Service bulletin 161214

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

The communication, as NHTSA indexes it (as of 2026-10-19)
Type	Service bulletin
NHTSA id	10148026
Published by NHTSA	2018-11-13
Manufacturer's number	161214
Manufacturer's date	2014-09-01
NHTSA component	FUEL SYSTEM, GASOLINE; ENGINE

NHTSA's summary

Service Action: Replace Fuel Tank Pressure Sensor. The internal sealing of the fuel tank pressure/temperature sensor may fail. As a result, the sensor may read an incorrect value and set a fault code for the fuel tank evaporation system. This may lead to the Check Engine Light (CEL) being illuminated.

The document

The document is the manufacturer's. This site does not hold it. NHTSA files a document at one of these two addresses; we have not asked NHTSA which.

Components

Engine, Fuel system

Vehicles listed
BMW I3	2014, 2015

Listing a model year does not mean every vehicle of it is concerned: the document says which.

Recalls for the same vehicles and component
2017068	2017-02-10. Fuel System
17V088000	2017-02-09. FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

A recall listed here may apply to some of the same vehicles. Only the manufacturer can say whether it applies to one vehicle.

Other bulletins for the same vehicles and component
B012021	2021-12-27. Service bulletin. For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the vehicle's Fuel Injectors to: 15 years/150,000 miles as determined by the vehicle's original in-service date.
B640621	2021-12-13. Service bulletin. Different air temperatures are felt from left to right out of the front fresh air grilles (air vents).
B010321	2021-02-22. Service bulletin. I3 REX FRONT (UPSTREAM) OXYGEN SENSOR: If a vehicle listed above arrives with engine malfunction indicator (Check Engine) warning light on, performing a Vehicle Test.
B120920	2020-10-19. Service bulletin. I01 REX MISFIRES AT HIGH ALTITUDES USING WINTER-BLEND FUEL: The check engine light (MIL) is displayed, and in some cases the range extender (REx) engine will run rough for about 1 to 2 seconds during cold start.
B130420	2020-06-15. Service bulletin. TANK VENTILATION AND MIXTURE CONTROL FAULTS STORED IN THE DME: The Engine Malfunction Warning is illuminated and one or more of the following faults are stored in the DME. All models: FC 191C02 - Fuel tank ventilation system 2nd discharge point: malfunction FC 195014 - Differential pressure sensor tank vent valve signal: fixed FC 118001 - Mixture control: mixture too lean FC 118401 - Mixture control: mixture too lean large deviation I01 only: FC 124103 - Mixture control: mixture too lean FC 124101 - Mixture control: Mixture lean large deviation CAUSE Internal mechanical defect in the tank ventilation valve. The defect can also result in a very loud clicking noise when the valve is cycling.
B640120	2020-04-20. Service bulletin. AIR CONDITIONING DOES NOT COOL: The air conditioning no longer cools the vehicle. A vehicle test reveals one or both of the following faults stored in the IHX_I1 Control Module: 801295 - Heat Pump pressure-temperature sensor 2 after air condition compressor: pressure short to ground / open circuit 80112A - Heat Pump pressure-temperature sensor 2 after air condition compressor: temperature - short to ground A short circuit at the temperature sensor due to aluminum particles in the high-pressure line.
B610520	2020-04-20. Service bulletin. CCM DISPLAYED "INCREASED BATTERY DRAIN" CAUSED BY CONTROLLER: This Service Information Bulletin (Revision 1) replaces SI B61 05 20 dated February 2020. Electrostatic discharge at standstill / start engine. Energy management" The results of the Energy Diagnosis test plan identifies the Controller as the root cause of the CCM. The Controller delays the vehicle going to sleep by up to 6 minutes. In some cases this will cause the CCM 415 to be displayed when starting the vehicle. Replacing the Controller in this case will not correct this situation.
B321119	2020-04-20. Service bulletin. SPORADIC REDUCTION OF STEERING ASSISTANCE: This Service Information Bulletin (Revision 1) replaces SI B32 11 19 dated October 2019. The driver notices a reduction of steering assistance sporadically while in certain driving situations. Steering control is never lost when the reduction of assistance occurs. The fault may self-correct for no obvious reason or be eliminated with a terminal change/key cycle. There is no Check Control (CC) message when the issue occurs. Unfavorable software in the Electric Power Steering (EPS).
B160318	2019-02-25. Service bulletin. SERVICE ACTION: REPLACE THE FUEL TANK PRESSURETEMPERATURE SENSOR. The internal sealing of the fuel tank pressure-temperature sensor may fail.
B220415	2018-12-10. Service bulletin. A sudden loss of traction while accelerating sharply may damage the engine mounts.