Service bulletin MSG95C53
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 45832 |
| Published by NHTSA | 1996-04-25 |
| Manufacturer's number | MSG95C53 |
| Manufacturer's date | 1995-08-01 |
| NHTSA component | ENGINE AND ENGINE COOLING:ENGINE |
NHTSA's summary
GENERAL MOTORS HAS DECIDED THAT CERTAIN 1995 CAVALIER, CORSICA/BERETTA, S TRUCKS EQUIPPED WITH 2.2L (LN2) 4 CYCLINDER ENGINES MAY HAVE PUSH ROD THAT MAY BE IN IN HARD CONTACT WITH THE ANTI-ROTATION BRACKET SECURING THE ROLLER LIFTERS. IF THE PUSH ROD IS IN HARD CONTACT WITH THE LIFTER ANTI-ROTATION BRACKET, IT MAY NOT BE PROPERLY SEATED IN THE LIFTER WHICH MAY REDUCE PROPER OIL FLOW TO THE THE ROCKER ARMS AND AFFECT DURABILITY. TO CORRECT THIS CONDITION, DEALERS ARE TO INSPECT THE ENGINES FOR PROPER OIL FLOW AND IF FOUND RESTRICTED, REPLACE BOTH ANTI-ROTATION BRACKETS, AND THE #1 AND #3 EXHAUST PUSH RODS AND ROCKER ARMS.
The document
No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.
Components
Engine
| CHEVROLET BERETTA | 1995 |
|---|---|
| CHEVROLET BLAZER | 1995 |
| CHEVROLET CAVALIER | 1995 |
| CHEVROLET CORSICA | 1995 |
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 2000109 | 2000-04-28. Engine |
|---|---|
| 1999016 | 1999-02-15. Engine |
| 95V180000 | 1995-09-22. ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN |
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| 130089009 | 2023-12-11. Service bulletin. Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules |
|---|---|
| 010601002A | 2003-03-31. Service bulletin. REVISED PISTON PIN REMOVAL / INSTALLATION PROCEDURE. *TT |
| 990604005A | 2001-05-24. Service bulletin. SOME OWNERS MAY COMMENT ON DRIVEABILITY SYMPTONS OF LONG OR HARD STARTS, CHUGGLE, ROUGH IDLE AND LIGHT OR INTERMITTENT MISFIRE DUE TO CLOGGED FUEL INJECTORS. *TT |
| 98054 | 2000-12-27. Service bulletin. GENERAL MOTORS HAS DETERMINED THAT SOME VEHICLES EQUIPPED WITH 2.2 LITER ENGINES MAY DEVELOP A FAILURE OF THE CYLINDER HEAD GASKET LEADING TO EXTERNAL COOLANT LEAKS FROM THE CYLINDER HEAD GASKET TO ENGINE BLOCK JOINT. *TT |
| 876002A | 2000-12-26. Service bulletin. SOME V6 ENGINES MAY, ON A VERY INFREQUENT BASIS, HAVE AN OIL ODOR CONDITION THAT IS GENERALLY ENCOUNTERED AFTER THE ENGINE'S OIL HAS BEEN CHANGED.TYPICALLY THE ODOR LASTS APPROXIMATELY 1000 MILES AFTER THE CHANGE OF OIL AND THEN DOES NOT REAPPEAR UNTIL THE NEXT CHANGE OF OIL. *TT |
| 98054 | 2000-07-25. Service bulletin. SUBJECT REGARDING ADDTIONAL INFORMATION FOR SPECIAL POLICY 98054 - COOLANT LOSS, VISIBLE COOLANT LEAKAGE, OR COOLANT ODOR. **MR |
| 99088A | 2000-07-25. Service bulletin. VOLUNTARY EMISSION CAMPAIGN INVOLVING VEHICLES EXHIBITING SYMPTONS RESULTING IN THE ILLUMINATION OF THE CHECK ENGINE LIGHT OR THE ENGINE RUNNING ROUGH. **MR |
| 99088A | 2000-06-12. Service bulletin. VEHICLES EXHIBIT SYMPTOMS RESULTING IN THE ILLUMINATION OF THE CHECK ENGINE LIGHT OR THE ENGINE RUNNING ROUGH (INSPECTION, CLEAN/REPLACE AND SEAL PCM, AND INSTALL PROTECTIVE PCM SHIELD ASSEMBLY). *MJS |
| 99088REV | 2000-06-09. Service bulletin. INFORMATION REGARDING ADDITIONAL CORRECTIONS FROM PRIVIOUS CAMPAIGN 99088, CONDITIONS THAT CONCERN ROUGH RUNNING ENGINE AND CHECK ENGINE LIGHT ILLUMINATION. MJS |
| 98054A | 1999-09-30. Service bulletin. SOME VEHICLES MAY DEVELOP A FAILURE OF THE CYLINDER HEAD GASKET LEADING TO EXTERNAL COOLANT LEAKS. *TT |