# Service bulletin PC630

A bulletin is a manufacturer's communication to its dealers, as NHTSA indexes it. The summary is NHTSA's. The document is the manufacturer's: read it at NHTSA. A bulletin is not a recall, and listing a model year does not mean every vehicle of it is concerned.

- Type: Service bulletin
- NHTSA id: 10143280
- Published by NHTSA: 2018\-07\-30
- Manufacturer's number: PC630
- Manufacturer's date: 2018\-06\-06
- NHTSA component: ELECTRICAL SYSTEM

## NHTSA's summary

30 kWh Lithium\-ion Battery Controller \(LBC\) Reprogram Voluntary Service Campaign \*\*\*\*\* Campaign Summary\*\*\*\*\* Nissan is conducting a Voluntary Service Campaign to reprogram the 30 kWh Lithium\-ion Battery Controller \(LBC\) in 2016\-17 model year LEAF vehicles. Nissan data gathering has shown the vehicle?s driving range gauge and Lithium\-ion battery capacity level gauge may indicate a range/capacity that is lower than the actual amount due to a design issue associated with an improper capacity calculation. This error results in an understated remaining charge and driving distance available. \*\*\*\*\* What Dealers Should Do \*\*\*\*\* 1. Verify if vehicles are affected by this Voluntary Service Campaign using Service Comm or DBS National Service History \- Open Campaign I.D. PC630. \- New vehicles in dealer inventory can be also be identified using DCS \(Sales\-\> Vehicle Inventory, and filter by Open Campaign\). \- Refer to NPSB 15\-460 for additional information 2. Nissan requests dealers repair any affected vehicles in retailer new or pre\-owned inventory to ensure customer satisfaction. 3. Dealers should use NTB18\-039 to correct any vehicles subject to this campaign. 4. Once repaired, dealer should submit a warranty claim and release the vehicle.

## The document

- [NHTSA's copy of the document (PDF)](https://static.nhtsa.gov/odi/tsbs/2018/MC-10143280-9999.pdf)
- [If that address does not open, try this one](https://static.nhtsa.gov/odi/tsbs/2018/MC-10143280-0001.pdf)

The document is the manufacturer's. This site does not hold it.

## Components

Electrical system

## Vehicles listed

- 2016 to 2017 NISSAN LEAF

## Recalls for the same vehicles and component

- [16V436000](/recalls/nhtsa/16V436000.md), 2016-06-15: AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE; ELECTRICAL SYSTEM:WIRING

