WenmarOpen by Wenmar Pro

Service bulletins for the 2000 BMW 325Ci

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

49 on file from NHTSA, as of 2026-10-19.

By type

By component

Bulletins, newest first
SIB-41-02-092010-07-14. Service bulletin. STRUCTURE; STRUCTURE:BODY; SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY. BMW VEHICLES: REAR AXLE CARRIER (SUB FRAME) SUPPORT PROPOSED CLASS ACTION SETTLEMENT. UNDER CERTAIN CIRCUMSTANCES, A FRACTURE IN THE STEEL BODY STRUCTURE COULD FORM IN THE AREA AROUND ONE OF THE REAR AXLE CARRIER MOUNTING POINTS. AS A RESULT, A DISTINCT CLICKING NOISE CAN BE HEARD FROM THE AREA OF THE REAR AXLE CARRIER DURING CERTAIN DRIVING CONDITIONS. MODEL E46 (3SERIES). NO MODEL YEARS LISTED. *PE
SIB-16-08-062010-07-14. Service bulletin. FUEL SYSTEM, OTHER:STORAGE:FUEL GAUGE SYSTEM. BMW VEHICLES: ENGINE CRANKS BUT DOES NOT START; FUEL LEVEL GAUGE DISPLAYS A SUFFICIENT AMOUNT OF FUEL, ALTHOUGH THE FUEL TANK IS EMPTY; FAULT CODE 2A1C (FUEL LEVEL PLAUSIBILITY) IS STORED IN MSV80. RIGHT SIDE FUEL SENDING UNIT IS DISLODGED FROM ITS BRACKET DUE TO INCORRECT ASSEMBLY. NO MODEL YEARS LISTED. *PE UPDATED 4/29/11. *PE
SIB-16-02-092010-07-14. Service bulletin. FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP. BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS WELL. IN SOME CASES, EPC DOES NOT SHOW THAT THE REPAIR KIT IS AVAILABLE SEPARATELY IN THE ILLUSTRATION, BUT IT IS AVAILABLE IN THE PARTS DESCRIPTION. ALL MODELS. NO MODEL YEARS LISTED. *PE
SIB-16-01-062010-06-21. Service bulletin. FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP; FUEL SYSTEM, OTHER; FUEL SYSTEM, OTHER:DELIVERY:FUEL PUMP. BMW: FUEL LEVEL SENSOR REPAIR PROCEDURE. THE CASE WHERE IT IS NECESSARY TO REPLACE THE RIGHT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING DOES NOT NEED TO BE REPLACED. NO MODEL YEARS LISTED. *PE
SIB-34-078-072010-05-28. Service bulletin. POWER TRAIN:MANUAL TRANSMISSION. BMW VEHICLES: DSC DISABLING FUNCTION. DSC OFF FUNCTION HAS BEEN IMPLEMENTED IN M5 AND M6 VEHICLES EQUIPPED WITH THE OPTIONAL 6 SPEED MANUAL TRANSMISSIONS. NO MODEL YEARS LISTED. *PE
SIB-22-01-072010-05-27. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE; STEERING:GEAR BOX (OTHER THAN RACK AND PINION); EQUIPMENT ADAPTIVE/MOBILITY. BMW VEHICLE: NOISE FROM FRONT AXLE/RIGHT SIDE. A GRINDING OR SCRAPING NOISE MAY BE HEARD WHILE CORNERING AT VEHICLE SPEEDS UP TO 30 MPH. THE NOISE IS MORE PRONOUNCED WHILE THE VEHICLE IS IN THE WARM UP PHASE AND MAY CHANGE INTENSITY DURING LEFT AND RIGHT TURNS. THE RIGHT SIDE ENGINE SUPPORT IS MAKING CONTACT WITH THE RIGHT SIDE ENGINE MOUNT. *PE
