Service bulletin 18-012-19 REV A
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10162571 |
| Published by NHTSA | 2019-07-15 |
| Manufacturer's number | 18-012-19 REV A |
| Manufacturer's date | 2019-05-29 |
| NHTSA component | POWER TRAIN |
NHTSA's summary
Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the PCM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following DTCs have been set:P0456 - EVAP System Small Leak. P0128 - Thermostat Rationality. The following software enhancement is included:Enable Soot Retention for vehicles equipped with Gasoline Particulate Filter (GPF).
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Transmission and driveline
Trouble codes named
P0128, P0456
| JEEP WRANGLER | 2019 |
|---|
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| 2023089 | 2023-02-23. Powertrain |
|---|---|
| 23V116000 | 2023-02-23. POWER TRAIN:CLUTCH ASSEMBLY |
| 2021035 | 2021-01-28. Powertrain |
| 21V028000 | 2021-01-28. POWER TRAIN:CLUTCH ASSEMBLY |
| 2020083 | 2020-03-03. Powertrain |
| 20V124000 | 2020-03-03. POWER TRAIN:CLUTCH ASSEMBLY |
A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.
| S2621000004 | 2026-10-07. Service bulletin. The Customer May Complain About a Popping Noise, Grinding Noise, or an Intermittent No Reverse or Forward Transmission Engagement. The Tech May Find Damaged and/or Worn Transmission Output Shaft Splines (850RE Transmission Only) |
|---|---|
| 18-062-26 | 2026-07-02. Service bulletin. Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● **P0420 - Catalyst System Efficiency Below Threshold Bank 1. ● P0430 - Catalyst System Efficiency Below Threshold Bank 2.** ● P0456 - EVAP System Small Leak. Customers may also comment on one or more of the following: ● **Vehicle fails emissions inspection testing.** ● Pinging/detonation sound from the engine after warm up at 1000-1500 RPM at low speed. (EMEA and APAC Only). ● The vehicle stalls at low speeds and/or coming to a stop This bulletin involves reprogramming the PCM with the latest available software. |
| S2621000003 REV.A | 2026-03-18. Service bulletin. The vehicle will exhibit a service transmission/check engine warning indicator for the following transmission models: 845RE, 8HP45, 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV, 8HP75-LCV, 8HP90, 8HP95. Transmissions may exhibit the following diagnostic codes: P07E4, P1DB2, P0716, P1B14, P0733, P1D90, P1DB7, P1B13. |
| S2621000003 | 2026-03-05. Service bulletin. Service transmission/check engine warning indicator for the 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV transmissions that have fault codes P07E4, P1DB2, P0716, P1B14, P0733, P1D90, P1DB7, P1B13. |
| 9100627 | 2025-07-23. Service bulletin. To inform dealers about the 850RE valve body PN: R8348504A connector: the original 16-pin connector included six pins that were not used in this application. To simplify the design, the connector has been optimized and updated to a 10-pin configuration. |
| 9100534 Rev 1 | 2025-05-19. Service bulletin. Transmission "Transmission For transmission concerns related to DTCs P0733-00, P1DA8-00, and/or P1D92-00, a repair is available, and transmission replacement is NOT required. Please reference TSB 21-009-25 Rev. A, for details on D-clutch replacement. Please also note, visible ""glitter"" or debris in the pan and fluid color/condition/odor is NOT an indicator of transmission health and should not be used as the reason for unit replacement. Complete unit replacements instead of repairs for these DTCs may be subject to chargeback." |
| 9100534 | 2025-03-28. Service bulletin. "Transmission For transmission concerns related to DTCs P0733-00, P1DA8-00, and/or P1D92-00, a repair is available, and transmission replacement is NOT required. Please reference TSB 21-009-25 Rev. A, for details on D-clutch replacement. Please also note, fluid color/condition/odor is NOT an indicator of transmission health and should not be used as the reason for unit replacement. Complete unit replacements instead of repairs for these DTCs may be subject to chargeback." |
| 101232 | 2024-11-07. Service bulletin. Plate - Planetary |
| S2403000002 | 2024-08-12. Service bulletin. Griding/Gear Clash From Transfer Case When Going Into 4WD, Above 5 mph (8 kph). |
| 99500 | 2024-07-31. Other. CARRIER – PLANETARY & SHAFT KIT - OUTPUT |