## Other bulletins for the same vehicles and component

- [NTB13\-107G](/bulletins/11004962.md), 2024-07-19, Service bulletin: ELECTRICAL SYSTEM. VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- [NTB13\-027D](/bulletins/11004961.md), 2024-07-19, Service bulletin: ELECTRICAL SYSTEM. CAN COMMUNICATION – NETWORK DIAGNOSTIC FLOW CHART This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- [NTB10\-066C](/bulletins/11004960.md), 2024-07-19, Service bulletin: ELECTRICAL SYSTEM. CAN COMMUNICATION CODES – DIAGNOSTIC TIPS AND GUIDELINES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- [NTB23\-053](/bulletins/10239062.md), 2023-07-11, Service bulletin: ELECTRICAL SYSTEM. SILICONE\-BASED LUBRICANT OR GREASE CAN DAMAGE ELECTRICAL COMPONENTS SERVICE INFORMATION Do not apply Silicone\-based lubricants or grease to, or around, any interior electrical components. To avoid the risk of death or severe personal injury, do not directly spray Silicone\-based lubricant or grease, or inadvertently overspray Silicone\-based lubricant or grease onto any interior electrical components. These types of lubricants can be detrimental to the proper operation of electrical components.
- [NTB23\-049](/bulletins/10239060.md), 2023-07-11, Service bulletin: ELECTRICAL SYSTEM. 12 VOLT BATTERY TESTING FOR IN\-SERVICE VEHICLES SERVICE INFORMATION The following Service Information lists NNA procedural recommendations for establishing good connections while performing 12V battery testing. These recommendations are expected to promote uniformity during the connection process, therefore reducing the number of incorrect “Test with DCA” and “Replace” results. HINT: If 12 volt batteries are allowed to discharge for a prolonged period of time, battery life may be drastically reduced. This condition may lead to premature battery replacement and customer dissatisfaction. IMPORTANT: • CPX\-900 is now an accepted testing tool to use along with or in place of the DSS\-5000 • CPX\-900 operating instructions are found at: https://nissancpx900.midtronics.com/ • DSS\-5000 operating instructions are found at: https://nissandss5000.midtronics.com/ • DCA\-8000 is now a required testing tool to be used for all warranty replacement decisions. The DCA\-8000 is also a more efficient charger than previously available, and will charge any available 12 volt lead acid battery safely and accurately as long as all precautions and inputs are made correctly. The DCA\-8000 operating instructions are found at: https://nissandca8000.midtronics.com/
- [NTB16\-003C](/bulletins/10235710.md), 2023-05-05, Service bulletin: ELECTRICAL SYSTEM. INTELLIGENT KEY REPLACEMENT OR SWAPPING BETWEEN VEHICLES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Discard all previous versions of this bulletin.
- [NTB13\-107F](/bulletins/10235707.md), 2023-05-05, Service bulletin: ELECTRICAL SYSTEM. VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- [NTB15\-009L](/bulletins/10231857.md), 2023-02-18, Service bulletin: ELECTRICAL SYSTEM. NAVIGATION SYMPTOMS WHEN SD CARD IS MISSING OR WRONG CARD INSTALLED This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.
- [NTB22\-100](/bulletins/10227267.md), 2022-12-06, Service bulletin: ELECTRICAL SYSTEM. 3G TELEMATICS HARDWARE DEACTIVATION SERVICE INFORMATION The APPLIED VEHICLES that come equipped with a factory installed SOS switch, located near the overhead map lamp, also come equipped with a wireless communication device called a Telematics Communication Unit \(TCU\). AT\&T discontinued its U.S. 3G network coverage on February 22, 2022. As a result, automakers that utilize AT\&T’s 3G network connection, including Nissan Group, have had connectivity services affected. NissanConnect® Services are no longer available on the APPLIED VEHICLES listed above.
- [NTB22\-026](/bulletins/10213684.md), 2022-06-08, Service bulletin: ELECTRICAL SYSTEM:INSTRUMENT PANEL:FUEL GAUGE:FUEL LEVEL FLOAT/SENSOR/SENDING UNIT; ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE \(ECU/ECM\):SOFTWARE; FUEL SYSTEM, DIESEL; FUEL SYSTEM, GASOLINE. SERVICE INFORMATION FOR FUEL GAUGE INACCURATE WITH DTCS STORED IN ECM SERVICE INFORMATION If a fuel level sensor has been diagnosed as sending an incorrect level signal, and one or more of the following DTCs are stored in the ECM, do not replace the entire “Fuel Level Sensor Unit, Fuel Filter and Fuel Pump Assembly” \(fuel pump assembly\). The fuel level sensor can be replaced separately. • P0460 \(FUEL LEV SEN SLOSH\) • P0461 \(FUEL LEVEL SENSOR\) • P0462 \(FUEL LEVL SEN/CIRC\) • P0463 \(FUEL LEVL SEN/CIRC\) NOTE: Warranty claims referring to fuel level issues that result in the replacement of the entire fuel pump assembly will be charged back.

JSON: [/v1/bulletins/10143280](/v1/bulletins/10143280)

[Report an error on this page](https://github.com/wenmar-pro/wenmar-open/issues/new?template=data_correction.yml&title=Data%20correction%3A%20Service%20bulletin%20PC630&page=https%3A%2F%2Fopen.wenmarpro.com%2Fbulletins%2F10143280&vehicle=Service%20bulletin%20PC630)