Service bulletin 18-018-13 REV. A
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10189193 |
| Published by NHTSA | 2021-03-22 |
| Manufacturer's number | 18-018-13 REV. A |
| Manufacturer's date | 2013-06-29 |
| NHTSA component | POWER TRAIN; SERVICE BRAKES, HYDRAULIC; BACK OVER PREVENTION; EXTERIOR LIGHTING; FUEL SYSTEM, GASOLINE; FUEL SYSTEM, DIESEL; ELECTRICAL SYSTEM |
NHTSA's summary
Flash: Diagnostic and System Improvements This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Several software improvements are available for vehicles equipped with a Cummins 6.7L turbo Diesel. Prevent Or Reduce Unnecessary Malfunction Indicator Lamp (MIL) Illumination For The Following Transmission Faults. These Faults Are Currently Tripped As A One Trip Fault And Should Have Been A Two Trip Fault: ? P0711 - TRANSMISSION TEMPERATURE SENSOR PERFORMANCE ? P0712 - TRANSMISSION TEMPERATURE SENSOR LOW ? P0713 - TRANSMISSION TEMPERATURE SENSOR HIGH ? P0714 - TRANSMISSION TEMPERATURE SENSOR INTERMITTENT ? P0740 - TCC OUT OF RANGE ? P0869 - LINE PRESSURE HIGH ? P0933 - HYDRAULIC PRESSURE SENSOR RANGE/PERFORMANCE ? P0934 - LINE PRESSURE SENSOR CIRCUIT LOW ? P0935 - LINE PRESSURE SENSOR CIRCUIT HIGH ? P1775 - SOLENOID SWITCH VALVE LATCHED IN TCC POSITION ? P1776 - SOLENOID SWITCH VALVE LATCHED IN LR POSITION ? U0100 - LOST COMMUNICATION WITH ECM/PCM ? U0002 - CAN C BUS OFF PERFORMANCE - BUS OFF Improvements To Prevent Or Reduce Unnecessary Malfunction Indicator Lamp (MIL) Illumination For: ? P026A - CHARGE AIR COOLER EFFICIENCY BELOW THRESHOLD ? P0544 - EXHAUST GAS TEMPERATURE SENSOR CIRCUIT - BANK 1 SENSOR 1 ? P0562 - BATTERY VOLTAGE LOW ? P20EE - SCR NOx CATALYST EFFICIENCY BELOW THRESHOLD - BANK 1 ? P2201 - AFTERTREATMENT NOx SENSOR CIRCUIT PERFORMANCE - BANK 1 SENSOR 1 ? P2281 - AIR LEAK BETWEEN MAF AND THROTTLE BODY ? P24A5 - EGR COOLER BYPASS BANK 1 CONTROL STUCK ? P2459 - DIESEL PARTICULATE FILTER REGENERATION TOO FREQUENT ? P249E - CLOSED LOOP SCR REDUCTANT INJECTION CONTROL AT LIMIT - FLOW TOO HIGH Other Updates: ? With the ignition in the ?Run? position, engine not running, a small number of customers may experience a message in the Vehicle Information Center that states ?Service Exhaust System - see dealer? erroneously. ? Add engine run time t
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Brakes, Driver assistance, Electrical system, Fuel system, Lighting, Transmission and driveline, Backup camera
Trouble codes named
P026A, P0544, P0562, P0711, P0712, P0713, P0714, P0740, P0869, P0933, P0934, P0935, P1775, P1776, P20EE, P2201, P2281, P2459, P249E, P24A5, U0002, U0100
| RAM 2500 | 2013 |
|---|---|
| RAM 3500 | 2013 |
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| S1623000028 Rev. | 2023-02-13. Service bulletin. Outside Power Fold Rearview Mirror Noise Or Loose At Pivot. Mirror Contacts Door Window Glass In The Folded Position. |
|---|---|
| S1625000003 Rev. | 2023-02-13. Service bulletin. Malfunction Indicator Lamp (MIL) Illumination. NOx Sensor Diagnostic Trouble Codes (DTCs) Diagnosis Information. |
| 0801615 | 2023-01-09. Service bulletin. Poor Radio Reception This bulletin involves replacing the satellite antenna if needed. A customer may experience, SXM (Sirius/XM) radio has intermittent muting. This occurs in areas where XM signal is degraded and cell signal is very weak. The condition happens when the optional vehicle internet connection through the cell network is in use with the internal vehicle Wi-Fi. This Symptom/Condition Only Applies To 2014-2015 KL Vehicles: A customer may experience a popping noise when listening to AM stations. |
