Service bulletin RCL/617
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 43047 |
| Published by NHTSA | 1995-11-01 |
| Manufacturer's number | RCL/617 |
| Manufacturer's date | 1995-05-01 |
| NHTSA component | ENGINE AND ENGINE COOLING:EXHAUST SYSTEM |
NHTSA's summary
UNKNOWN
The document
No address for NHTSA's copy can be built for this communication. Ask the dealer for it by the manufacturer's number.
Components
Engine, Exhaust and emissions
| JEEP CHEROKEE | 1989, 1990 |
|---|---|
| JEEP COMANCHE | 1989, 1990 |
| JEEP WRANGLER | 1989, 1990 |
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 1995062 | 1995-04-07. Emissions |
|---|---|
| 1994195 | 1994-12-12. Emissions |
| 1993071 | 1993-05-21. Emissions |
| 1991018 | 1991-01-29. Engine |
| 1990156 | 1990-10-05. Emissions |
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| 070397 | 2000-01-07. Service bulletin. CONCERNS WITH ENGINE COOLANT USAGE. *NLM |
|---|---|
| 070397 | 1997-11-13. Service bulletin. VARIOUS CAR OWNER'S HAVE EXPRESSED INTEREST IN USING ENGINE COOLANTS MADE WITH PROPYLENE GLYCOL INSTEAD OF ETHYLENE GLYCOL. *YC |
| RCL647 | 1996-04-25. Service bulletin. APPLIES TO VEHICLES EQUIPPED WITH A 4.2L ENGINE AND FEDERAL HIGH ALTITUDE EMISSION CONTROL SYSTEM. FUEL VAPORS MAY CAUSE DETERIORATION OF THE PCV HARNESS ASSEMBLY. THE PCV HARNESS ASSEMBLY MUST BE REPLACED AND THE ENGINE IDLE SPEEDS MUST BE RESET. |
| RCL/558 | 1995-11-01. Service bulletin. RECALL 558 - FAILURE OF THE OXYGEN SENSOR AND CATALYTIC CONVERTER MAY CAUSE A VEHICLE TO BE IN VIOLATION OF CALIFORNIA EMISSIONS STANDARDS. TO CORRECT THIS CONDITION, THE OXYGEN SENSOR AND CATALYTIC CONVERTER MUST BE REPLACED WITH IMPROVED DESIGN PARTS. *TW |
| RCL/556 | 1995-03-01. Service bulletin. IT HAS BEEN DETERMINED THAT CERTAIN EMISSION RELATED COMPONENTS OF THE 1989 JEEP EQUIPPED WITH THE 2.5L ENGINE, MAY BE SUSCEPTIBLE TO FAILURE. FAILURE OF THESE COMPONENTS MAY CAUSE THE VEHICLE TO BE IN VIOLATION OF CALIFORNIA EMISSIONS STANDARDS. HYDROCARBONS, CARBON MONOXIDE AND OXIDES OF NITROGEN COULD BE ABOVE THE ALLOWABLE LIMITS, WHICH WERE ESTABLISHED TO PROTECT PUBLIC HEALTH FROM THE DANGERS OF AIR POLLUTION. TO CORRECT THIS PROBLEM, DEALERS WILL REPLACE THE OXYGEN SENSOR, CRANKCASE VENTILATION HOSE AND IF EQUIPPED, THE TRANSFER CASE VACUUM HOSE AND FUEL TANK VENT BOOT. IN ADDITION, THE THE EXHAUST MANIFOLD WILL BE CHECKED FOR AN EXHAUST LEAK NOISE AND REPLACED AS RQUIRED. *TW |
| RCL/557 | 1995-03-01. Service bulletin. IT HAS BEEN DETERMINED THAT THE 1990 JEEP VEHICLE, EQUIPPED WITH THE 2.5L ENGINE, MAY BE IN VIOLATION OF FEDERAL EMISSIONS STANDARDS. HYDROCARBON, CARBON MONOXIDE AND OXIDES OF NITROGEN LEVELS COULD BE ABOVE ALLOWABLE LIMITS, WHICH WERE ESTABLISHED TO PROTECT THE PUBLIC HEALTH FROM THE DANGERS OF AIR POLLUTION. TO CORRECT THIS PROBLEM, DEALERS WILL REPLACE THE OXYGEN SENSOR. *TW |
| RCL/616 | 1995-03-01. Service bulletin. IT HAS BEEN DETERMINED THAT THE OXYGEN SENSOR ON CERTAIN 1989 JEEP CHEROKEE, COMANCHE AND WRANGLER MODELS EQUIPPED WITH A 2.5L ENGINE MAY BE SUSCEPTIBLE TO FAILURE. FAILURE OF THE OXYGEN SENSOR MAY CAUSE YOUR VEHICLE TO BE IN VIOLATION OF FEDERAL EMISSIONS STANDARDS. TO CORRECT THIS PROBLEM, DEALERS WILL REPLACE THE OXYGEN SENSOR. *TW |
| 011395 | 1995-03-01. Service bulletin. SUPPLEMENTAL INFORMATION TO MANUFACTURER'S RECALL #556. *TW |
| RCL/589 | 1995-02-10. Service bulletin. HYDROCARBON AND CARBON MONOXIDE EMISSIONS LEVLS FOR THE ABOVE LISTED MODEL VEHICLES MAY EXCEED THE LIMITS ALLOWED BY CALIFORNIA EMISSIONS STANDARDS. TO CORRECT THE CONDITION, THE PCV HARNESS, CHOKE VACUUM DIAPHRAGM, EGR VALVE AND DECEL VALVE, IF EQUIPPED, MUST BE REPLACED. *TW |