WenmarOpen by Wenmar Pro

Service bulletin SC293_TSB

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
TypeService bulletin
NHTSA id10253808
Published by NHTSA2024-05-06
Manufacturer's numberSC293_TSB
Manufacturer's date2024-04-23
NHTSA componentELECTRICAL SYSTEM; FUEL SYSTEM, GASOLINE; ENGINE AND ENGINE COOLING

NHTSA's summary

TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: FUEL INJECTOR HARNESS INSPECTION AND REPLACEMENT (SC293) - This bulletin provides information to inspect and if necessary, replace the fuel injector wire harness on certain 2024MY Sportage HEV (NQ5 HEV) vehicles equipped with a GAMMA II 1.6L T-GDI engine, produced from November 15, 2023 through November 20, 2023. The subject vehicles may have been assembled with a fuel injector harness that can cause a poor electrical terminal connection. A poor connection can cause uneven fuel delivery to the engine, affecting engine performance and emissions.

The document

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Electrical system, Engine, Fuel system

Vehicles listed
KIA SPORTAGE HYBRID2024 (the catalog's model; the bulletin names a series or trim of it)

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
25V8740002025-12-17. TRAILER HITCHES; ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
TSB_CLI049_R22026-09-02. Service bulletin. TECHNICAL SERVICE BULLETIN: PARTIAL REPAIR – ELECTRICAL A/C COMPRESSOR - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information regarding the partial repair of the Air Conditioning (A/C) compressor assembly on some 2011MY~ Optima Hybrid (TF HEV, JF HEV/PHEV), 2015MY~ Soul EV (PS EV), 2017MY~ Niro (DE HEV/PHEV/EV), 2022MY~ EV6 (CV), 2021MY~ Sorento (MQ4 HEV/PHEV), 2023MY~ Sportage (NQ5 HEV/PHEV), and 2023MY~ Niro (SG2 EV/HEV/PHEV) vehicles.
TSB_ELE4262026-08-27. Service bulletin. TECHNICAL SERVICE BULLETIN: AVN GEN 5.0 WIDE SOFTWARE UPDATE - This bulletin provides information on the Audio Video Navigation (AVN) system software update for certain vehicles equipped with AVN5W and Navigation System listed in the table below. Affected vehicles may overestimate travel times during route calculation.
TSB_ELE4222026-06-03. Service bulletin. TECHNICAL SERVICE BULLETIN: INFOTAINMENT SYSTEM SOFTWARE UPDATE USING UPDATE.KIA.COM - This bulletin provides information and service procedures for updating the infotainment systems on applicable Kia vehicles using the Kia Navigation Updater available at update.kia.com. The software update may improve system performance, enhance existing features, and apply the latest operating software for supported vehicles (2021-2026MY All Models).
TSB_ELE4172026-05-01. Service bulletin. TECHNICAL SERVICE BULLETIN: INFOTAINMENT SOFTWARE UPDATE PROCEDURE - This bulletin provides information on the process for downloading infotainment software updates and preparing USB for installation on applicable Kia vehicles. The software downloads and USB preparation process is similar across all supported platforms; however, in‑vehicle installation procedures vary by head unit type.
TSB_ENG2642026-04-01. Service bulletin. TECHNICAL SERVICE BULLETIN: CUSTOMER ACTION: ECU LOGIC IMPROVEMENT FOR DTC P2B59F0 (CA2516) - This bulletin provides information to upgrade the Engine Control Unit (ECU) software on certain 2024–2025MY vehicles equipped with 2.5 GDI or 2.5 T-GDI Theta III engines listed in the table below. Affected vehicles may experience an illuminated malfunction indicator light (MIL) accompanied with DTC P2B59F0 which can set while driving. There are no drivability issues related to this DTC.
TSB_ELE3942026-03-31. Service bulletin. TECHNICAL SERVICE BULLETIN: AVN5.0W DTC P17A000 DAIGNOSTIC PROCEDURE - This bulletin provides information regarding a potential illuminated Malfunction Indicator Lamp (MIL) accompanied by DTC P17A000 on some 2022-2025MY Hybrid Electric Vehicles (HEV) and Plug-In Hybrid Electric Vehicles (PHEV) equipped with AVN5.0Wide head units listed below. This condition occurs when the Global Positioning System (GPS) module within the Audio Video Navigation (AVN) head unit, sends an inaccurate signal to the Hybrid Power Control Unit (HPCU), causing the DTC to set. There are no drivability symptoms associated with this condition.
TSB_ELE399_R12026-02-02. Service bulletin. TECHNICAL SERVICE BULLETIN: BMS DISCHARGE LOGIC IMPROVEMENT - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to upgrade the ‘BMS’ system software on certain 2023-2024MY Sportage HEV (NQ5 HEV) vehicles produced from February 15, 2022, through December 15, 2023, which may experience excessive discharging of the 12V lithium battery while parked, potentially resulting in a no-start condition.
SC320_TSB_R12025-12-02. Service bulletin. TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: EGR VALVE ASSEMBLY REPLACEMENT (SC320) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to replace the Exhaust Gas Recirculation (EGR) Valve Assembly on certain 2024MY Kia vehicles listed in the table below. Kia has become aware that the EGR Valve Assembly in the subject vehicles may not have been manufactured to Kia’s specifications. This condition may cause the vehicle to release air pollutants which exceed Federal and California standards. As a result, the subject vehicles may exhibit an illumination of Malfunction Indicator Lamp (MIL) with DTC(s) P040500, P064200 and/or P065200.
TSB_ELE3992025-09-11. Service bulletin. TECHNICAL SERVICE BULLETIN: BMS DISCHARGE LOGIC IMPROVEMENT - This bulletin provides information to upgrade the ‘BMS’ system software on certain 2023-2024MY Sportage (NQ5 HEV) vehicles produced from February 15, 2022, through December 15, 2023, which may experience excessive discharging of the 12V lithium battery while parked, potentially resulting in a no-start condition.
SC338_OWNR_NQ5_1022025-09-11. Emissions. VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION: EXPANSION (SC338 Flight 102) - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign to update the battery management system (BMS) to prevent overcharging of the 12V Lithium battery in certain 2023-2024 MY Sportage Hybrid (HEV) vehicles to ensure compliance with emissions regulations.