SIB-12-24-072010-05-26. Service bulletin. ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR; FUEL SYSTEM, GASOLINE; FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY. BMW VEHICLE: S54-CATALYST PROTECTION MODE WHILE THE VEHICLE IS LOW ON FUEL. COMPLAINTS THAT THE VEHICLE HAS NO POWER DURING HEAVY ACCELERATION. FUEL RESERVE LIGHT IS ILLUMINATED AND THE FUEL LEVEL, WHEN MEASURED WITH THE SERVICE TESTER, IS BELOW 10 LITERS. WITH THE FUEL LEVEL LOW AND UNDER EXTREME DRIVING CONDITIONS (HEAVY ACCELERATION, CORNERING OR RACING), THE FUEL SUPPLY MAY BE INADEQUATE, CAUSING AN INTERMITTENT LEAN MIXTURE TO BE RECORDED BY ALL 4 OXYGEN SENSORS. *PE
SIB-12-20-072010-05-26. Service bulletin. FUEL SYSTEM, OTHER:FUEL FILTER; ENGINE AND ENGINE COOLING:ENGINE. BMW VEHICLE: M54/M56-MIXTURE TOO LEAN-FAULT CODES 2882/2883 ARE STORED IN THE DME. COMPLAINTS THAT SERVICE ENGINE SOON LIGHT IS ILLUMINATED. THE FAULT CODES 2882/2883-FUEL TRIM, MIXTURE TOO LEAN ARE STORED IN THE DME. POSSIBLE CAUSES MAY INCLUDE-INCORRECT AIR FILTER, UNMETERED AIR OR A DEFECTIVE AIR MASS METER. *PE
SIB-11-14-072010-05-26. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER; ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER. BMW VEHICLE: N54 TURBOCHARGER WASTE GATE CONTROL NOISES AND OPERATION. AFTER TURNING OFF ENGINE, A SLIGHT RATTLE NOISE IS HEARD FROM THE ENGINE COMPARTMENT. THIS NOISE IS SIMILAR TO A MECHANICAL TYPEWRITER. IN ADDITION, THE COMPLAINTS OF A SLIGHT REDUCTION OF POWER SIMILAR TO AN INCREASED TURBO LAG. THE VACUUM SUPPLY TO THE WASTE GATES MAY BE RESTRICTED OR BLOCKED. NO MODEL YEARS LISTED. *PE
SIB-11-02-082010-05-21. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE; ENGINE AND ENGINE COOLING:ENGINE:DIESEL. BMW VEHICLE: THE SERVICE ENGINE SOON (MIL) LAMP IS ILLUMINATED AND A POWER REDUCTION IS CLEARLY PERCEPTIBLE. THIS SITUATION MAY OCCUR AFTER DRIVING FOR SOME TIME WITH THE ENGINE ALREADY AT FULL OPERATING TEMPERATURE. IF THE IGNITION IS CYCLED, THE ENGINE THEN USUALLY PERFORMS NORMALLY. *PE UPDATED 2/7/11. *PE UPDATED ON 06/09/2011. *KB UPDATED 8/10/11. *PE UPDATED 1/11/13. *PE
SIB-12-07-062010-04-23. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE:DIESEL; ENGINE AND ENGINE COOLING:ENGINE; ELECTRICAL SYSTEM:SOFTWARE. BMW: SERVICE ENGINE SOON LAMP ILLUMINATED-FC 23F4 MAP THERMOSTAT. IN SOME VEHICLES HAVE INSUFFICIENT HEAT. E90, E91 (3 SERIES), E60, E61 (5 SERIES) 3/06 AND E83 (X3 SERIES) 9/08. *PE
SI-B-34-11-082009-12-09. Service bulletin. SERVICE BRAKES, HYDRAULIC; SERVICE BRAKES, AIR. BMW VEHICLES: TEILECLEARING FOR DYNAMIC STABILITY CONTROL (DSC). A PART REPLACEMENT AUTHORIZATION MUST BE OBTAINED BY SUBMITTING A TC CASE IN PUMA BEFORE ANY OF THE FOLLOWING DSC COMPONENTS ARE REPLACED UNDER WARRANTY FOR THE VEHICLES LISTED IN THE MODEL SECTION OF THIS BULLETIN: DSC CONTROL MODULE, DSC HYDRO UNIT, AND YAW RATE SENSOR. NO MODEL YEARS LISTED. *PE
SIB-51-19-072009-10-31. Service bulletin. ELECTRICAL SYSTEM; LATCHES/LOCKS/LINKAGES:DOORS:LATCH; STRUCTURE:BODY:DOOR. BMW VEHICLES: DOORS WILL NOT UNLOCK USING THE KEY FOB OR CENTRAL LOCKING BUTTON. *PE UPDATED1/4/10. *PE UPDATED 5/24/10. *PE
