Service bulletin 18-037-14
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10218212 |
| Published by NHTSA | 2022-08-22 |
| Manufacturer's number | 18-037-14 |
| Manufacturer's date | 2014-11-19 |
| NHTSA component | EXTERIOR LIGHTING; FUEL SYSTEM, GASOLINE |
NHTSA's summary
Flash: 6.4L Powertrain Diagnostic And System Improvements For MIL Illumination This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the Technician may find that the following Diagnostic Trouble Code has been set: ? P2096 - Downstream Fuel Trim System 1 Lean. ? P2097 - Downstream Fuel Trim System 1 Rich. ? P2098 - Downstream Fuel Trim System 2 Lean. ? P2099 - Downstream Fuel Trim System 2 Rich. ? P0300 - Multiple Cylinder Misfire (set during engine warm-up)
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Fuel system, Lighting
Trouble codes named
P0300, P2096, P2097, P2098, P2099
| DODGE CHALLENGER | 2014 |
|---|
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 0815223 | 2023-08-21. Service bulletin. Fuel Pump Connector Replacement The technician may experience a crank/no start after the fuel pump module was replaced. This bulletin involves replacing the fuel pump connector harness (pigtail) when replacing the fuel pump module. |
|---|---|
| 9003704 | 2022-09-26. Service bulletin. Transmission Oil Pan, Heater (TMU), Tube or O-ring Applies to vehicles equipped with 8 speed transmissions only; if you have a leak that appears to be at the pan the use of proper leak detection is recommended. The fluid in the 8 speeds can be detected with a black light and there are aftermarket spray on leak detection materials to help ensure that the leak is properly diagnosed and not from another location such as cooler lines, heater tubes, or case porosity. Please note that the transmission pan gasket is available for many of the 8 speed applications FCA offers. Please review the available quick connect and transfer tube parts, as replacement of the TMU may not be required. If a TOC line connection is found to be the source, the quick connect may need replacement. If the leak source is coming from the connection of the TMU to the transmission, the transfer tube may need replacement. When parts are returned to the QEC the retaining clips (snap ring) for the quick disconnect fittings are missing. (This leaves a question as to whether the clips were missing from the assembly plant, or the technician removed them in order to make line removal easier.) Please return the clips with the transmission heater and note if they were not there to begin with. For any questions regarding transmission heater, contact FCA Redacted Content. If no response in 15 minutes, proceed with repair. |
| S2208000131 | 2022-09-26. Service bulletin. No Start Condition After A Fuel Pump Replacement, Multiple Fuel System Level Related DTC?s Setting |
| 9003694 | 2022-08-08. Service bulletin. Oil Pump Assembly If error code P06DD present on any Pentastar V6 application, please inspect oil pump for relief valve failure. See photo attached. If valve is found out of place please call Bob Jackson (248) 944-0466 bob.jackson@fcagroup.com, or Joe Lovell (734) 309-6467 joe.lovell@fcagroup.com before proceeding. If unable to reach after 15 minutes record the following information and proceed with oil pump replacement and hold part for return to FCA via Fastrack system |
| 18-039-15 REV. A | 2022-08-08. Service bulletin. Flash: 6.4L Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module with the latest available software. A small number of customers may experience one or more of the following conditions: ? With the cluster set on metric units, they are unable to accurately increase or decrease the cruise control set speed using the resume or set buttons. Instead of changing vehicle speed by 1 KPH when pressing the buttons, the vehicle speed will increase approximately 1.6 KPH. ? Potential gear hunting during cruise operation at lower vehicle speeds (25-40 mph). In addition, a small number of customers with manual transmission equipped vehicles may experience certain symptoms/conditions or a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the Technician may find that the following Diagnostic Trouble Code has been set: ? P2096 - Downstream Fuel Trim System 1 Lean. (LC vehicles with Sales Code ESH with a manual transmission (Sales Code DEC). ? P2097 - Downstream Fuel Trim System 1 Rich. (LC vehicles with Sales Code ESH with a manual transmission (Sales Code DEC). ? P2098 - Downstream Fuel Trim System 2 Lean. (LC vehicles with Sales Code ESH with a manual transmission (Sales Code DEC). ? P2099 - Downstream Fuel Trim System 2 Rich. (LC vehicles with Sales Code ESH with a manual transmission (Sales Code DEC). ? P0300 - Multiple Cylinder Misfire (set during engine warm-up) (LC vehicles with Sales Code ESH with a manual transmission [Sales Code DEC]). |
