Service bulletin 18-012-26
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 11028239 |
| Published by NHTSA | 2026-02-04 |
| Manufacturer's number | 18-012-26 |
| Manufacturer's date | 2026-01-31 |
| NHTSA component | ELECTRICAL SYSTEM |
NHTSA's summary
NOte: Revision is being created to correct the Models affected. Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● P0072-00 - Ambient Air Temperature Sensor Circuit "A" Low. ● P0087-00 - Fuel Rail Pressure Too Low. ● P2540-00 - Low Pressure Fuel System Sensor Circuit Range/Performance. ● P2543-00 - Low Pressure Fuel System Sensor Circuit Intermittent. ● P20EE-00 - SCR Nox Catalyst Efficiency Below Threshold - Bank 1 Catalyst 1. ● P203F-00 - Reductant Level Too Low. ● P2698-00 - Exhaust Aftertreatment Fuel Injector "A" Performance. ● P06B9-00 - Cylinder 1 Glow Plug Circuit Performance. ● P06BA-00 - Cylinder 2 Glow Plug Circuit Performance. ● P06BB-00 - Cylinder 3 Glow Plug Circuit Performance. ● P06BC-00 - Cylinder 4 Glow Plug Circuit Performance. ● P06BD-00 - Cylinder 5 Glow Plug Circuit Performance. ● P06BE-00 - Cylinder 6 Glow Plug Circuit Performance. Customers may also comment on one or more of the following: ● Diesel Exhaust Fluid (DEF) level gauge inaccuracy. ● Poor cold start performance. ● Unable to initiate manual Diesel Particulate Filter (DPF) regen through Electronic Vehicle Information Center (EVIC). ● While using the remote Power Take-Off (PTO) feature, the PTO may not engage or resume operation properly, after disengaging: 1. Engine is running with PTO engaged. 2. Operator is using the equipment, for example a bucket attachment. 3. Operator gets in position, then uses remote start/stop button to turn truck off while they perform a task. 4. The task is completed, then operator is ready to move the bucket so they use remote start/stop to start the engine. 5. The engine starts, but PTO does not automatically re-engage so their equipment doesn’t operate. This bulletin involves inspecting and possibly reprogramming the PCM with the latest available software.
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Electrical system
Trouble codes named
P0072, P0087, P06B9, P06BA, P06BB, P06BC, P06BD, P06BE, P203F, P20EE, P2540, P2543, P2698
| RAM 4500 | 2026 |
|---|---|
| RAM 5500 | 2026 |
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 26V225000 | 2026-04-09. ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL |
|---|---|
| 2026043 | 2026-02-02. Electrical |
| 26V059000 | 2026-02-02. ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL; EXTERIOR LIGHTING:TURN SIGNAL; EXTERIOR LIGHTING:BRAKE LIGHTS |
| 25V826000 | 2025-12-01. ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL |
| 25V530000 | 2025-08-18. SERVICE BRAKES; ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL |
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| 9100926 | 2026-10-07. Service bulletin. WIRELESS CHARGER Welcome GREEN LED not turning ON after multiple IGN ON/OFF without sleep cycle and no phone on the charging pads. Part numbers affected: 68630089AA 68630088AB 68649038AA Welcome Green LED turns on for 1 second after multiple IGN ON/OFF without sleep cycle and no phone on the charging pad. Intent of this condition is to notify the customer/dealership that the Wireless Charging Pad is ready to charge. Do not report as warranty claim, no impact to wireless charger functionality. Part numbers affected: 68630089AB 68630088AD 68649038AB Advice to dealership: Do no replace wireless charger PNs 68630089AA,68630088AB,68649038AA if no Welcome GREEN LED is seen after multiple IGN ON/OFF without sleep cycle and no phone on the charging pads. This feature is available in the successor NIKs, no impact to wireless charger functionality. |
|---|---|
| 25-004-26 REV. A | 2026-09-30. Service bulletin. Exhaust Gas Temperature (EGT) Sensor Water Intrusion ’s VIN MUST be listed in VIP or your RSU VIN list. NOTE: This bulletin applies to ● The Vehicle MUST be built on or before February 16, 2026 (MDH North America, Enlarged 0216XX). Europe, Middle East & ● The vehicle MUST be equipped with a 6.7L I6 Cummins Turbo Africa, and India & Asia Diesel Engine (Sales Codes ETM or ETN). Pacific markets. CUSTOMER Customers may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may SYMPTOM: exhibit/set the following Diagnostic Trouble Code (DTC): ● P2482-00 - Exhaust Gas Temperature Sensor Circuit High - Bank 1 Sensor 5. Customers may also comment on the following: ● Soot load is too high and power derate occurs due to regen being disabled. This bulletin involves replacing the EGT sensors. |
| 9100922 | 2026-09-23. Service bulletin. SENSOR Exhaust Temperature If this sensor is being replaced due to an early-life P242B pending fault code, clear the fault code and perform the Powertrain Verification Test. Only replace the sensor if P242B returns as an active fault code. |
| OTHERDOC_176 | 2026-09-17. Other. Radio Over The Air Update to U43.17 R1H Software Version (FOTA) Customers may experience one or more of the following:- Navigation Stability - Android Auto & Carplay stability & connectivity- Trailer Tow pages- Distorted/glitchy display prior to start‑up animation- Text appearance display- Widget incorrect display- Turn signal blind spot response timing- Audio cut out - Drive Modes selection- Park assist Guidelines selctio |
| 25-004-26 | 2026-09-17. Service bulletin. Exhaust Gas Temperature (EGT) Sensor Water Intrusion CUSTOMER Customers may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may SYMPTOM: exhibit/set the following Diagnostic Trouble Code (DTC): ● P2482-00 - Exhaust Gas Temperature Sensor Circuit High - Bank 1 Sensor 5. Customers may also comment on the following: ● Soot load is too high and power derate occurs due to regen being disabled. This bulletin involves replacing the EGT sensors. |
| 08-331-26 | 2026-09-17. Service bulletin. Flash: Vehicle System Interface Module (VSIM) Updates Customers may experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle may SYMPTOM: exhibit/set the following Diagnostic Trouble Code (DTC): ● B2204-87 - Ecu Configuration Mismatch-Missing Message. Customers may comment on the following: ● Odometer is blinking while ignition is on. This bulletin involves inspecting and possibly reprogramming the VSIM with the latest available software. |
| S2623000052 REV. A | 2026-09-10. Service bulletin. Airbag Warning Light On or Intermittent. The Occupant Restraint Controller (ORC) May Have The Following DTCs (Active/Stored) |
| 08-315-26 | 2026-08-26. Service bulletin. Flash: Integrated Trailer Control Module (ITCM) Update Customers may experience the following: SYMPTOM: ● 'Check Trailer Turn Lamp' message in the Instrument Panel Cluster (IPC) with no trailer connected. This bulletin involves inspecting and possibly reprogramming the ITCM with the latest software. |
| 9100879 | 2026-08-13. Service bulletin. Front Passenger Display Module Verify "Z" part number availability. Order a "Z" part number for all Exchange Orders, Warranty, Mopar, Customer Pay and Service Contract. Order "68" part number for New, Unsold units only. |
| 113795 | 2026-08-13. Service bulletin. HEADLAMP |