Service bulletin 0805222
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10220797 |
| Published by NHTSA | 2022-09-26 |
| Manufacturer's number | 0805222 |
| Manufacturer's date | 2022-03-11 |
| NHTSA component | POWER TRAIN; LANE DEPARTURE; PARKING BRAKE; ELECTRICAL SYSTEM; ENGINE AND ENGINE COOLING; BACK OVER PREVENTION; EXTERIOR LIGHTING |
NHTSA's summary
Flash: Hybrid Control Processor (HCP) and Auxiliary Hybrid Control Processor (AHCP) Updates This bulletin involves reprogramming the HCP and AHCP or also known as Power InverterModule (PIM) with the latest available software. Technicians and/or customers may report the vehicle will not pass a state smog check due to permanent fault codes which will not clear.As a result, the vehicles are not eligible to be registered in certain states. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technicianmay find one or more of the following DTCs have been set: P0A33 - Drive Motor B Temperature Sensor 1 Circuit High. P0A2D - Sensor Power Supply 1 Circuit High. P215B - Vehicle Speed Output Shaft Speed Correlation. P0C4A - Drive Motor A Inverter Over Temperature. P0E15 - Hybrid-Ev Battery Pack Coolant Heater A Control Performance. P1AFE - MCPB Improper Shut Down. P1AF8 - MCPA Control Module Shutdown Performance. P0513 - Invalid Skim Key. U151A-87 - Hybrid Control Processor Secret Code-Missing Message. Customers may also experience more or more of the following: The scheduled charging does not occur on desired schedule. Vehicle does not start when pushing ignition switch with no MIL for DTCs P1AFE and P1AF8 (pending DTCs). Vehicle does not start when pushing ignition switch with DTCs P0513 and U151-A87 (stored or active). Scheduled charging start/end does not align with displayed time (ex: 12:05 pm end time on radio, but charging ends at 12:06 pm). Scheduled charging does not start following a power outage. Scheduled Cabin Conditioning (SCC) feature will not function properly if they schedule the departure time in between 50 minutes to 480 minutesat extreme cold ambient temps below -24 °C (-11 °F). ?Charge Now? soft button does not always work. The vehicle will get a rough engine spin-down, and then ?Service Charging System? warning and shutdown if the vehicle is quicklyre-cranked after the initial key crank.
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Brakes, Driver assistance, Electrical system, Engine, Lighting, Transmission and driveline, Backup camera, Parking brake
Trouble codes named
P0513, P0A2D, P0A33, P0C4A, P0E15, P1AF8, P1AFE, P215B, U151A
| CHRYSLER PACIFICA | 2021 |
|---|
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 24V436000 | 2024-06-13. BACK OVER PREVENTION: SENSING SYSTEM: CAMERA |
|---|
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| S2208000045 REV.B | 2024-12-11. Service bulletin. Backup Camera Poor Image Quality Inspection |
|---|---|
| 9004452 | 2024-01-08. Service bulletin. CAMERA, Rear View Prior to replacement, please contact FCA Redacted Content. If no response in 15 minutes, proceed with repair. |
| S2108000015 | 2024-01-02. Service bulletin. Uconnect Box Require Service Message |
| S1408000384 | 2024-01-02. Service bulletin. Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC) Inaccurate, Battery Charging Message, Presence of IBS related Diagnostic Trouble Codes (DTCs), or Battery Warning Lamp On |
| 9003357 | 2024-01-02. Service bulletin. ADAPTER, Engine Oil Filter (Pentastar V6) For all 2014MY replace the Oil Filter Adapter (OFA). For any other MY (with mileage above 30,000) review and follow instructions from STAR Online S1809000007 REV. C available on Dealer Connect. Also, consider the following: 1) Remove OFA 2) Replace only the oil inlet O-ring and gaskets (seals kit in SOL above). 3) Re-install the OFA. For 2023MY and beyond use black O-ring. For 2022MY and prior use red O-ring. Note: When replacing OFA, it may be necessary to transfer the Oil Temp/Pressure Sensor from the old OFA to the new OFA. |
| S238A000047 | 2023-12-18. Service bulletin. Humming Noise Through Speakers While Vehicle Is Off |
| 9004452 | 2023-10-30. Service bulletin. CAMERA, Rear View Prior to replacement, please contact FCA Redacted Content. If no response in 15 minutes, proceed with repair. |
| 9100133 | 2023-07-31. Service bulletin. ROCKER ARM ASSY - ROLLER ROCKER Case 1.- Before replacing the intake or exhaust rocker arms due to an abnormal ticking noise, please check that the INTAKE Hydraulic Lash Adjusters are not "collapsed". If a collapsed INTAKE HLA is found, replace all INTAKE HLAs on the suspect cylinder head (no need to replace rocker arms). The noise can occur at low or high RPMs, and at low or high temperatures. There are no Diagnostic Trouble Codes (DTC)s present. Case 2.- If the INTAKE camshaft or INTAKE rocker arm has excessive wear on the high lift profile (Rocker arm: slider, Camshaft: central lobe), replace the intake camshaft (1) in that cylinder head and all intake rocker arms (6). |
| S1623000028 Rev. | 2023-02-13. Service bulletin. Outside Power Fold Rearview Mirror Noise Or Loose At Pivot. Mirror Contacts Door Window Glass In The Folded Position. |
| S2108000170 | 2023-01-17. Service bulletin. Head unit button stuck DTC code B14DA-2A |