Service bulletin 1800302
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 629146 |
| Published by NHTSA | 2002-03-27 |
| Manufacturer's number | 1800302 |
| Manufacturer's date | 2002-01-21 |
| NHTSA component | ENGINE AND ENGINE COOLING:ENGINE:GASOLINE |
NHTSA's summary
SOME VEHICLES MAY EXHIBIT ROUGH IDLE AFTER COLD START UP, SAG OR HESITATION AFTER COLD START, WARM IDLE INSTABILITY, AND SPARK KNOCK. *TT
The document
No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.
Components
Engine
| DODGE DAKOTA | 2001 |
|---|
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 68332810 | 2022-10-17. Service bulletin. Service - Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY - The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T-joints.~ 2. Fill the T-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket(s) onto the oil pan flange.~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2-mm [0.063-in] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m [21 ft. lbs.]. |
|---|---|
| R2118796A | 2021-05-03. Service bulletin. Valve Body. These may cause over drive cycling. |
| 1800902A | 2002-09-27. Service bulletin. SUBJECT REGARDING FLASH: HOT SAG/SPARK KNOCK/TRANSMISSION SHIFT ISSUES. *SLC |
| 1800902 | 2002-04-30. Service bulletin. SUBJECT REGARDING FLASH: HOT SAG/SPARK KNOCK/TRANSMISSION SHIFT ISSUES. *JG |
| 1100201 | 2001-11-29. Service bulletin. SOME VEHICLES MAY EXHIBIT A HISSING SOUND WHEN WATER FROM THE EVAPORATOR DRAIN DRIPS ON THE EXHAUST. *TT |
| 0900301 | 2001-10-05. Service bulletin. THIS BULLETIN REINFORCES A REQUIREMENT TO CEASE THE CURRENT PRACTICE OF USING SUPPLEMENTAL OIL ADDITIVE TREATMENTS IN ALL DAIMLERCHRYSLER ENGINES. *TT |
| 2500401 | 2001-07-11. Service bulletin. SUBJECT REGARDING ADDITIONAL DIAGNOSTIC FOR DIAGNOSTIC TROUBLE CODES CAUSED BY AN EVAPORATIVE SYSTEM LEAK. *TT |
| 963 | 2001-04-13. Service bulletin. EMISSIONS RECALL TO INSTALL AN EVAPORATIVE CANISTER PURGE ORIFICE WHICH WAS INADVERTENTLY OMITTED. *JB |