# Service bulletin Parts

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

- Type: Service bulletin
- NHTSA id: 10221561
- Published by NHTSA: 2022\-09\-26
- Manufacturer's number: Parts
- Manufacturer's date: 2016\-07\-27
- NHTSA component: BACK OVER PREVENTION

## NHTSA's summary

Transmission, Valve Body, Clutch Pack If the vehicle you are repairing exhibits a chirp noise during a 3\-4 upshift or a 4\-5 upshift please call Jian Zhu on his cell \(248\) 379\-1132 prior to replacing the component. Engineering would like to visit a dealers located in the SE Michigan area with a vehicle exhibiting the above complaint. If Jian cannot be reached within 15 minutes proceed with the repair.

## The document

- [NHTSA's copy of the document (PDF)](https://static.nhtsa.gov/odi/tsbs/2016/MC-10221561-0001.pdf)
- [If that address does not open, try this one](https://static.nhtsa.gov/odi/tsbs/2016/MC-10221561-9999.pdf)

The document is the manufacturer's. This site does not hold it.

## Components

Driver assistance, Backup camera

## Vehicles listed

- 2015 RAM 2500

## Other bulletins for the same vehicles and component

- [0809614](/bulletins/10231978.md), 2023-02-21, Service bulletin: VISIBILITY; BACK OVER PREVENTION. Uconnect Access Buttons On The Rear View Mirror Are Inoperative
- [S1623000028 Rev.](/bulletins/10231735.md), 2023-02-13, Service bulletin: VEHICLE SPEED CONTROL; BACK OVER PREVENTION; POWER TRAIN; VISIBILITY; PARKING BRAKE. Outside Power Fold Rearview Mirror Noise Or Loose At Pivot. Mirror Contacts Door Window Glass In The Folded Position.
- [S1625000003 Rev.](/bulletins/10231712.md), 2023-02-13, Service bulletin: BACK OVER PREVENTION; EXTERIOR LIGHTING. Malfunction Indicator Lamp \(MIL\) Illumination. NOx Sensor Diagnostic Trouble Codes \(DTCs\) Diagnosis Information.
- [2500115](/bulletins/10229248.md), 2023-01-09, Service bulletin: BACK OVER PREVENTION; FUEL SYSTEM, GASOLINE. Diesel Exhaust Fluid \(DEF\) Level Gauge Inaccurate Or Stuck This bulletin involves verifying the correct DEF level in the tank and if necessary, replacing the DEF pump module. A small number of customers may comment that their DEF level gauge is stuck for long periods of time or is erratic. The customer may also experience a Malfunction Indicator Lamp \(MIL\) illumination. Upon further investigation a technician may find one or more of the following Diagnostic Trouble Codes \(DTCs\). ? P203B \- Reductant Level Sensor Circuit Performance ? P203C \- \(Diesel Exhaust Fluid\) Reductant Level Sensor Circuit Low. ? P203D \- \(Diesel Exhaust Fluid\) Reductant Level Sensor Circuit High.
- [2200215](/bulletins/10229197.md), 2023-01-09, Service bulletin: ELECTRICAL SYSTEM; EXTERIOR LIGHTING; SERVICE BRAKES, HYDRAULIC; BACK OVER PREVENTION. Service Tire Pressure System Message This bulletin involves inspecting and replacing the Tire Pressure Module \(TPM\) sensor if required. The customer may notice a message ?Service Tire Pressure System? displayed on the cluster. On further inspection the technician may find the following Diagnostic Trouble Codes \(DTCs\): NOTE: The cluster will always display the low tire indicator if the tire pressure is under specification, or if there is a DTC set in the TPM system. If a DTC is set, the indicator will flash for 75 seconds and then stay on solid when the vehicle is started. ? C1501\-07 Tire Pressure Sensor 1 \- Mechanical Failure. ? C1501\-31 Tire Pressure Sensor 1 \- No Signal. ? C1502\-07 Tire Pressure Sensor 2 \- Mechanical Failure. ? C1502\-31 Tire Pressure Sensor 2 \- No Signal. ? C1503\-07 Tire Pressure Sensor 3 \- Mechanical Failure. ? C1503\-31 Tire Pressure Sensor 3 \- No Signal. ? C1504\-07 Tire Pressure Sensor 4 \- Mechanical Failure. ? C1504\-31 Tire Pressure Sensor 4 \- No Signal.