| 0807117 | 2022-10-24. Service bulletin. This bulletin involves inspecting and updating the radio software, if required. A customer may experience one or more of the following conditions. Navigation Failed? message is displayed. Navigation is inoperative or inaccurate. CD player will not play songs and/or locks up the radio. Clock will not automatically update to local time. Clock may be off by several hours. (RA3 Only). HVAC temperature out of sync with radio display (KL vehicles). Some Uconnect App remote commands do not execute with the vehicle. Radio Apps are inoperative. Adds Apple Siri® Eyes Free capability for iPhone® owners. Auto Play can now be configured. Radio will lock up. Radio display screen is black or blank. Battery drain - due to radio remains on. HVAC temperature out of sync with radio display (KL vehicles). Track names may be displayed twice in USB or SD media modes. SD, USB or BTSA modes may become non-functional for a given ignition cycle. Duplicate song titles may be displayed in USB mode. Last track is displayed but next track is being played. Navigation function may reset itself after using One-Shot VR. Intermittently the Global Positioning System (GPS) may lose its location for a short time and causes routing and positioning concerns. GPS and Internal cellular device may become inoperative and causes a loss of GPS and cellular functions. A false Pop-up message may appear. Vehicle Phone Requires Service? even though the vehicle?s phone works properly. Back-up camera image may be unclear or jittery/stutters at times. Mute button status was not being displayed correctly. Presets where not shown correctly or were deleted. Park Sense tone continuously on. Radio display may show. Please insert USB Stick? Navigation may not start or may lose position. Rear camera may show a black screen for 3 seconds upon going to reverse. iPod would not resume playing after a VR session or phone call. Radio reset, screen lockup, blank screen or sluggish system. |
| 9003319 | 2022-10-24. Service bulletin. Turbocharger, Turbo Speed Sensor, Turbo Gaskets and Seals 1. Do Not Replace Turbocharger for Exhaust Brake Operation Complaints. Do not replace the turbocharger for complaints of exhaust brake operating when the Exhaust Brake switch is off. Replacing the turbocharger will not address these complaints. Update the PCM with the new software version to correct this issue. 2. Turbo Speed Sensor is Now Serviceable. If a Turbocharger Speed Sensor is being replaced for a P2580 or any other reason, the Turbo Speed Sensor is now available separate from the Turbocharger Kit. do not replace the entire Turbocharger Kit. 2013-2015 Chassis Cab or Pickup - PN 68210095A$ 2007-2012 Chassis Cab or Pickup - PN 68039104A$. 3. Replace Exhaust Gaskets with Turbocharger Removal.~ If turbocharger is removed/replaced, the following items are not reusable and must be replaced: Turbocharger Gasket Turbocharger Outlet Seal Turbocharger Band Clamp If the front exhaust pipe is removed/replaced, the following items are not reusable and must be replaced. Turbocharger Outlet Seal Turbocharger Band Clamp |
| 18-091-16 | 2022-09-26. Service bulletin. Flash: Powertrain Diagnostic And System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Codes (DTCs) have been set. Several software improvements are available for the following conditions. The Following DTC has been changed from a two trip fault to a one trip fault: · U1A24 - Lost Communication With Ammonia Sensor. Prevent or reduce MIL illumination when no defect is present for the following DTCs. These faults have been changed from a one trip fault to a two trip fault: · P0201 - P0206 - Fuel Injector X Circuit/Open. · P049D - EGR Control Position Exceeding Learning Limit. · P0711 - Transmission Temperature Sensor