# Service bulletin PIT5412D

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

- Type: Service bulletin
- NHTSA id: 10161005
- Published by NHTSA: 2019\-06\-10
- Manufacturer's number: PIT5412D
- Manufacturer's date: 2019\-05\-13
- NHTSA component: EXTERIOR LIGHTING:HEADLIGHTS

## NHTSA's summary

This Preliminary Information communication provides information to the technician about vehicles that have either the truck or the snowplow's headlights are flickering or inoperative. There may be a diagnostic trouble code B2575 and or a B2699 set in the body control module. Technician will need to contact the snowplow manufacturer for additional information on their headlight changeover system. Technician is to refer to the latest version of the General Motors up\-fitter integration bulletin 116 for additional information these circuits. Technician can find this information at http://www.gmupfitter.com/, under the "Technical Bulletin" Tab and then "Show all bulletins."

## The document

- [NHTSA's copy of the document (PDF)](https://static.nhtsa.gov/odi/tsbs/2019/MC-10161005-0001.pdf)
- [If that address does not open, try this one](https://static.nhtsa.gov/odi/tsbs/2019/MC-10161005-9999.pdf)

The document is the manufacturer's. This site does not hold it.

## Components

Lighting, Headlights

## Trouble codes named

B2575, B2699

## Vehicles listed

- 2017 CHEVROLET SILVERADO
- 2014 CHEVROLET SILVERADO 1500
- 2015 to 2016 CHEVROLET SILVERADO 2500
- 2018 to 2019 CHEVROLET SILVERADO 2500
- 2019 CHEVROLET SILVERADO 4500
- 2017 GMC SIERRA
- 2014 to 2016 GMC SIERRA 1500
- 2019 GMC SIERRA 2500
- 2018 GMC SIERRA 3500
- 2019 GMC SIERRA DENALI

## Other bulletins for the same vehicles and component

- [PIT5546G](/bulletins/10171311.md), 2020-02-10, Service bulletin: EXTERIOR LIGHTING:HEADLIGHTS; ELECTRICAL SYSTEM; EXTERIOR LIGHTING. This Preliminary information communicates that water leaking into the headlamp assembly or headlamp assembly connections can cause an electrical short which will keep modules from shutting down causing a dead battery and a no crank condition, a crank no start, or unable to program the engine control module. Engine control module will set a diagnostic trouble code of P1682, or the engine will continue to run with the ignition off.
- [PIT3219F](/bulletins/10161011.md), 2019-06-10, Service bulletin: ELECTRICAL SYSTEM; EXTERIOR LIGHTING:HEADLIGHTS. This Preliminary Information communicates to technicians that the Daytime Running Lamps \(DRL's\) or the auto headlamps will not shut off when using the daytime running lamp disable switch \(Which is part of the headlamp switch\), if the vehicles was built for Canada \(RPO Z49\). These vehicles were built with different software that doesn't allow the DRL's or Auto headlamp to be shut off. Canada law prohibits disabling daytime running lamps \(DRL's\) or auto headlamps.
- [PIT5374A](/bulletins/10139329.md), 2018-06-04, Service bulletin: EXTERIOR LIGHTING:HEADLIGHTS. This Preliminary Information communication provides information to the technician about vehicles with poor headlight performance when driving in very dark rural areas. Technician should perform normal diagnostics first. If no issue found or the customer is still has complaint the Body Control Module for vehicles built before 12/23/14 at Flint Assembly \(11th Vehicle Identification Number Digit "F"\), 1/13/15 at Silao Assembly \(11th Vehicle Identification Number Digit "G"\) or 1/16/15 at Ft. Wayne Assembly \(11th Vehicle Identification Number Digit "Z"\). Technician should replace both headlights with part number 23342527. After the headlights are replaced a headlamp aiming procedure should be performed.
- [PIT3219E](/bulletins/10137526.md), 2018-05-21, Service bulletin: EXTERIOR LIGHTING:HEADLIGHTS:HIGH/LOW BEAM DIMMER SWITCH. This Preliminary Information communicates to techniciansthat the Daytime Running Lamps \(DRL\&\#39;s\) or the auto headlamps will not shut off when using the daytime running lamp disable switch \(Which is part of the headlamp switch\), if the vehicles was built for Canada \(RPO Z49\). These vehicles were built with different software that doesn\&\#39;t allow the DRL\&\#39;s or Auto headlamp to be shut off. Canada law prohibits disabling daytime running lamps \(DRL\&\#39;s\) or auto headlamps.
- [PIE0380C](/bulletins/10137350.md), 2018-05-21, Service bulletin: EXTERIOR LIGHTING:TURN SIGNAL; EXTERIOR LIGHTING:HEADLIGHTS:HIGH/LOW BEAM DIMMER SWITCH. This engineering informational bulletin is requesting information from the field on vehicles that have the condition of Both Front Low Beam, High Beam, Day Time Running Lamps \(DRL\) and Turn Signals Inoperative.
- [18NA046](/bulletins/10137330.md), 2018-05-21, Service bulletin: EXTERIOR LIGHTING:HEADLIGHTS:CONCEALMENT DEVICES. This technical bulletin provides repair information to correct a customer concern of a headlamp bezel loose or falling off.
- [18NA001](/bulletins/10137274.md), 2018-05-21, Service bulletin: EXTERIOR LIGHTING:HEADLIGHTS. This informational bulletin explains normal operation of HID bulbs when driving over road irregularities.
- [PIE0380B](/bulletins/10134601.md), 2018-04-23, Service bulletin: EXTERIOR LIGHTING:TURN SIGNAL; EXTERIOR LIGHTING:HEADLIGHTS. This engineering informational bulletin is requesting information from the field on vehicles that have the condition of Both Front Low Beam, High Beam, Day Time Running Lamps \(DRL\) and Turn Signals Inoperative.
- [PIT5412C](/bulletins/10129077.md), 2018-02-21, Service bulletin: STRUCTURE; EXTERIOR LIGHTING:HEADLIGHTS; EXTERIOR LIGHTING:HEADLIGHTS:SWITCH. This Preliminary Information communication provides information to the technician about vehicles that have either the truck or the snowplow\&\#39;s headlights are flickering or inoperative. There may be a diagnostic trouble code B2575 and or a B2699 set in the body control module. Technician will need to contact the snowplow manufacturer for additional information on their headlight changeover system. Technician is to refer to the latest version of the General Motors up\-fitter integration bulletin 116 for additional information these circuits. Technician can find this information at http://www.gmupfitter.com/, under the "Technical Bulletin" Tab and then "Show all bulletins."
- [PIE0380](/bulletins/10118993.md), 2017-10-15, Service bulletin: EXTERIOR LIGHTING:HEADLIGHTS:HIGH/LOW BEAM DIMMER SWITCH. This engineering informational bulletin is requesting information from the field on vehicles that have the condition of Both Front Low Beam, High Beam, Day Time Running Lamps \(DRL\) and Turn Signals Inoperative.

JSON: [/v1/bulletins/10161005](/v1/bulletins/10161005)

[Report an error on this page](https://github.com/wenmar-pro/wenmar-open/issues/new?template=data_correction.yml&title=Data%20correction%3A%20Service%20bulletin%20PIT5412D&page=https%3A%2F%2Fopen.wenmarpro.com%2Fbulletins%2F10161005&vehicle=Service%20bulletin%20PIT5412D)