SIB-65-75-062009-07-13. Service bulletin. AIR BAGS. BMW SERVICE CAMPAIGN: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. THE AIRBAG WARNING LAMP (AWL) IS ILLUMINATED, TOGETHER WITH THE PASSENGER AIRBAG STATUS LAMP (POL). THE PROBLEM MAY BE INTERMITTENT. MICROCRACKS IN THE OC3 SEAT MAT. *PE UPDATED 9/30/11. *PE
SIB-12-12-082009-05-06. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE; ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSES/LINES/PIPING/FITTINGS. BMW: SERVICE ENGINE LAMP IS ILLUMINATED. DME FC 2A15 MINOR LEAK AND 2A16 SUPERFINE LEAK IN EVAPORATION SYSTEM. TANK VENTILATION CORRUGATED HOSE MAY CONTACT THE LOW SIDE AIR CONDITIONING PRESSURE LINE ALUMINUM FERREL. THIS CONTACT MAY CAUSE A SMALL LEAK. *PE
SI B63-04-082008-09-22. Service bulletin. EXTERIOR LIGHTING:HEADLIGHTS. BMW: HEADLAMP MOISTURE: FAULT DIAGNOSTICS. WATER OR CONDENSATION IN ONE OR BOTH HEADLAMPS. MODELS 5 SERIES, 6 SERIES, 7 SERIES, X5, X6, 1 SERIES, AND 3 SERIES. MODEL YEARS 2000-20008. *PE
SI B52 05 082008-09-10. Service bulletin. SEATS. BMW: SEAT FRAME DESIGN CHANGED FOR 392 (3 SERIES COUPE) PRODUCED UP TO MAY 2007. ON EARLY PRODUCTION E92S, THE SOCKET WHICH SECURES THE SEAT BACKREST RELEASE CABLE TO THE RELEASE MECHANISM COULD PULL FREE FROM THE RELEASE MECHANISM. *PE
SI B63 02 082008-08-22. Service bulletin. EXTERIOR LIGHTING:TAIL LIGHTS. REAR BULB FAILURE. MODEL E92 (3 SERIES COUPE) VEHICLES PRODUCED UP TO JANUARY 21, 2008 ARE AFFECTED. THE BULB OUT WARNING SHOWS IN THE INSTRUMENT CLUSTER. *PE
SI B11 13 072008-08-22. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER; ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO/SUPERCHARGER. N54 RATTLE NOISE FROM TURBOCHARGER AREA. MODELS E90, E92 AND E93 (3 SERIES) 335I AND 335XI; E60 AND E61 (5 SERIES) 535I AND 535XI, ALL WITH N54 ENGINE FROM THE START OF PRODUCTION TO JANUARY 17, 2008 PRODUCTION. *PE
SI B12 01 082008-08-22. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. N52 EDK THROTTLE JAMMING FAULTS 2D09, 2CED AND 2CEC. MODEL E90 AND E91 (3 SERIES) AND E60 AND E61 (5 SERIES), ALL MODELS UP TO 11/2005 WITH N52 ENGINE. *PE
1204052005-07-16. Service bulletin. ENGINE AND ENGINE COOLING:ENGINE. CHECK ENGINE LAMP ILLUMINATED AND/OR VEHICLE OVERHEATS. BMW E90 (3 SERIES) ALL E90 (3 SERIES) AND E60 (5 SERIES) MODELS EQUIPPED WITH N52 ENGINE. *TT
0001992000-10-06. Service bulletin. UNKNOWN OR OTHER. SUBJECT REGARDING NEW VEHICLE PREPARATION AND MAINTENANCE REQUIREMENTS. *TT
0001992000-05-31. Service bulletin. UNKNOWN OR OTHER. SUBJECT PERTAINING TO NEW VEHICLES PREPARATION AND MAINTENANCE REQUIREMENTS. *TT
8403991999-11-12. Service bulletin. EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM). THIS SERVICE INFORMATION BULLETIN MENTIONS THAT THE BMW MONOCHROME ACCESSORY NAVIGATION SYSTEM IS FINALLY IN STOCK. *TT

The summaries are NHTSA's. Each bulletin's page links NHTSA's copy of the manufacturer's document.