Performance. · P0712 - Transmission Temperature Sensor Low. · P0713 - Transmission Temperature Sensor High. · P0714 - Transmission Temperature Sensor Intermittent. · P0740 - TCC Out Of Range. · P0869 - Line Pressure High. · P0933 - Hydraulic Pressure Sensor Range/Performance. · P0934 - Line Pressure Sensor Circuit Low. · P0935 - Line Pressure Sensor Circuit High. · P1775 - Solenoid Switch Valve Latched In TCC Position. · P1776 - Solenoid Switch Valve Latched In LR Position. · U0100 - Lost Communication With ECM/PCM. · U0002 - CAN C Bus Off performance - Bus Off. · **P2281 - Air Leak Between MAF And Throttle Body. · P218F - Reductant No Flow Detected. · P242F - Diesel Particulate Filter Restriction - Ash Accumulation. · P20E8 - (Diesel Exhaust Fluid) Reductant Pressure Too Low. · P202E - Diesel Exhaust Fluid) Reductant Injector Performance. · P209F - Diesel Exhaust Fluid) Reductant Tank Heater Control Circuit Performance. · P218F - Reductant No Flow Detected.** · P205E - (Diesel Exhaust Fluid) Reductant Tank Temperatur |
| 08-016-15 | 2022-09-26. Service bulletin. Poor Radio Reception This bulletin involves replacing the satellite antenna if needed. A customer may experience, SXM (Sirius/XM) radio has intermittent muting. This occurs in areas where XM signal is degraded and cell signal is very weak. The condition happens when the optional vehicle internet connection through the cell network is in use with the internal vehicle Wi-Fi. This Symptom/Condition Only Applies To 2014-2015 KL Vehicles: A customer may experience a popping noise when listening to AM stations. |
| 1803014REVB | 2022-09-26. Service bulletin. Flash: 6.7L Diagnostic and System Improvements This bulletin involves selectively erasing and reprogramming the Powertrain Control Module (PCM) with new software. Several software improvements are available for vehicles equipped with a Cummins 6.7L turbo Diesel.Prevent Or Reduce Malfunction Indicator Lamp (MIL) Illumination When No Defect is Present For The Following Diagnostic Trouble Codes (DTCs). These Faults Have Been Changed From P0201 - P0206 - Fuel Injector X Circuit/Open. P049D - EGR Control Position Exceeding Learning Limit. P0711 - Transmission Temperature Sensor Performance. P0712 - Transmission Temperature Sensor Low. P0713 - Transmission Temperature Sensor High. P0714 - Transmission Temperature Sensor Intermittent. P0740 - TCC Out Of Range. P0869 - Line Pressure High. P0933 - Hydraulic Pressure Sensor Range/Performance. P0934 - Line Pressure Sensor Circuit Low. P0935 - Line Pressure Sensor Circuit High. P1775 - Solenoid Switch Valve Latched In TCC Position. P1776 - Solenoid Switch Valve Latched In LR Position. U0100 - Lost Communication With ECM/PCM. U0002 - CAN C Bus Off performance - Bus Off. U110E - Lost Ambient Temperature Message.The Following DTC Has Been Changed From A Two Trip Fault To One Trip Fault: U1A24 - Lost Communication With Ammonia Sensor.Improvements To Prevent Or Reduce Malfunction Indicator Lamp (MIL) Illumination When No Defect Is Present For: U3017 - Control Module Timer/Clock Performance. P026B - Injection Timing Performance. P0128 - Thermostat Rationality. In cold ambient temperatures. P0087 - Fuel Rail Pressure Too Low. P2281 - Air Leak Between MAF and Throttle Body. U1421 - Implausible Ignition Key Off Time Received. P026A - Charge Air Cooler Efficiency Below Threshold. P04DB - Crankcase Ventilation System Disconnected. P0544 - Exhaust Gas Temperature Sensor Circuit - Bank 1 Sensor 1. P0562 - Battery Voltage Low. P0604 - Internal Control Module RAM Error. P1451 - Diesel Particulate Filter |
