Service bulletin LI65.10-P-074275

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

NHTSA's summary

Complaint A) Wind noise in area of rear edge of rear fixed element of panoramic sliding sunroof (EPC item 78/150/550) at speeds over approx. 75mph (Picture I) B) Wind noise in area of rear edge of rear fixed element of panoramic sliding sunroof (EPC item 78/150/550) at speeds over approx. 120mph (Picture I) Cause Below are potential causes for the complaint. A) Lifting and vibrating of sealing lip of rear roof paneling (EPC item 65/015/310) on outer left and right, at the contact surface with the end cap of the drip rail (EPC item 69/060/250) B) Lifting and vibrating of sealing lip of rear roof paneling (EPC item 65/015/310) in the center of the vehicle (Y=0), at the contact surface with the rear fixed element of the panoramic sliding sunroof (EPC item 78/150/550) Identification of source of noise by masking off of (Picture II): A) Joint between drip rail (EPC item 69/060/250), rear roof paneling (EPC item 65/015/300) and rear fixed element of panoramic sliding sunroof (EPC item 78/150/550) B) Joint between sealing lip of rear roof paneling (EPC item 65/015/310) and rear fixed element of panoramic sliding sunroof (EPC item 78/150/550), with approx. 5 cm-long adhesive strip - CAUTION: Sealing lip is very sensitive, do not damage! Remedy A1) Sealing lip (EPC item 65/015/310) is mounted OVER the end cap of the drip rail (EPC item 69/060/250) (Picture III): Carefully push sealing lip under the end cap of the drip rail using a wide plastic wedge A2) Sealing lip (EPC item 65/015/310) is mounted UNDER the end cap of the drip rail (EPC item 69/060/250) (Picture III): Trim sealing lip in extension of glass edge of rear fixed element for panoramic sliding sunroof (EPC item 78/150/550) (Picture IV) B) Replace sealing lip (EPC item 65/015/310); to do so, the rear roof paneling (EPC item 65/015/300) must be removed (attempt to remove the rear roof paneling without damaging it; only replace if damaged) NOTE: Before starting the repair, please ensure that the parts are available in the workshop!

The document

• NHTSA's copy of the document (PDF)
• If that address does not open, try this one

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Body and frame

Listing a model year does not mean every vehicle of it is concerned: the document says which.

• Bulletins for another vehicle
• Report an error on this page
• Report an error by email