Service bulletin TSB_ENG240_R1

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
Type	Service bulletin
NHTSA id	10215668
Published by NHTSA	2022-07-19
Manufacturer's number	TSB_ENG240_R1
Manufacturer's date	2022-07-12
NHTSA component	ENGINE AND ENGINE COOLING

NHTSA's summary

TECHNICAL SERVICE BULLETIN: SERVICE ACTION: OIL FILTER AND COOLER HOUSING O-RING GASKET REPLACEMENT (SA500) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information to replace the oil filter and cooler O-ring gaskets on some 2022MY Carnival (KA4) vehicles produced from September 27, 2021 through January 27, 2022, which may exhibit oil leakage due to poor sealing of the oil filter and cooler assembly O-ring gaskets.

The document

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Engine

Vehicles listed
KIA CARNIVAL	2022

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Other bulletins for the same vehicles and component
SC290_TSB	2024-05-15. Emissions. TECHNICAL SERVICE BULLETIN: VOLUNTARY EMISSIONS SERVICE CAMPAIGN: LAMBDA-III 3.5L GDI ENGINE DTC P00B7 ECM LOGIC IMPROVEMENT (SC290) - This bulletin provides the procedure to update the software logic of the Engine Control Module (ECM) system on some 2022-2024MY Carnival (KA4) vehicles produced from January 4, 2021 through November 6, 2023. The subject vehicles may have engine calibrations that were not optimized for emissions standards under certain specific conditions, which may cause the vehicle to release air pollution which exceed Federal and California standards. As a result, the subject vehicles may exhibit an illumination of Malfunction Indicator Lamp (MIL) with DTC P00B7.
SC290_OWNR	2024-05-15. Emissions. VOLUNTARY EMISSIONS SERVICE CAMPAIGN: OWNER NOTIFICATION (SC290) - This document is the owner notification advising that Kia is conducting a Voluntary Emissions Service Campaign to improve the emissions logic in the Electronic Control Module (ECM) to ensure compliance with emissions regulations.
TSB_FUE062_R2	2024-04-03. Service bulletin. TECHNICAL SERVICE BULLETIN: SERVICE ACTION: ECM LOGIC UPDATE FOR DTC P2118 AND THROTTLE BODY FREEZING (SA514) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to update the software logic of the Engine Control Module (ECM) system on some 2022-2024MY Carnival (KA4) vehicles produced from January 4, 2021 through November 6, 2023, which may exhibit an MIL "ON" with DTC P2118. The throttle body plate may freeze after a cold soak in very cold temperatures, possibly causing the vehicle to go into "limp-home" mode. Once the vehicle is warmed up, the throttle body performs normally.
TSB_FUE062_R1	2024-03-02. Service bulletin. TECHNICAL SERVICE BULLETIN: SERVICE ACTION: ECM LOGIC UPDATE FOR DTC P2118 AND THROTTLE BODY FREEZING (SA514) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides the procedure to update the software logic of the Engine Control Module (ECM) system on some 2022-2024MY Carnival (KA4) vehicles produced from January 4, 2021 through October 26, 2022, which may exhibit an MIL "ON" with DTC P2118. The throttle body plate may freeze after a cold soak in very cold temperatures, possibly causing the vehicle to go into "limp-home" mode. Once the vehicle is warmed up, the throttle body performs normally.
TSB_ENG219_R1	2022-09-30. Service bulletin. TECHNICAL SERVICE BULLETIN: MAINTENANCE REMINDER FEATURE - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area.This bulletin provides information on setting the "Service Interval Reminder" feature available on most 2014-2023MY Kia vehicles (refer to model list on page 2). If the service interval reminder is set, the customer will be informed to have the next maintenance service performed, which can positively affect vehicle longevity and performance. Refer to TSB ENG241 for 2023MY~ vehicles equipped with the Oil Life Management System (OLMS) feature not included in table on page 2.
TSB_ENG240	2022-07-02. Service bulletin. TECHNICAL SERVICE BULLETIN: SERVICE ACTION: OIL FILTER AND COOLER HOUSING O-RING GASKET REPLACEMENT (SA500) - This bulletin provides information to replace the oil filter and cooler O-ring gaskets on some 2022MY Carnival (KA4) vehicles produced from September 27, 2021 through January 27, 2022, which may exhibit oil leakage due to poor sealing of the oil filter and cooler assembly O-ring gaskets.
TSB_ENG231_R1	2021-12-23. Service bulletin. TECHNICAL SERVICE BULLETIN: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC22) - This bulletin has been revised to include additional information. New/revised sections of this bulletin are indicated by a black bar in the margin area. This bulletin provides information related to extracting "in use performance tracking" emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting.
TSB_ENG231	2021-10-02. Service bulletin. TECHNICAL SERVICE BULLETIN: DATA COLLECTION: EXTRACT CALIFORNIA EMISSIONS DATA FROM ECU (DC22) - This bulletin provides information related to extracting "in use performance tracking" emissions data from the Engine Control Unit (ECU) of certain vehicles sold in California. The California Air Resources Board (CARB) requires the emissions data from vehicles with a minimum of 3,000 accumulated miles without reprogramming or resetting.