| 2101719 | 2022-09-15. Service bulletin. Flash: Transmission Control Module (TCM) Updates This bulletin involves reprogramming the TCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the followingDTC has been set:U1111-00 - Lost Odometer Message(DD, DF, and DP with Diesel Engine Only). In addition, the customer may notice one or more of the following conditions: The customer may notice a harsh 2-3 and/or 3-4 shift(2017 MY D2 with ETK 6.7L Diesel and DF2 Transmission Only). 1-2 hard shift. 3-4 flare issue fix. Trans quick learn fix(Gas Engine Only). Transmission oil temperature light illumination during high engine and tow loads. Less than desired towing performance while using cruise control. Harsh engagement while shifting from neutral to drive, neutral to reverse,or park to reverse with vehicle still in motion (rolling garage shift). Engine flare during 2-1 tip in downshift. Less than desired shift quality during 6-5 and 5-4 coasting downshifts. Delayed downshifts in Tow/Haul mode while driving down grades. Less than desired transmission shift performance when transitioning froma low traction to high traction surfaces i.e. ice covered road to clear pavement. Less than desired shift points during light pedal and Wide Open Throttle(WOT) operation or while in Tow/Haul and engine brake modes. 1-2 upshift shudder correction(Diesel engine and DF2 Transmission Only). A harsh 1-2 upshift(DF2 Transmission Only). Excessive gear shifting(DF2 Transmission Only). Harsh 2-1 downshift(DF2 Transmission Only). Delayed engagement when shifting from neutral to drive, neutral to reverse,or park to reverse (garage shifts)(DF2 Transmission Only). Audible squawk noise on 4-3 downshift(DF2 Transmission Only). Poor vehicle acceleration in first gear with vehicle fully loaded(DF2 Transmission Only). MIL illumination with no defect found forDTC P253D - PTO Sense Circuit High(DF2 Transmission Only). |
| 18-062-14 | 2022-08-22. Service bulletin. Flash: 6.7L Diagnostic and System Improvements This bulletin involves selectively erasing and reprogramming the Engine Control Module (ECM) with new software. Several software improvements are available for vehicles equipped with a Cummins 6.7L Turbo Diesel. These improvements are separated into the following categories.Prevent Or Reduce Unnecessary Malfunction Indicator Lamp (MIL) Illumination For The Following Diagnostic Trouble Codes (DTCs). These DTCs Are Currently Set As A One Trip Fault And Should Be A Two Trip Fault: P0201 - P0206 - Fuel Injector X Circuit/Open. U110E - Lost Ambient Temperature Message. P049D - EGR Control Position Exceeded Learning Limit.These DTCs Are Currently Set As A Two Trip Fault And Should Have Been A One Trip Fault: U12A4 - LOST COMMUNICATION WITH AMMONIA SENSOR Improvements To Prevent Or Reduce Unnecessary Malfunction Indicator Lamp (Mil) Illumination For: P2281 - Air Leak Between MAF and Throttle Body. U3017 - Control Module Timer/Clock Performance. U1421 - Implausible Ignition Key Off Time Received. P0128 - Thermostat Rationality. In cold ambient temperatures. P0087 - Fuel Rail Pressure Too Low. P0544 - Exhaust Gas Temperature Sensor Circuit - Bank 1 Sensor 1. P2002 - Diesel Particulate Filter Efficiency Below Threshold. P061A - Level 2 Torque Performance. P0234 - Turbocharger Over boost condition. P026A - Charge Air Cooler Efficiency Below Threshold. P0299 - Manifold Pressure Sensor Out of Range Low. P0544 - Exhaust Gas Temperature (EGT) Sensor Circuit - Bank 1 Sensor 1. P0562 - Battery Voltage Low. P20EE - SCR NOX Catalyst Efficiency Below Threshold - Bank 1. P2201 - Aftertreatment NOX Sensor Circuit Performance - Bank 1 Sensor 1. P24A5 - EGR Cooler Bypass Bank 1 Control Stuck. P2459 - Diesel Particulate Filter Regeneration Too Frequent. P249E - Closed Loop SCR Reductant Injection Control At Limit - Flow Too High. |