# Service bulletin 090298

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

- Type: Service bulletin
- NHTSA id: 600803
- Published by NHTSA: 1999\-11\-08
- Manufacturer's number: 090298
- Manufacturer's date: 1998\-04\-03
- NHTSA component: ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

## NHTSA's summary

SUBJECT ON ENGINE TO TRANSMISSION DOWEL SERVICE. \*YC

## The document

No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.

## Components

Engine

## Vehicles listed

- 1999 CHRYSLER 300M
- 1998 to 1999 CHRYSLER CONCORDE
- 1998 CHRYSLER LHS
- 1999 CHRYSLER LHS
- 1998 to 1999 DODGE INTREPID

## Other bulletins for the same vehicles and component

- [68332810](/bulletins/10223854.md), 2022-10-17, Service bulletin: ENGINE AND ENGINE COOLING. Service \- Four Piece Oil Pan Gasket All Cummins Equipped Vehicles ONLY \- The replacement oil pan gasket can be a four piece gasket rather than a single piece gasket. This applies to Cummins 5.9L and 6.7L engines only. Installation: 1. Clean the oil pan T\-joints.\~ 2. Fill the T\-joint between the pan rail/gear housing and pan rail/rear seal retainer with sealant. Use Mopar® Silicone Rubber Adhesive Sealant or equivalent. 3. Apply a 2\-mm \[0.063\-in\] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the oil pan flange.\~ 4. The four piece gasket will need to be assembled to make a complete oil pan gasket. 5. Lay the oil pan gasket\(s\) onto the oil pan flange.\~ 6. Ensure the oil pan gasket segment joints are properly aligned. 7. Apply a 2\-mm \[0.063\-in\] bead of Mopar Engine Sealant RTV Silicone Rubber Adhesive, to the top of the oil pan gasket.\~ 8. Install the oil pan. Starting from the center and working outward, tighten the oil pan bolts to 28 N·m \[21 ft. lbs.\].
- [R2118796A](/bulletins/10191460.md), 2021-05-03, Service bulletin: ENGINE AND ENGINE COOLING. Valve Body. These may cause over drive cycling.
- [2500102A](/bulletins/10006129.md), 2004-04-21, Service bulletin: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL. MALFUNCTION INDICATOR LAMP \(MIL\) ILLUMINATION, DIAGNOSTIC TROUBLE CODE \(DTC\) P0442, P0455, OR P0456 \- LEAK DETECTION PUMP \(LDP\), LEAK DETECTED. THIS BULLETIN SUPERSEDES 25\-001\-02 DATED FEB 11, 2002. \*TT
- [0900204](/bulletins/10005587.md), 2004-03-04, Service bulletin: ENGINE AND ENGINE COOLING. SHORT DURATION COLD ENGINE START\-UP TICKING LIKE SOUND. THIS BULLETIN APPLIES TO VEHICLES BUILT PRIOR TO MARCH 31, 2003. \*MN
- [0900503](/bulletins/10005297.md), 2004-02-20, Service bulletin: ENGINE AND ENGINE COOLING:ENGINE. SHORT DURATION COLD ENGINE START\-UP TICKING LIKE SOUND. \*TT
- [0900203](/bulletins/10002279.md), 2003-08-20, Service bulletin: ENGINE AND ENGINE COOLING:ENGINE. ENGINE STUMBLE AND/OR MISFIRE \- MALFUNCTION INDICATOR LAMP ILLUMINATION. \*TT
- [1802302](/bulletins/635687.md), 2002-10-30, Service bulletin: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR. CONCERNS WITH MALFUNCTION INDICATOR LAMP ILLUMINATION WITH A CATALYST EFFICIENCY FAILURE DIAGNOSTIC TROUBLE CODE \(DTC P0420\) RECORDED IN THE POWER TRAIN CONTROL MODULE \(PCM\). \*TT
- [0700202](/bulletins/629133.md), 2002-03-27, Service bulletin: ENGINE AND ENGINE COOLING:COOLING SYSTEM. SUBJECT REGARDING LOW OR NO CABIN HEAD, ENGINE COOLING SYSTEM SYSTEM FILL PROCEDURE. \*TT
- [01015](/bulletins/620946.md), 2001-09-04, Service bulletin: ENGINE AND ENGINE COOLING:ENGINE:GASOLINE. ADVANCE SERVICE INFORMATION REGARDING A NO\-START CONDITION WHICH MAY EXIST FOLLOWING A HOT SOAK. \*TT
- [070200](/bulletins/614154.md), 2000-09-29, Service bulletin: ENGINE AND ENGINE COOLING:COOLING SYSTEM. SOME VEHICLES MAY EXHIBIT ENGINE OVERHEATING AND / OR COOLANT BOTTLE FAILURES AFTER SERVICE HAS BEEN PERFORMED ON THE ENGINE COOLING SYSTEM. \*TT

JSON: [/v1/bulletins/600803](/v1/bulletins/600803)

[Report an error on this page](https://github.com/wenmar-pro/wenmar-open/issues/new?template=data_correction.yml&title=Data%20correction%3A%20Service%20bulletin%20090298&page=https%3A%2F%2Fopen.wenmarpro.com%2Fbulletins%2F600803&vehicle=Service%20bulletin%20090298)