| 18-039-15 REV. A | 2022-07-25. Service bulletin. Flash: 6.4L Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module with the latest available software. A small number of customers may experience one or more of the following conditions: ? With the cluster set on metric units, they are unable to accurately increase or decrease the cruise control set speed using the resume or set buttons. Instead of changing vehicle speed by 1 KPH when pressing the buttons, the vehicle speed will increase approximately 1.6 KPH. ? Potential gear hunting during cruise operation at lower vehicle speeds (25-40 mph). In addition, a small number of customers with manual transmission equipped vehicles may experience certain symptoms/conditions or a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the Technician may find that the following Diagnostic Trouble Code has been set: ? P2096 - Downstream Fuel Trim System 1 Lean. (LC vehicles with Sales Code ESH with a manual transmission (Sales Code DEC). ? P2097 - Downstream Fuel Trim System 1 Rich. (LC vehicles with Sales Code ESH with a manual transmission (Sales Code DEC). ? P2098 - Downstream Fuel Trim System 2 Lean. (LC vehicles with Sales Code ESH with a manual transmission (Sales Code DEC). ? P2099 - Downstream Fuel Trim System 2 Rich. (LC vehicles with Sales Code ESH with a manual transmission (Sales Code DEC). ? P0300 - Multiple Cylinder Misfire (set during engine warm-up) (LC vehicles with Sales Code ESH with a manual transmission [Sales Code DEC]). |
| 18-039-20 | 2020-05-26. Service bulletin. Possible Driveability Issues due to the Winter-Blend Fuel into the Warmer Season |
| UB4 Rev. 6 | 2020-05-26. Service bulletin. Emissions Recall UB4 Evaporative Emissions Canister |
| UB4 Rev. 5 | 2020-04-27. Service bulletin. Revised Emissions Recall UB4 Evaporative Emissions Canister |
| 18-094-16 | 2018-06-11. Service bulletin. Flash: Powertrain Diagnostic And System Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience one or more of the following conditions: With the cluster set on metric units, they are unable to accurately increase or decrease the cruise control set speed using the resume or set buttons. Instead of changing vehicle speed by 1 kph when pressing the buttons, the vehicle speed will increase approximately 1.6 kph. Potential gear hunting during cruise operation at lower vehicle speeds 40-64 kph (25-40 mph). In addition, a small number of customers may experience certain symptoms/conditions or a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Codes have been set: P1115 - General Temperature Rationality. P0456 - EVAP System Small Leak. P0441 - EVAP Purge System Performance. P2610 - PCM Internal Engine Off Timer Performance. P0300 - Multiple Cylinder Misfire. P0301 - Cylinder 1 Misfire. P0302 - Cylinder 2 Misfire. P0303 - Cylinder 3 Misfire. · P0304 - Cylinder 4 Misfire. · P0305 - Cylinder 5 Misfire. · P0306 - Cylinder 6 Misfire. · P0307 - Cylinder 7 Misfire. · P0308 - Cylinder 8 Misfire. · P0335 - Crankshaft Position Sensor Circuit. · P0122 - Throttle Position Sensor 1 Circuit Low. · P0123 - Throttle Position Sensor 1 Circuit High. · P0222 - Throttle Position Sensor 2 Circuit Low. · P0223 - Throttle Position Sensor 2 Circuit High. · P2299 - Brake Pedal Position / Accelerator Pedal Position Incompatible.** · P2096 - Downstream Fuel Trim System 1 Lean. (LC vehicles with Sales Code ESH with a manual transmission (Sales Code DEC). · P2097 - Downstream Fuel Trim System 1 Rich. (LC vehicles with Sales Code ESH with a manual transmission (Sales Code DEC). · P2098 - Downstream Fuel Trim System 2 Lean. (LC vehicles with Sales Code ESH with a ma |