- [1807622](/bulletins/10228032.md), 2022-12-19, Service bulletin: POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE \(TCM/PCM/TECM\); FUEL SYSTEM, GASOLINE; POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE; ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE \(ECU/ECM\); EXTERIOR LIGHTING; ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE \(ECU/ECM\):SOFTWARE; FUEL SYSTEM, DIESEL; SERVICE BRAKES, HYDRAULIC; BACK OVER PREVENTION. Flash: Powertrain Control Module \(PCM\) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain ControlModule \(ECM/PCM\) with the latest available software. Customers may experience a Malfunction Indicator Lamp \(MIL\) illumination. Upon further investigation a technician may find one or more of thefollowing DTCs have been set: P064F \- Unauthorized Software/Calibration Detected. P202E \- \(Diesel Exhaust Fluid\) Reductant Injector Performance. P24A5 \- EGR Cooler Bypass Bank 1 Control Stuck. P1C55 \- NOx Sensor Intermittent ? Bank 1 Sensor 1. P0301 \- Cylinder 1 Misfire. P0302 \- Cylinder 2 Misfire. P0303 \- Cylinder 3 Misfire. P0304 \- Cylinder 4 Misfire. P0305 \- Cylinder 5 Misfire. P0306 \- Cylinder 6 Misfire. P020A \- Fuel Injector 1 Performance. P020B \- Fuel Injector 2 Performance. P020C \- Fuel Injector 3 Performance. P020D \- Fuel Injector 4 Performance. P020E \- Fuel Injector 5 Performance. P020F \- Fuel Injector 6 Performance. U0001 \- Can C Bus. P1451 \- Diesel Particulate Filter System Performance. P229E \- NOx Sensor Circuit \- Bank 1 Sensor 2. P218F \- Reductant No Flow Detected. P242F \- Diesel Particulate Filter Restriction \- Ash Accumulation. P205E \- \(Diesel Exhaust Fluid\) Reductant Tank Temperature Sensor CircuitIntermittent \(setting when the block heater is plugged in\). U110E \- Lost Ambient Temperature Message. P20E8 \- \(Diesel Exhaust Fluid\) Reductant Pressure Too Low. P2281 \- Air Leak Between MAF And Throttle Body. P1477 \- Intake Air Diverter Valve Position Sensor Circuit Shorted To Ground. U1421 \- Implausible Ignition Key Off Time Received. P026B \- Injection Timing Performance. In addition, the following software enhancements are also available: A/C pressure sensor update. Improvements made to reduce misfire. wiTECH engine cooling fan actuation test update. Improved Exhaust Gas Recirculation \(EGR\) valve response. Over Running Clutch \(ORC\) software improvement. Unpleasantodor in the vehicle at low speeds during regeneration cycle.
- [9003319](/bulletins/10224685.md), 2022-10-24, Service bulletin: ELECTRICAL SYSTEM; BACK OVER PREVENTION; POWER TRAIN; ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO/SUPERCHARGER. Turbocharger, Turbo Speed Sensor, Turbo Gaskets and Seals 1. Do Not Replace Turbocharger for Exhaust Brake Operation Complaints. Do not replace the turbocharger for complaints of exhaust brake operating when the Exhaust Brake switch is off. Replacing the turbocharger will not address these complaints. Update the PCM with the new software version to correct this issue. 2. Turbo Speed Sensor is Now Serviceable. If a Turbocharger Speed Sensor is being replaced for a P2580 or any other reason, the Turbo Speed Sensor is now available separate from the Turbocharger Kit. do not replace the entire Turbocharger Kit. 2013\-2015 Chassis Cab or Pickup \- PN 68210095A$ 2007\-2012 Chassis Cab or Pickup \- PN 68039104A$. 3. Replace Exhaust Gaskets with Turbocharger Removal.\~ If turbocharger is removed/replaced, the following items are not reusable and must be replaced: Turbocharger Gasket Turbocharger Outlet Seal Turbocharger Band Clamp If the front exhaust pipe is removed/replaced, the following items are not reusable and must be replaced. Turbocharger Outlet Seal Turbocharger Band Clamp
