# Service bulletin SSM 51294

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

- Type: Service bulletin
- NHTSA id: 10230796
- Published by NHTSA: 2023\-01\-31
- Manufacturer's number: SSM 51294
- Manufacturer's date: 2023\-01\-11
- NHTSA component: ENGINE AND ENGINE COOLING

## NHTSA's summary

Some 2016\-2019 F\-Super Duty/F\-650/F\-750 vehicles equipped with a 6.7L engine may require the lower intake manifold to be removed for various concerns. The WSM, Section 303\-01, has been updated to remove the lower intake manifold leaving the crankcase vent oil separator attached. Both parts should be removed from the engine together to avoid discarding and replacing the crankcase vent oil separator.

## The document

- [NHTSA's copy of the document (PDF)](https://static.nhtsa.gov/odi/tsbs/2023/MC-10230796-0001.pdf)
- [If that address does not open, try this one](https://static.nhtsa.gov/odi/tsbs/2023/MC-10230796-9999.pdf)

The document is the manufacturer's. This site does not hold it.

## Components

Engine

## Vehicles listed

- 2016 to 2019 FORD F\-250 SD
- 2016 to 2019 FORD F\-350 SD
- 2016 to 2019 FORD F\-450 SD
- 2016 to 2019 FORD F\-550 SD
- 2016 to 2019 FORD F\-650 SD
- 2016 to 2019 FORD F\-750 SD

## Recalls for the same vehicles and component

- [19V278000](/recalls/nhtsa/19V278000.md), 2019-04-08: ENGINE; EQUIPMENT:ELECTRICAL
- [18V894000](/recalls/nhtsa/18V894000.md), 2018-12-18: ENGINE

## Other bulletins for the same vehicles and component

- [26E02](/bulletins/11036559.md), 2026-09-01, Other: UNKNOWN OR OTHER; ENGINE. NEW VEHICLE DELIVERY HOLD Emissions Recall 26E02 Certain 2016\-2019 F\-650 \- 750 and 2017\-2019 F\-350 \- 550 Vehicles Equipped With 6.7L Diesel Engines Crankcase Ventilation \(CCV\) Inspection And Replacement
- [26N03](/bulletins/11036547.md), 2026-09-01, Other: ENGINE; UNKNOWN OR OTHER. Customer Satisfaction Program 26N03 Certain 2017\-2019 Model Year Super Duty Vehicles w/ 6.7L Diesel Engines Diesel Particulate Filter Replacement, If Required After Dealer Evaluation
- [SSM 55098](/bulletins/11036338.md), 2026-08-25, Service bulletin: UNKNOWN OR OTHER; POWER TRAIN; ENGINE. Some 2013\-2016 Super Duty vehicles equipped with a 6.7L diesel engine and 2015\-2019 Transit vehicles equipped with a 3.2L diesel engine may not pass a state smog test due to the exhaust gas system \(EGS\) monitor that will not run after completing the exhaust gas sensor drive cycle located within Section 2 of the Powertrain Control/Emissions Diagnostics \(PC/ED\) Manual \> Drive Cycles. This may be due to the vehicles diesel oxidation catalyst \(DOC\) age counter being under the 120\-minute age requirement. There is an all\-new "PCM Catalytic Converter Age Evaluation" application within the latest version of the Ford Diagnosis and Repair System \(FDRS\). Use this new FDRS application to determine the age \(in minutes\) of the DOC. If the age is less than 120 minutes, perform manual regenerations to increase the catalyst age counter to satisfy the monitor age requirement. If further assistance is needed, contact the technical assistance center \(TAC\). Note: this article only applies to the EGS monitor. Problems with other vehicle monitors not running successfully must be addressed using normal diagnostics located i
- [SSM 54690](/bulletins/11030810.md), 2026-04-06, Service bulletin: ENGINE. Some 2013\-2016 Super Duty vehicles equipped with a 6.7L diesel engine and 2015\-2019 Transit vehicles equipped with a 3.2L diesel engine may not pass a state smog test due to the exhaust gas system \(EGS\) monitor that will not run after completing the Exhaust Gas Sensor drive cycle located within Section 2 of the Powertrain Control/Emissions Diagnostics \(PC/ED\) Manual \> Drive Cycles. This may be due to the vehicles diesel oxidation catalyst \(DOC\) age counter being under the 120\-minute requirement. Engineering is investigating this issue and working on a solution.
- [24L05](/bulletins/11023852.md), 2025-10-03, Other: ENGINE; UNKNOWN OR OTHER. Certain 2011\-2022 Model Year Super Duty Vehicles Equipped with 6.7L Engine \- Emission Control Information Label Update for Qualified Vehicles
- [24L04](/bulletins/11023851.md), 2025-10-03, Other: UNKNOWN OR OTHER; ENGINE. Certain 2017 and 2020\-2022 Model Year Super Duty Vehicles Equipped with 6.7L Engine \- Emission Control Information Label Update
- [24L04](/bulletins/11022379.md), 2025-09-03, Other: UNKNOWN OR OTHER; ENGINE. Certain 2017 and 2020\-2022 Model Year Super Duty Vehicles Equipped with 6.7L Engine \- Emission Control Information Label Update
- [24L05](/bulletins/11022355.md), 2025-09-03, Other: ENGINE; UNKNOWN OR OTHER. Certain 2011\-2022 Model Year Super Duty Vehicles Equipped with 6.7L Engine \- Emission Control Information Label Update for Qualified Vehicles
- [SSM 52335](/bulletins/10251952.md), 2024-03-20, Service bulletin: ENGINE AND ENGINE COOLING. For 2015\-2024 Ford and Lincoln vehicles equipped with turbocharged engines and customer concern of an engine oil leak, refer to Workshop Manual \(WSM\), Section 303\-00 for oil leak inspection and testing methods. Ford has evaluated turbochargers replaced for oil leak symptoms and although oil may collect on the external surface of a turbocharger, it is extremely rare for a turbocharger assembly to be the root cause of the oil leak. Careful inspection of the turbocharger oil feed and drain tubes should be performed along with the recommended WSM procedures as needed. Warranty claims for turbocharger replacement going forward will be assessed.
- [TSB 22\-2248](/bulletins/10251453.md), 2024-03-07, Service bulletin: ENGINE AND ENGINE COOLING. This article supersedes TSB 22\-2201 to update the Service Procedure and Parts List. Some 2015\-2019 F\-Super Duty and 2016\-2019 F\-650/F\-750 vehicles equipped with a 6.7L engine may exhibit an oil leak from the oil filter, crankcase vent oil separator, oil cooler, or upper/lower oil pan. This may be due to the mating surfaces of the upper oil pan and the engine block or to a clogged crankcase vent oil separator.

JSON: [/v1/bulletins/10230796](/v1/bulletins/10230796)

[Report an error on this page](https://github.com/wenmar-pro/wenmar-open/issues/new?template=data_correction.yml&title=Data%20correction%3A%20Service%20bulletin%20SSM%2051294&page=https%3A%2F%2Fopen.wenmarpro.com%2Fbulletins%2F10230796&vehicle=Service%20bulletin%20SSM%2051294)