Service bulletin PIC6243E
A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.
| Type | Service bulletin |
|---|---|
| NHTSA id | 10160397 |
| Published by NHTSA | 2019-06-03 |
| Manufacturer's number | PIC6243E |
| Manufacturer's date | 2019-04-01 |
| NHTSA component | POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM) |
NHTSA's summary
This Preliminary Information communication advises the technician that the Hybrid Powertrain Control Module 2 will be placed on a parts restriction through the General Motors Technical Assistance Center. Dealer will need to contact General Motors Technical Assistance Center for further assistance.
The document
The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.
Components
Transmission and driveline, Automatic transmission, Transmission control module
| CHEVROLET BOLT EV | 2017, 2018, 2019 |
|---|---|
| CHEVROLET VOLT | 2016, 2017, 2018, 2019 |
Listing a model year does not mean every vehicle of it is concerned: the document says which.
| PIP5621C | 2022-10-17. Service bulletin. This Preliminary information communicates to the dealer technician that TAC recommends the utilization of the GDS2 software to aid in diagnosing automatic transmission concerns. TAC is requesting the GDS2 session logs be sent in before the dealer contacts TAC. |
|---|---|
| N202307990 launc | 2022-02-07. Service bulletin. Customer Satisfaction Program. Certain vehicles may have a condition related to the high voltage battery which could gradually lose the ability to maintain voltage. If battery concerns are not addressed, the vehicle could enter a reduced propulsion mode while driving, or lose propulsion, or it may not start. Dealers are to update the Hybrid Powertrain Control Module (HPCM2). This software update is intended to increase the amount of warning time provided. |
| PIC6448 | 2021-12-13. Service bulletin. This Preliminary information communicates That Techline connect is Not supporting the progaming of the T6 PIM / HPCM. and advies them to call Techline. |
| 06-00-89-031D | 2021-09-07. Service bulletin. OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification |
| 990420002L | 2021-08-09. Service bulletin. This service bulletin provides information on Driveline Clunk Noise and what is acceptable and what is considered normal operation. |
| 06-00-89-031D | 2021-04-20. Service bulletin. OEM and Remanufactured Engine and Automatic Transmission/Transaxle Identification |
| 17-NA-328 | 2021-04-15. Service bulletin. Malfunction Indicator Lamp (MIL) Illuminated - DTC P1AE6 Set Important: Stable battery voltage is critical during programming. Any fluctuation, spiking, over voltage or loss of voltage will interrupt programming. Install the EL-49642 SPS Programming Support Tool to maintain system voltage. If not available, connect a fully charged 12 V jumper or booster pack disconnected from the AC voltage supply. DO NOTconnect a battery charger. Refer to Hybrid Powertrain Control Module 2 Programming and Setup in SI. |
| 16-NA-407 4 | 2021-04-14. Service bulletin. Information on Chassis Control Module (CCM) and Hybrid Powertrain Control Module (HPCM) Receives Invalid Data and Sets DTC U0422 The technician may find DTC U0422 set. The technician may also find the following DTCs set: • U1534 • U1538 Based on analysis with the BCM and Hybrid Powertrain Control Module (HPCM) teams, during vehicle startup (on occasion) the PEPS module arbitration along with high bus traffic leads to the BCM or HPCM setting the door open switch virtual device availability (VDA) to unavailable. The BCM or HPCM does not update the VDA back to Available until the door switch changes state (this signal is event based as opposed to periodic). The ICCM and HPCM sets the U0422 DTC after 1 second of either the door ajar VDA or door open VDA being unavailable |
| 16-NA-175 | 2021-04-13. Service bulletin. SHAKE AND/OR SHUDDER DURING LIGHT THROTTLE ACCELERATION BETWEEN 40 AND 128 KM/H (25 AND 80 MPH) AT A STEADY STATE. |
| 150089004C | 2021-03-08. Service bulletin. This service bulletin provides technicians with updated information to help identify the differences between what is considered a fluid leak, and what is considered fluid seepage. |