- [22\-002\-15](/bulletins/10221531.md), 2022-09-26, Service bulletin: SERVICE BRAKES; EXTERIOR LIGHTING; ELECTRICAL SYSTEM; BACK OVER PREVENTION. Service Tire Pressure System Message This bulletin involves inspecting and replacing the Tire Pressure Module \(TPM\) sensor if required. The customer may notice a message ?Service Tire Pressure System? displayed on the cluster. On further inspection the technician may find the following Diagnostic Trouble Codes \(DTCs\): NOTE: The cluster will always display the low tire indicator if the tire pressure is under specification, or if there is a DTC set in the TPM system. If a DTC is set, the indicator will flash for 75 seconds and then stay on solid when the vehicle is started. ? C1501\-07 Tire Pressure Sensor 1 \- Mechanical Failure. ? C1501\-31 Tire Pressure Sensor 1 \- No Signal. ? C1502\-07 Tire Pressure Sensor 2 \- Mechanical Failure. ? C1502\-31 Tire Pressure Sensor 2 \- No Signal. ? C1503\-07 Tire Pressure Sensor 3 \- Mechanical Failure. ? C1503\-31 Tire Pressure Sensor 3 \- No Signal. ? C1504\-07 Tire Pressure Sensor 4 \- Mechanical Failure. ? C1504\-31 Tire Pressure Sensor 4 \- No Signal.
- [0805316B](/bulletins/10220438.md), 2022-09-26, Service bulletin: BACK OVER PREVENTION. Radio software enhancement.
- [08\-019\-17 REV. A](/bulletins/10219892.md), 2022-09-15, Service bulletin: AIR BAGS; BACK OVER PREVENTION; PARKING BRAKE; ELECTRICAL SYSTEM. RG3 RG4 RJ3 RJ4 Radio Enhancements This bulletin involves inspecting and if required, updating the radio software. A small number of customers may experience one or more of the following:Navigation failed message is displayed \(WK and KL with RG3 and RG4\). The clock not automatically updating to local time \(WK and KL with RG3 and RG4\). Poor or no connection to cellular network \(WK and KL with RG3 and RG4\). HVAC temperature out of sync with radio display \(KL with RG3 and RG4\). Some Uconnect App remote commands do not execute with the vehicle. Display goes blank/black \(WK and KL with RG3 and RG4\). Cyrillic keyboard is missing in phone book \(WK and KL with RG3 or RG4\). Wrong speed limit on NAV speed camera indication \(WK and KL with RG3 or RG4\). Blind Spot module beep or chime sound may be heard continuously \(KL Only\). Radio may keep the CAN bus network awake, causing a battery drain. Voice Recognition \(VR\) to set temperature, will indicate wrong setting to rear seat temperature. Not possible to set temperature in degrees Celsius using the VR \(UK vehicles only\). Teleprompter does not appear when pressing the VR button. VR operation cancels while in media mode. Radio may display camera?s previous image before displaying the current image. Navigation lost vehicle position during route calculation. Navigation displays are missing after vehicle heading changes. Navigation giving incorrect guidance to exit the highway. FM audio may switch to AM after ignition cycle. Text messages appear as sender?s phone number, not their name. VR phone button may not work at times. Audio muted after AUX device is disconnected. VR ?Listen? to text will only play 1st message. Drive Mode: Eco, Sport or Normal setting may not be saved after key cycle \(LA, LD, LX and ZD Only\). Drive Mode: Shift light On/Off, out of sync \(LA, LD, LX and ZD Only\). Speed adjusted volume may not work. AM/FM seek or tuner soft keys may be missing.

JSON: [/v1/bulletins/10221561](/v1/bulletins/10221561)

[Report an error on this page](https://github.com/wenmar-pro/wenmar-open/issues/new?template=data_correction.yml&title=Data%20correction%3A%20Service%20bulletin%20Parts&page=https%3A%2F%2Fopen.wenmarpro.com%2Fbulletins%2F10221561&vehicle=Service%20bulletin%20Parts)