WenmarOpen by Wenmar Pro

Service bulletin TSB_FUE068

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
TypeService bulletin
NHTSA id11019972
Published by NHTSA2025-07-01
Manufacturer's numberTSB_FUE068
Manufacturer's date2025-06-30
Campaign id or software versionCA2505
NHTSA componentFUEL/PROPULSION SYSTEM
Manufacturer's systemFUE

NHTSA's summary

TECHNICAL SERVICE BULLETIN: GDI FUEL INJECTOR REPLACEMENT FOR MISFIRE DTC(S) THETA III 2.5L GDI (CA2505) -This bulletin provides information regarding cylinder misfire DTCs stored on some 2021-2023MY Kia models listed in the table below equipped with a naturally aspirated Theta III 2.5L GDI engine and dual fuel injection, where a low-pressure (MPI) injector and a high-pressure (GDI) injector independently supply fuel to each cylinder. A GDI fuel injector may become damaged due to exposure to fuel containing ethanol, potentially resulting in the malfunction indicator lamp (MIL) illuminating, along with no-start, misfire, and/or reduced power, while driving at highway speeds remains possible.

The document

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Fuel system

Vehicles listed
KIA SORENTO2021, 2022
KIA SPORTAGE2023

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
23V0270002023-01-25. FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
20214212021-07-09. Fuel System
21V5190002021-07-08. FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
TSB_ELE4162026-07-28. Service bulletin. TECHNICAL SERVICE BULLETIN: ON-BOARD CHARGER INSPECTION AND REPLACMENT (SA644) - This bulletin provides information related to charging system diagnosis and repair on certain Sportage (NQ5 PHEV) vehicles produced from December 13, 2022 through May 30, 2023. The affected vehicles may experience interrupted or inoperative high‑voltage battery charging due to an on‑board charger (OBC) internal malfunction. As a result, charging of the high-voltage battery may be interrupted or unavailable, with several diagnostic trouble codes (DTCs) stored related to the OBC unit. If this occurs, the vehicle can still be driven by the internal combustion engine.
TSB_ELE399_R12026-02-02. Service bulletin. TECHNICAL SERVICE BULLETIN: BMS DISCHARGE LOGIC IMPROVEMENT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to upgrade the ‘BMS’ system software on certain 2023-2024MY Sportage HEV (NQ5 HEV) vehicles produced from February 15, 2022, through December 15, 2023, which may experience excessive discharging of the 12V lithium battery while parked, potentially resulting in a no-start condition.
TSB_FUE0682025-10-24. Service bulletin. TECHNICAL SERVICE BULLETIN: GDI FUEL INJECTOR REPLACEMENT FOR MISFIRE DTC(S) THETA III 2.5L GDI (CA2505) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding cylinder misfire DTCs stored on some 2021-2023MY Kia models listed in the on the table on page 4, equipped with a naturally aspirated Theta III 2.5L GDI engine and dual fuel injection, where a low-pressure (MPI) injector and a high-pressure (GDI) injector independently supply fuel to each cylinder. A GDI fuel injector may become damaged due to exposure to fuel containing ethanol, potentially resulting in the malfunction indicator lamp (MIL) illuminating, along with no-start, misfire, and/or reduced power, while driving at highway speeds remains possible.
TSB_ELE3992025-09-11. Service bulletin. TECHNICAL SERVICE BULLETIN: BMS DISCHARGE LOGIC IMPROVEMENT - This bulletin provides information to upgrade the ‘BMS’ system software on certain 2023-2024MY Sportage (NQ5 HEV) vehicles produced from February 15, 2022, through December 15, 2023, which may experience excessive discharging of the 12V lithium battery while parked, potentially resulting in a no-start condition.
SC338_OWNR_NQ5_1022025-09-11. Emissions. VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION: EXPANSION (SC338 Flight 102) - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign to update the battery management system (BMS) to prevent overcharging of the 12V Lithium battery in certain 2023-2024 MY Sportage Hybrid (HEV) vehicles to ensure compliance with emissions regulations.
TSB_SC338_R12025-09-03. Emissions. TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: BMS S/W LOGIC IMPROVEMENT FOR DTC P1BB2 (SC338) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to upgrade the Battery Management System ‘BMS’ software logic on certain 2023-2024MY Sportage HEV (NQ5 HEV) vehicles produced from February 15, 2022 to December 15, 2023, and 2023MY Niro HEV (SG2 HEV) vehicles produced from June 21, 2022 through April 25, 2023. Due to a software issue, the Battery Management System (BMS) may inadvertently overcharge the 12V Lithium battery. If the 12V Lithium battery becomes overcharged, the subject vehicles may experience a reduction in motive power accompanied by the ‘Check Hybrid System, Stop Safely’ warning message, Hybrid system warning lamp, Service warning lamp, Charging system warning lamp, and a rapid beeping sound for approximately ten (10) seconds. (Note: This Voluntary Emissions Service Campaign supersedes SC335).
TSB_FUE066_CLSD2025-07-01. Service bulletin. TECHNICAL SERVICE BULLETIN: GDI FUEL INJECTOR REPLACEMENT FOR MISFIRE DTC(S) - CLOSED AND SUPERSEDED BY FUE068/CA2505 - This bulletin is now closed. This bulletin provides information regarding cylinder misfire DTCs stored on some 2021-2023MY Kia models listed in the table below equipped with a naturally aspirated Theta III 2.5L GDI engine and dual fuel injection, where a low-pressure (MPI) injector and a high-pressure (GDI) injector independently supply fuel to each cylinder. A GDI fuel injector may become damaged due to exposure to fuel containing ethanol, potentially resulting in the malfunction indicator lamp (MIL) illuminating, along with no-start, misfire, and/or reduced power, while driving at highway speeds remains possible.
SC338_TSB2025-07-01. Service bulletin. TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: BMS S/W LOGIC IMPROVEMENT FOR DTC P1BB2 (SC338) - This bulletin provides information to upgrade the Battery Management System ‘BMS’ software logic on certain 2023MY Sportage HEV (NQ5 HEV) vehicles produced from February 15, 2022 to October 28, 2023, and 2023-2024MY Niro HEV (SG2 HEV) vehicles produced from June 21, 2022 through February 6, 2023. Due to a software issue, the Battery Management System (BMS) may inadvertently overcharge the 12V Lithium battery.
SC335_TSB_CLSD2025-07-01. Service bulletin. TECHNICAL SERVICE BULLETIN: VOLUNTARY SERVICE CAMPAIGN: BMS S/W LOGIC IMPROVEMENT FOR DTC P1BB2 (SC335) CLOSED AND SUPERSEDED TO SC338 (TSB) - This bulletin is now closed. "This bulletin provided information to upgrade the Battery Management System ‘BMS’ software logic on certain 2023-2024MY Sportage HEV (NQ5 HEV) vehicles produced from February 15, 2022 to October 28, 2023, and2023-2024MY Niro HEV (SG2 HEV) vehicles produced from June 21, 2022 through February 6, 2023. Due to a software issue, the Battery Management System (BMS) may inadvertently overcharge the 12V Lithium battery.
SC338_STKR2025-06-25. Emissions. SC338_STKR: VOLUNTARY EMISSIONS SERVICE CAMPAIGN COMPLETION LABEL/STICKER