Service bulletin 9004345
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10187015 |
| Published by NHTSA | 2021-02-16 |
| Manufacturer's number | 9004345 |
| Manufacturer's date | 2021-01-20 |
| NHTSA component | ENGINE AND ENGINE COOLING |
NHTSA's summary
COOLER, EGR If you are replacing the high pressure EGR cooler (p/n 68490113A$) for a suspected internal coolant leak that was detected by wetness in the EGR pipe or valve, please perform proper cooling system pressure test first to verify the leak. Refer to all published service information regarding Cooling Diagnosis and Testing (LEAK TESTING) before proceeding.
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Engine
| JEEP WRANGLER | 2020, 2021 |
|---|---|
| RAM 1500 | 2020, 2021 |
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 2023221 | 2023-04-13. Engine |
|---|---|
| 22V865000 | 2022-11-23. ENGINE |
| 2022584 | 2022-10-14. Engine |
| 22V767000 | 2022-10-13. ENGINE; FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP |
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| 9100898 | 2026-09-17. Service bulletin. Engine PNs: MY 24-26 WD/DT (5.7L) Code P00B is being misdiagnosed and incorrect parts are being installed causing over repair. Refer to SOL S2609000006 The IAFM Foam Engine Valley Cover (PN 53013735AB) does not provide sufficient clearance for proper routing of the MDS solenoid jumper harness (PN 05148163AE). As a result, the harness may become compressed by the foam cover. To prevent unnecessary part replacement, the MDS solenoid jumper harness (PN 05148163AE) should be inspected for damage or pinch conditions prior to replacing the following part numbers: Engine PNs: 68409343AA 68409357AA 68450915AA OCV PNs: 53022338AB Phaser PNs: 53022298AA 53022298AB |
|---|---|
| 9100363 Rev 3 | 2026-09-03. Service bulletin. Turbocharger Kit Please note that many turbo components are serviceable separately and full turbo replacement may not be required. If the turbo is being inspected for: Noise/Rattle: Inspect heat shield fasteners for looseness and check the wastegate actuator/linkage for binding. The actuator kit is serviced separately. Oil Leak: Inspect the turbo oil feed O-ring area for leaks. O-ring is serviced separately. |
| 113271 | 2026-07-18. Service bulletin. CORE – HEATER |
| 113270 | 2026-07-18. Service bulletin. CORE – HEATER |
| 112639 | 2026-07-08. Service bulletin. THROTTLE BODY – NONE |
| 112640 | 2026-07-08. Service bulletin. THROTTLE BODY – NONE |
| S2609000009 | 2026-07-02. Service bulletin. Check Engine Light (CEL) Illuminated with Diagnostic Trouble Code (DTC) P0106 Manifold Absolute Pressure Sensor Performance Setting In The Powertrain Control Module (PCM) |
| 112842 | 2026-07-02. Service bulletin. BOLT - HEX FLANGE HEAD |
| 9100839 | 2026-06-18. Service bulletin. 3-way valves are available in STAR Parts as two distinct components and must be selected correctly based on application. The High Temp 3-way valve (68309834AC) is located between the engine and the bulkhead at the rear of the engine compartment. The Low Temp 3-way valve (68448241AA) is located between the engine and the radiator at the front of the engine. When ordering or servicing, ensure the correct valve is identified and installed in the proper location, as incorrect part selection may lead to improper thermal system operation and repeat repairs. |
| 9100702Rev1 | 2026-04-15. Service bulletin. Camshaft cap bolts within the cylinder head assembly may cause damage to other components. DO NOT replace entire long block when only left OR right cylinder heads need to be replaced. |