Service bulletin 541309

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
Type	Service bulletin
NHTSA id	10149603
Published by NHTSA	2018-11-26
Manufacturer's number	541309
Manufacturer's date	2013-05-01
NHTSA component	VISIBILITY

NHTSA's summary

"Panoramic Sunroof Repair Instructions. INFORMATION Sunroof Repair Instructions: The panoramic sunroof contains several ""mechanism sets"" which can be repaired and/or replaced independently in the event of a mechanical failure. When performing such a repair to any of these sets, the TIS/ISTA Repair Instructions (REP) should always be consulted. Due to the complex nature of these repairs, a set of complementary instructions with additional detail, explanation, and photos has been developed. The attached Repair Instructions should always be used in conjunction with the TIS/ISTA REP. Refer to the following repair attachments: Front Glass Mechanism repair E53, E61, E70, E83, E91.pdf Rear Glass Mechanism repair E53, E61, E70, E83, E91.pdf Wind Deflector Mechanism repair E53, E61, E70, E83, E91.pdf Sunshade Mechanism repair E53, E61, E83.pdf Sunshade Mechanism repair E70, E91.pdf All panoramic roofs for the above-listed models are conceptually similar and utilize similar repairs. NOTE: An E83 (X3) sunroof cassette is used for demonstration of the repairs. Some differences may exist between this and other models. The following prerequisite work is required in order to replace the following kits (in addition to removing the cassette from the car and glass from the cassette): Front Glass Mechanism - None. Rear Glass Mechanism - Remove the front glass mechanism. Wind Deflector Mechanism - Remove the front glass mechanism; remove the rear glass mechanism. Sun shades and Shade Mechanism - None Sunroof Mechanical 3D Animation: A 3D animation has been developed in order to clarify how the sunroof mechanism operates, as well as how it is assembled and disassembled. To view this animation, open Interactive Career Pathways (ICP) and select ""Replace Front and Rear Glass Panel Mechanic"" from the Technical Service Information section of the home page. This animation allows you to: * Operate the mechanism and view from any angle; * Add or remove parts and then cycle the sunroof; * S

The document

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Glass, wipers and mirrors

Vehicles listed
BMW 325XIT	2006 (the catalog's model; the bulletin names a series or trim of it)
BMW 328I	2007, 2008, 2009, 2010, 2011, 2012
BMW 328XI	2007, 2008
BMW 328XI	2009 to 2012
BMW 530XI	2006, 2007
BMW 535I	2008, 2009, 2010
BMW X3	2004, 2005, 2006, 2007, 2008, 2009, 2010
BMW X5	2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013
BMW X5 M	2010 to 2012

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
10V025000	2010-01-28. VISIBILITY:WINDSHIELD
2010017	2010-01-26. Visual System

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
B510819	2024-02-01. Service bulletin. The basic conditions for initializing the power windows are not met.
B540421	2023-11-01. Service bulletin. This situation can result in two customer complaints: 1. Wind noise 2. Excess water entry
B540421	2022-10-31. Service bulletin. The front sunroof glass seal has shrunk, creating a gap which can cause wind noise or excess water entry.
B510415	2021-05-17. Service bulletin. The customer complains of rattling noises from the rear window when driving on rough roads.
B612315	2020-12-21. Service bulletin. Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full: Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full.There are no faults stored in the system for the washer fluid level switch.
B612315	2019-12-16. Service bulletin. Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full : The low washer fluid warning is illuminated even though the washer fluid reservoir is full. There are no faults stored in the system for the washer fluid level switch. A non-approved washer fluid was used that is silicone-based. Silicone-based fluids are not compatible with the contactless capacitive level sensor. Fluids that contain a silicone additive are normally colored other than blue.
B512519	2019-09-23. Service bulletin. GROANING NOISE WHEN OPENING/CLOSING FRONT WINDOWS. A groaning noise can be heard from the front door(s) when opening or closing the power windows.
B610819	2019-07-22. Service bulletin. Service Information June 2019 General Electrical Systems B61 08 19 Technical Service WINDSHIELD WIPERS SWITCH ON BY THEMSELVES. The windshield wipers switch on by themselves and can no longer be switched off despite activation of the switch. An internal software error in the SZL (steering column switch cluster).
660612	2019-07-12. Service bulletin. Lane Change Warning Lamps on Side View Mirrors Are Too Dark. The lane change warning lamps (small and triangle-shaped) on the exterior door mirrors are too dark. This may occur when driving from light to dark conditions, such as: * Entering a tunnel * At twilight CAUSE: RLSS (Rain Light Solar Sensor) hardware error.
Radio and Air Co	2019-07-12. Service bulletin. "Service Action: Program Control Units (FEM). One or more of the following situations may occur when using the windshield wipers: * After the wipers are switched off, they do not remain in the park position, but in the middle of the windshield. * The wipers continue to operate even when the ignition is switched off. * The wipers only partially moved when switched on. * Hazard warning lights flash permanently. * Vehicle locks and unlocks on its own. * Interior lights turn on by themselves. * The trunk lid cannot be opened. AFFECTED VEHICLES This Service Action involves F30 which were produced October 2011 to August 2012. In order to determine whether a specific vehicle has had this Service Action completed or is affected by this Service Action, first check the B-pillar label for code number 631. If code number 631 has been punched out, the campaign has already been performed. If code number 631 has not been punched out, it will be necessary to utilize the "Service Menu" of DCSnet (Dealer Communication System) or the Key Reader. Based on the response of the system, either proceed with the corrective action or take no further action."