASSEMBLY. DELAY ENGAGEMENT INTO DRIVE AFTER COLD SOAK (REPLACE WITH REVISED FORWARD CLUTCH HOUSING ASSEMBLY COMPLETE). *TW
6311061997-08-21. Service bulletin. VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM. AIR LEAKING FROM I/P VENTS IN HEATER OR DEFROST MODES (REPLACE MODE VALVE VACUUM ACTUATOR; ADD CLIP TO HVAC MODULE CASE). *AK
7334031997-07-24. Service bulletin. SUSPENSION:REAR:SHOCK ABSORBER. REAR SHOCK NOISE IN TRUNK AREA - SOUNDS LIKE LOOSE LUMBER. *TW
7760011997-06-27. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. KNOCK, RATTLE OR TAP NOISE FROM THE ENGINE BEFORE THE ENGINE HAS REACHED OPERATING TEMPERATURE OR UNDER LIGHT LOAD CONDITIONS AT OPERATING TEMPERATURE KNOCK, RATTLE OR TAP NOISE FROM THE ENGINE BEFORE THE ENGINE HAS REACHED OPERATING TEMPERATURE OR UNDER LIGHT LOAD CONDITIONS AT RATURE (REPLACE PISTON AND/OR ROD ASSEMBLIES). *TW
7316011997-06-27. Service bulletin. SEATS:FRONT ASSEMBLY:RECLINER. RATTLE/SQUEAK FROM PASSENGER (RIGHT) SIDE OF REAR FOLDING SEATBACK AREA (REPOSITION RIGHT HAND FRAME ARM). *TW
6372051997-06-27. Service bulletin. POWER TRAIN:DRIVELINE:DRIVESHAFT. LEAK IN THE AXLE SEAL AREA (SHORTEN VENT HOSE). *TW
6381391997-06-27. Service bulletin. INTERIOR LIGHTING. INTERIOR DOME LIGHT STAYS ON ALL THE TIME (REROUTE WIRE HARNESS). *TW
6765281997-05-27. Service bulletin. ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR; ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL. INTERMITTENT DIAGNOSTIC TROUBLE CODE P0107 MAP SENSOR CIRCUIT LOW VOLTAGE (PCM FLASH CALIBRATION) *TW
6762041997-05-27. Service bulletin. ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY. COOLANT LOSS, VISIBLE COOLANT LEAKAGE, LOW COOLANT LAMP ON OR COOLANT ODOR CAUSED BY COOLANT LEAKAGE. *TW

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.