# Service bulletin ONL6BN09142023

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

- Type: Service bulletin
- NHTSA id: 10242571
- Published by NHTSA: 2023\-09\-21
- Manufacturer's number: ONL6BN09142023
- Manufacturer's date: 2023\-09\-14
- NHTSA component: ENGINE AND ENGINE COOLING

## NHTSA's summary

Owner Notification Letter \- On some 2022 Passport, Pilot, and Ridgeline vehicles, during the manufacturing process, the cover cap for the front blower motor may have been partially blocked. If this occurs, airflow may be restricted to the motor, which may cause the motor to overheat.

## The document

- [NHTSA's copy of the document (PDF)](https://static.nhtsa.gov/odi/tsbs/2023/MC-10242571-0001.pdf)
- [If that address does not open, try this one](https://static.nhtsa.gov/odi/tsbs/2023/MC-10242571-9999.pdf)

The document is the manufacturer's. This site does not hold it.

## Components

Engine

## Vehicles listed

- 2022 HONDA PASSPORT
- 2022 HONDA PILOT
- 2022 HONDA RIDGELINE

## Other bulletins for the same vehicles and component

- [A24\-085](/bulletins/11005272.md), 2024-07-26, Service bulletin: ENGINE. Service Bulletin \- MIL flashes and vehicle will not accelerate, low power. After cycling the ignition, the symptom does not return with no stored DTCs. This issue is more common in regions with cold weather \(specifically near or below freezing temperatures\). Usually after a long drive \(around 2 hours\) and accelerating while cornering.
- [A24\-085](/bulletins/11002716.md), 2024-07-01, Service bulletin: ENGINE. Service Bulletin \- The MIL flashes and vehicle will not accelerate, low power. After cycling the ignition, the symptom does not return with no stored DTCs. This issue is more common in regions with cold weather \(specifically near or below freezing temperatures\). Usually after a long drive \(around 2 hours\) and accelerating while cornering. Moisture accumulation in the intake manifold during long drives gets drawn into the combustion chamber while cornering, causing misfires.
- [A24040A](/bulletins/11000142.md), 2024-05-15, Other: ENGINE. Service NewsDue to On\-Board Diagnostic \(OBD\) regulation change starting with 2019 vehicles, American Honda’s Variable Valve Timing and Lift Electronic Control \(VTEC\) On\-Board Diagnostic monitors are now included in the EGR/VVT OBD Monitor Readiness status group. Due to some customer’s driving patterns, they may not drive in the fashion needed to operate the VTEC \(EGR/VVT\) that only operates above 5,350 rpm to run the OBD monitoring. Therefore, the EGR/VVT OBD monitor group readiness status is not set to “Complete” when the customer presents their vehicle to a Smog Check station for inspection.
- [A23\-091](/bulletins/10247623.md), 2023-12-23, Service bulletin: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL; FUEL SYSTEM, GASOLINE; ENGINE AND ENGINE COOLING. Service Bulletin \- Due to variations in the purge control solenoid valve spring, the valve wears unevenly and intermittently sticks. This may result in setting DTC P0441 \(Evaporative Emission \(EVAP\) System Purge Flow Malfunction\).
- [A23\-008](/bulletins/10245550.md), 2023-11-29, Service bulletin: ENGINE AND ENGINE COOLING. Service Bulletin \- Under certain circumstances, after coming to a stop and the idle stop feature engages, the vehicle may not automatically restart. Typically, the customer can immediately restart the vehicle by selecting Park and pushing the ENGINE START/STOP button.
- [A23\-023](/bulletins/10234629.md), 2023-04-22, Service bulletin: ELECTRICAL SYSTEM:STARTER ASSEMBLY; ENGINE AND ENGINE COOLING. Service Bulletin \- The engine will not crank on initial startup after precipitation and sub\-freezing temperatures. Water can enter the starter motor, and when temperatures drop below freezing, the water will freeze inside the starter motor. This will prevent the starter from cranking the engine.
- [ATI\&03282023902](/bulletins/10233667.md), 2023-04-04, Service bulletin: ENGINE AND ENGINE COOLING; FUEL SYSTEM, GASOLINE. Dealer Message \- American Honda Motor Co., Inc. \(AHM\) is investigating certain 2020\-2022 Accords, CR\-Vs, Odysseys, Passports, Pilots, Ridgelines, 2020 Fits, 2020\-2021 Civic Hatchbacks, 2020\-2023 Civic Sedans/Coups with a customer complaint of the Check Engine Light \(CEL\) on \& the DTC P0087 \(Fuel Rail Pressure Too Low \[Loss of Fuel Pressure\]\) stored. In some cases, the customer may also experience such conditions as engine hard to start, no start or start \& stumble in conjunction with CEL. To better understand the cause of this condition, AHM would like to inspect the vehicle prior to you attempting a repair of any kind.
- [ATI\&03132023905](/bulletins/10233206.md), 2023-03-23, Service bulletin: ENGINE AND ENGINE COOLING; FUEL SYSTEM, GASOLINE. Dealer Message \- American Honda Motor Co., Inc. \(AHM\) is investigating certain 2020\-2022 Accords, CR\-Vs, Odysseys, Passports, Pilots, Ridgelines, 2020 Fits, 2020\-2021 Civic Hatchbacks, 2020\-2023 Civic Sedans/Coups with a customer complaint of the Check Engine Light \(CEL\) on \& the DTC P0087 \(Fuel Rail Pressure Too Low \[Loss of Fuel Pressure\]\) stored. In some cases, the customer may also experience such conditions as engine hard to start, no start or start \& stumble in conjunction with CEL. To better understand the cause of this condition, AHM would like to inspect the vehicle prior to you attempting a repair of any kind.
- [ONL6AX03102023\-2](/bulletins/10232977.md), 2023-03-18, Service bulletin: ENGINE AND ENGINE COOLING. Product Update \- Honda is conducting a product update to your 2019\-22 Passport, 2016\-22 Pilot, and 2020\-23 Ridgeline. Under certain circumstances, after coming to a stop and the idle stop feature engages, the vehicle may not automatically restart.
- [ONL6T603102023\-4](/bulletins/10232975.md), 2023-03-18, Service bulletin: ENGINE AND ENGINE COOLING. Warranty Extension \- Under certain circumstances, after coming to a stop and the idle stop feature engages, the vehicle may not automatically restart.

JSON: [/v1/bulletins/10242571](/v1/bulletins/10242571)

[Report an error on this page](https://github.com/wenmar-pro/wenmar-open/issues/new?template=data_correction.yml&title=Data%20correction%3A%20Service%20bulletin%20ONL6BN09142023&page=https%3A%2F%2Fopen.wenmarpro.com%2Fbulletins%2F10242571&vehicle=Service%20bulletin%20ONL6BN09142023)